Instructions / Assembly

ManualsBrandsToject ManualsFire Pit Patio SetsEufaula Gray 10-Piece Wicker Modern Outdoor Patio Conversation Sofa Set with a Steel Fire Pit and Dark Gray Cushions

Please keep this instruction manual for future reference

ITEM NO.： GYM 8

Assembly Instructions

42 Inch Gas Fire Pit

DANGER:

•

Shut off gas to the appliance.

•

Extinguish any open flame.

•

If odor continues, leave the area immediately

After leaving the area, call your gas supplier

or fire department.

WARNING: For Outdoor Use Only!

WARNING:

FOR YOUR SAFET Y:

If the information in this manual is not

followed

exactly, a fire or explosion may

Do not store or use

gasoline, or other flammable

vapors

and liquids, in the

vicinity of this or any

An LP-cylinder

not connected for

all not be stored in the vicinity of this or

any other appliance.

FIRE OR EXPLOSION HAZARD

If you smell gas:

•

Failure to follow these instructions could result in

fire or explosion, which could cause property

damage, personal injury, or death.

DANGER

CARBON MONOXIDE HAZARD

This appliance can produce

carbon monoxide which has

odor.

Using it in an enclosed space

can kill you.

Never use this appliance in

enclosed space such as a

camper, tent, car or home.

Installation and service must be

performed by a qualified installer,

service agency, or the gas supplier

INSTALLER: leave this manual with the applian ce.

CONSUMER: Retain this manual for future

reference.

WARNING:

result causing property damage,

personal injury or loss of life.

WHAT TO DO IF YOU SMEL L GAS:

Do not try lighting any appliance.

Do not touch any electrical switch; do

NOT use any phone in your building.

Immediately call your gas supplier from

a neighbor’s phone.

Follow the gas supplier’s instructions.

If you cannot reach your gas supplier.

Call the fire department.

Installation and service must be

performed by a qualified installer, service

agency or gas supplier. Save these

instructions for future reference. If you

are assembling this unit for someone

else, give this manual to him or her to

read and save for future reference.

other appliance.

use

WARNING:

Improper installation, adjustment,

alteration, service or maintenance can

cause

property damage, personal injury

Read

this installation, operating, and

maintenance

instructions thoroughly

before

installing or servicing this

equipment.

or loss of life.

READ INSTRUCTION MANUAL BEFORE ATTEMPTING TO

ASSEMBLE OR OPERATE THIS PRODUCT.

WARNING:

Summary of content (14 pages)

PAGE 1
ITEM NO.： GYM 8 Assembly Instructions 42 Inch Gas Fire Pit DANGER: FIRE OR EXPLOSION HAZARD If you smell gas: • Shut off gas to the appliance. • Extinguish any open flame. • If odor continues, leave the area immediately • After leaving the area, call your gas supplier or fire department. Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.
PAGE 2
Table of Contents Assembly..………………………………………....…7-10 Operating Instructions .........................................11-13 Maintenance...........................................................14 Care and Cleaning ................................................14 Troubleshooting ....................................................15 Service Parts................................................. 16 Table of Contents ..........................................................2 Safety Information.............
PAGE 3
Safety Information (continued) WARNING: You must provide propane gas and propane cylinder. Use a standard 20 lb. propane cylinder only. Use this heater only with a propane vapor withdrawal supply system. See Chapter 5 of the Standard for Storage and Handling of Liquefied Petroleum Gas, ANS/NFPA 58. Your local library or fire department should have this book. The pressure regulator and hose assembly supplied with the appliance must be used.
PAGE 4
Safety Information (continued) WARNING: Solid fuels shall not be burned in this appliance. The installation must conform with local codes or, in the absence of local codes, ANSIZ223. 1/NFPA54, NFPA58 Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2.
PAGE 5
Warranty 1 YEAR LIMITED WARRANTY • We warrant the metal frame and burner to be free of manufacturing defects to the original purchaser for one years. • Proof of purchase (dated register receipt) is required for warranty claims. WHAT IS NOT COVERED It remains the customer’s responsibility for freight and packaging charges to and from our service center. This warranty does not cover commercial use, acts of nature, fire, freezing and abusive use.
PAGE 6
Package Contents D E K J F C I G A B H M L A B C D E F G Door Frame Back Leg B Back Leg C Metal Lid Lava Rock Table Top with Burner Side Panel 1 1 1 1 1 1 1 H I J K L M 5 Side Panel with Window Back Panel Longer Ceramic Tile Shorter Ceramic Tile Gas Tank Support Cover 1 1 2 2 1 1
PAGE 7
Assembly 1 Assembling the Legs □ Attach Door Frame (Part A),Back Right Leg (Part B B) and Back Left Leg (Part C) to the Tabletop with Burner(Part F) by using (4) M6x10mm Bolts(Part AA). C NOTE: Do not completely tighten the bolts. A AA 2 Assembling Side Panels with Widow □ Attach Side Panel with Window (Part H) to the Legs (Parts A & B) by using (4) M6X25mm bolts (Part BB). □ Connect the Control Panel to the Side Panel with Window (Part H) by using (4) M5X10mm Bolts(Part CC) and (4) M5 Nuts(Part DD).
PAGE 8
Assembly 3 Assembling Side Panels and Back Panel □ Attach Side Panel (Part G) to the Legs (Parts A & C) by using (4) M6X25mm bolts (Part BB). BB □ Attach Back Panel (Part I) to the Legs (Parts B & C) by using (4) M6X25mm Bolts (Part BB). B I BB NOTE: Do not completely tighten the bolts. C G A 4 Assembling the Gas Tank Support □ Attach the Gas Tank Support (Part L) to the Side Panel (Parts G & H) by using (4) M6X25mm Bolts (Part BB).
PAGE 9
Assembly 5 Place the Ceramic Tile □ Place the Ceramic Tile(Parts J & K) into the Tabletop. K J 6 Assembling the Lava Rock □ Ensure the Lava Rock (Part E) are not placed on the ignition portion of the burner. □ NOTE: Ensure no glass stone is placed on the ignition portion of D the burner.Then place the Cover (E) on. NOTE:The cover must be removed when the burner is in E operation.Wait until the unit cools before installing the cover.
PAGE 10
Assembly 7 Assembling the Cylinder □ Put the cylinder into the Gas Tank Support (Part L), and secure the cylinder by tightening the screw in the gas tank support. Connect the hose and regulator to the cylinder. NOTE: The propane cylinder is sold separately. Use a standard 20 lb. propane cylinder only. Put the hose away from the bowl base during connect the propane cylinder. 8 □ Installing the AAA Battery Open the igniter and place the AAA Battery（EE） into the igniter. Then tighten clockwise.
PAGE 11
Operating WARNING: Never use this appliance for other than the intended use. DO NOT use this appliance to prepare food. Initial Lighting: When lit for the first time, the appliance emits a slight odor. This is a normal temporary condition caused by the “burn-in ” of internal paints and lubricants used i n the manufacturing process and does not occur again. Simply run the main burner on high for approximately 30 minutes.
PAGE 12
Operating (continued) LEAK TESTING OPERATION WARNING: A leak test must be performed annually or if a part of the gas system is replaced. WARNING: Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, damage to property, serious bodily injury, or death. LEAK TESTING: 1, Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with three parts water.
PAGE 13
Operating (continued) LIGHTING CAUTION: Keep the outdoor gas appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. CAUTION: Do NOT obstruct the flow of combustion and ventilation air. CAUTION: Check and clean burner/vent tubes for insects and insect nests. A clogged tube can lead to a fire.” 1. Make sure all labels, packaging and protective films have been removed from the outdoor fire pit. 2. Control knob must be in the “OFF” position (Figure 1). 3.
PAGE 14
Maintenance Storage between uses: □ Turn the control knob to “OFF” position. □ Disconnect LP source. □ Store heater upright in an area sheltered from direct contact with inclement weather (such as rain, sleet, hail, snow, dust and debris). □ If desired, cover heater to protect exterior surfaces and to help prevent build up in air passages. NOTE: Wait until heater is cool before covering. Storage during periods of extended inactivity or when transporting: □ Turn the control knob to “OFF” position.