Installation Instructions

Tie Down Engineering • 255 Villanova Dr. SW • Atlanta, Georgia 30336
3
Safety instructions
CAUTION: Please read the safety warnings and Instructions contained in this manual before
operating the lift hoist. Failure to obey the warnings contained herein could result in
personal injury or damage to the equipment; however, this information should not be a substitute
for routine accident prevention, but rather an addition to routine accident prevention.
GENERAL SAFETY INSTRUCTIONS:
1. Transportandhandleyourlifthoistwithcare.
2. UnpacktheTranzSportercarefullyandinspectforanydamagethatmayoccurduringtransportation.
 DONOTUSETHEHOISTIFANYPARTISDAMAGED
3. Pleaseobserveallsafetyandwarninglabelsattachedtothehoist.
4. Useonlyreplacementpartsfurnishedbythemanufacturer.
5. AlwayskeeptheareaaroundthebasesectionoftheTranzSporterhoistcleartohelpprevent
 slipping,trippingorfallingagainstthehoist.
6. DONOTALLOWANYONETOOPERATETHETRANZSPORTERHOISTWHOHASNOTBEENTHOROUGHLY
 ANDPROPERLYTRAINEDINTHECORRECTOPERATIONANDUSEOFTHISHOIST.
7. Thishoistismanufacturedtoliftmaterialsonly.Donotusethelifthoistforthepurposeof
 transportingpersonnelfromoneleveltoanother.
8. Donotclimbthelifthoistoruseasapersonnelladder.
9. Donotoverload-maximumliftingcapacityfortheLH200is200lbs.withaloadcapacityof180lbs.
10. Keephands,feetandotherbodypartsaswellasclothingawayfromthetracksectionsandmovingor
 rotatingpartsofthehoistwhenstartingtheengineorwhenoperatingthehoist.
11. Donotallowanypersonstowalkorworkunderornearthehoistwhileinoperation.
12. Donotusethishoisttotransporthotasphaltoranyotherhotmoltensubstancefromone
 elevationtoanother.
13. Storeallpartsofthehoistinsuchafashionasnottodamageanyofthecomponents.
14. Donotoperateindoorsorinanareawithpoorventilation.
Warning labels are attached to the LH200
and are weather resistant. If you notice any
of these decal’s missing from your hoist,
please contact TIE DOWN ENGINEERING for a
replacement label.
Remember: Safety First!!
15640-2
WARNING
DO NOT REMOVE THIS TAG!
SHOCK HAZARD
KEEP ENTIRE LIFT HOIST
CLEAR OF ALL UTILITY
AND ELECTRICAL WIRING!
15641-2
DO NOT REMOVE THIS TAG!
IMPORTANT SAFETY INFORMATION
• TOP OF HOIST MUST BE SECURED TO ROOF USING “S” HOOKS (PROVIDED)
AND TWO LENGTHS OF ROPE (NOT PROVIDED)
• BRAKE TENSION SPRINGS MUST BE CHECKED FOR CORRECT TENSIONING DAILY
(BEFORE USE) IN ORDER TO PREVENT LOAD SLIPPAGE
• KEEP BRAKE DRUMS AND BRAKE SHOES FREE OF OIL, LUBRICANTS, AND
EXCESSIVE MOISTURE, CHECK FOR DAILY WEAR AND REPLACE WHEN NECESSARY
• DO NOT OPERATE THIS UNIT IF ANY COMPONENT PARTS EXHIBIT DAMAGE
OR WEAR. THIS INCLUDES ALL TRACK SECTIONS
WARNING
SAFETY LATCH MUST BE
ENGAGED WHEN LIFT
HOIST IS NOT IN USE
DO NOT REMOVE THIS TAG!
15642-2
15640-2
WARNING
DO NOT REMOVE THIS TAG!
SHOCK HAZARD
KEEP ENTIRE LIFT HOIST
CLEAR OF ALL UTILITY
AND ELECTRICAL WIRING!
15641-2
DO NOT REMOVE THIS TAG!
IMPORTANT SAFETY INFORMATION
• TOP OF HOIST MUST BE SECURED TO ROOF USING “S” HOOKS (PROVIDED)
AND TWO LENGTHS OF ROPE (NOT PROVIDED)
• BRAKE TENSION SPRINGS MUST BE CHECKED FOR CORRECT TENSIONING DAILY
(BEFORE USE) IN ORDER TO PREVENT LOAD SLIPPAGE
• KEEP BRAKE DRUMS AND BRAKE SHOES FREE OF OIL, LUBRICANTS, AND
EXCESSIVE MOISTURE, CHECK FOR DAILY WEAR AND REPLACE WHEN NECESSARY
• DO NOT OPERATE THIS UNIT IF ANY COMPONENT PARTS EXHIBIT DAMAGE
OR WEAR. THIS INCLUDES ALL TRACK SECTIONS
WARNING
SAFETY LATCH MUST BE
ENGAGED WHEN LIFT
HOIST IS NOT IN USE
DO NOT REMOVE THIS TAG!
15642-2
15640-2
WARNING
DO NOT REMOVE THIS TAG!
SHOCK HAZARD
KEEP ENTIRE LIFT HOIST
CLEAR OF ALL UTILITY
AND ELECTRICAL WIRING!
15641-2
DO NOT REMOVE THIS TAG!
IMPORTANT SAFETY INFORMATION
• TOP OF HOIST MUST BE SECURED TO ROOF USING “S” HOOKS (PROVIDED)
AND TWO LENGTHS OF ROPE (NOT PROVIDED)
• BRAKE TENSION SPRINGS MUST BE CHECKED FOR CORRECT TENSIONING DAILY
(BEFORE USE) IN ORDER TO PREVENT LOAD SLIPPAGE
• KEEP BRAKE DRUMS AND BRAKE SHOES FREE OF OIL, LUBRICANTS, AND
EXCESSIVE MOISTURE, CHECK FOR DAILY WEAR AND REPLACE WHEN NECESSARY
• DO NOT OPERATE THIS UNIT IF ANY COMPONENT PARTS EXHIBIT DAMAGE
OR WEAR. THIS INCLUDES ALL TRACK SECTIONS
WARNING
SAFETY LATCH MUST BE
ENGAGED WHEN LIFT
HOIST IS NOT IN USE
DO NOT REMOVE THIS TAG!
15642-2