Esse 755 Stove Installation Guide

A'
19!
4.!INSTALLATION!INSTRUCTIONS!
!
1. Remove!the!heatshield,!and!remove!the!knock!out!section!(as!escribed!above).!
2. Remove!the!flue!plate,!from!the!rear!of!the!stove,!by!unscrewing!the!three!outer!fixing!
screws!(using!a!13mm!spanner).!
3. Open!the!stove!door,!and!remove!the!top!steel!baffle.!
4. Remove!the!two!nuts,!securing!the!stove!top!in!place,!(using!a!13mm!spanner),!and!lift!it!
clear!from!the!stove.!
5. Release!the!steel!flue!collar,!by!unscrewing!the!three!fixing!Philips!head!bolts.!
6. Reposition!the! steel! flue! collar! onto! the! rear! of! the! stove,! (where! the! flue! plate! was!
previously!located),!reusing!the!three!Philips!head!bolts.!
7. Reposition!the!flue!plate!around!the!top!flue!port,!and!fix!in!place!to!seal.!
8. Replace!the!stove!top!into!position,!and!secure!using!the!two!retained!fixing!nuts.!
9. Replace!the!top!steel!baffle.!
10. Drop!the!supplied!flue!blanking!disk!into!the!circular!cut^out!in!the!stove!top.!
11. If!the!flue! blanking!dŝƐŬĚŽĞƐŶƚĨŝƚĨůƵƐŚǁŝƚŚƚŚĞƐƚŽǀĞƚŽƉƌĞŵŽǀĞŝƚĂŶĚĂĚũƵƐƚƚŚĞƚŚƌĞĞ
inner!screws!heads!on!the!flue!plate,!so!as!to!make!the!blanking!disk!sit!flush.!!
!@>+#%=)R)B.*%))
The!stove!must!be!installed!and!connected!to!the!chimney!and! flue!pipe! in!line!with! the!current!
requirements!of!Building!Regulations.!ƐĂďĂƐŝĐŐƵŝĚĞůŝŶĞƚŚĞĐŚŝŵŶĞLJĂŶĚĨůƵĞŝŶƐƚĂůůĂƚŝŽŶƐŚŽƵůĚ!
ط!
Have!an!internal!cross!section!area!of!approximately!320cm²,!with!a!minimum!diameter!
or!square!side!length!of!125mm².!
ط!
Have!a!minimum!height!of!4.5m.!
ط!
Be!free!from!cracks,!severe!bends,!voids!and!obstructions.!
ط!
Ensure!where!a!flue!pipe!connects!to!a!chimney,!the!flue!passes!past!the!point!where!
the!chimney!narrows.!
ط!
Ensure!an!appropriate!flue!draft,!as!detailed!within!the!Flue!Draft!section!of!this!
manual.!
ط!
Take!into!consideration!future!access!for!maintenance!and!sweeping.!
!
Please!consult!Document!J!of!the!Building!Regulations!for!detailed!guidance.!
@%,0$@)
The! hearth! must! be! at! least! 12mm! thick! and! of! non^combustible! material(s).! When! in! use,! the!
temperature!on!the!horizontal!surface!below!the!stove!has!been!measured!at!<100°C.!!There!must!
be!a!minimum!distance!of!225mm!from!the!front!of!the!stove,!to!the!front!of!the!hearth.!!The!hearth!
must!be!of!robust!construction,!capable!of!taking!the!weight!of!the!stove.!!Please!consult!Document!
J!of!the!Building!Regulations!for!detailed!guidance.!
! )