SDS

MATERIAL SAFETY DATA SHEET
THE TESTOR CORPORATION
440 BLACKHAWK PARK AVENUE
ROCKFORD, ILLINOIS 61104
Telephone number: [phone] (M-F 8:00 AM - 4:30 PM CDT)
24 hour Chemtrec telephone number:* [phone] Page 1 of 3
24 hour Chemtrec International number:* [phone] (collect calls accepted.)
*TO BE USED ONLY IN THE EVENT OF CHEMICAL EMERGENCIES INVOLVING
A SPILL, LEAK, FIRE, EXPOSURE, OR ACCIDENT INVOLVING CHEMICALS.
Date prepared: 3/28/2012
This MSDS complies with OSHA 29 CFR 1910.1200 (The Hazard Communication Standard)
*********************************************************************************
-------------------- SECTION I - PRODUCT IDENTIFICATION -------------------------
PRODUCT IDENTITY (TRADE NAME): #1148 (T, TT CWM, CA) Thinner For
Oil Base Brushing Enamel
---------------------------------------------------------------------------------
--------------------- SECTION II - HAZARDOUS INGREDIENTS ------------------------
SPECIFIC_CHEMICAL_NAME CAS_# %_WT OSHA_PEL/TWA ACGIH_TLV/TWA
Xylol (Xylene) 1330-20-7 1-5 100 ppm. 100 ppm.
Ethyl Benzene 100-41-4 1 100 ppm. 100 ppm.
n-Propoxy Propanol 1569-01-3 90-95 Not Estab. Not Estab.
Aromatic Hydrocarbon Solvent 64742-94-5 1-5 100 ppm.* 100 ppm.*
(High Boiling) * Industry Recommendation
---------------------------------------------------------------------------------
--------------------- SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS -----------
BOILING RANGE: 272 to 395 deg.F SPECIFIC GRAVITY (Water=1): .880
GALLON WEIGHT OF VAPOR PRESSURE: 2 mm Hg @ 20 deg.C (calc.)
PRODUCT (Lbs/Gal): 7.33 VAPOR DENSITY: Heavier than air.
PERCENT VOLATILES EVAPORATION RATE: Slower than Ethyl Ether.
(By Volume): 100
---------------------------------------------------------------------------------
-------------------- SECTION IV - FIRE & EXPLOSION HAZARD DATA ------------------
FLASH POINT (SFCC): 108 deg.F
OSHA FLAMMABILITY CLASSIFICATION: Combustible Liquid - CLASS II
FLAMMABLE LIMITS (calc.) IN AIR: LEL 1.0 ,UEL 16.9
EXTINGUISHING MEDIA: Alcohol resistant foam, carbon dioxide, or dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Caution: Combustible. Dilution with water
will reduce burning rate. Avoid breathing vapors. Keep personnel removed from
and upwind of fire. Wear full protective equipment: Eye/Face Shield, Body
(Full Bunker Gear), Respiratory (SCBA).
UNUSUAL FIRE AND EXPLOSION HAZARDS: Cool fire exposed containers with water
spray (fog). Vapors may travel to ignition source and flash back. This material
may produce a floating fire hazard in extreme fire conditions. Overexposure to
decomposition products may cause a health hazard.