SDS

MATERIAL SAFETY DATA SHEET
THE TESTOR CORPORATION
440 BLACKHAWK PARK AVENUE
ROCKFORD, ILLINOIS 61104
Telephone number: [phone] (M-F 8:00 AM - 4:30 PM CDT)
24 hour Chemtrec telephone number:* [phone] Page 1 of 3
24 hour Chemtrec International number:* [phone] (collect calls accepted.)
*TO BE USED ONLY IN THE EVENT OF CHEMICAL EMERGENCIES INVOLVING
A SPILL, LEAK, FIRE, EXPOSURE, OR ACCIDENT INVOLVING CHEMICALS.
Date prepared: 7/25/2011
This MSDS complies with OSHA 29 CFR 1910.1200 (The Hazard Communication Standard)
*********************************************************************************
-------------------- SECTION I - PRODUCT IDENTIFICATION -------------------------
PRODUCT IDENTITY (TRADE NAME): #1166 (T, TT, CA) Flat Brown
Oil Base Brushing Enamel
---------------------------------------------------------------------------------
--------------------- SECTION II - HAZARDOUS INGREDIENTS ------------------------
SPECIFIC_CHEMICAL_NAME CAS_# %_WT OSHA_PEL/TWA ACGIH_TLV/TWA
VM&P Naphtha 64742-89-8 10-15 300 ppm. 300 ppm.
Mineral Spirits 64742-88-7 25-30 500 ppm.* 100 ppm.*
Magnesium Silicate Pigment 14807-96-6 5-10 2 mg/cu.m.** 2 mg/cu.m.**
Iron Oxide Pigment 51274-00-1 10-15 10 mg/cu.m.*** 5 mg/cu.m.***
1332-37-2
Hydrous Almuminum Silicate 1332-58-7 1-5 10 mg/cu.m.*** 5 mg/cu.m.**
Pigment
Amorphous Silica Gel 112926-00-8 1-5 20 mppcf 10 mg/cu.m.
* Stoddard Solvent as Guide ** Respirable Dust *** Total Dust
---------------------------------------------------------------------------------
--------------------- SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS -----------
BOILING RANGE: 246 to 370 deg.F SPECIFIC GRAVITY (Water=1): 1.104
GALLON WEIGHT OF VAPOR PRESSURE: 5.7 mm Hg @ 20 deg.C (calc.)
PRODUCT (Lbs/Gal): 9.20 VAPOR DENSITY: Heavier than air.
PERCENT VOLATILES EVAPORATION RATE: Slower than Ethyl Ether.
(By Volume): 59.8
---------------------------------------------------------------------------------
-------------------- SECTION IV - FIRE & EXPLOSION HAZARD DATA ------------------
FLASH POINT (SFCC): 74 deg.F
OSHA FLAMMABILITY CLASSIFICATION: Flammable Liquid - CLASS IC
FLAMMABLE LIMITS (calc.) IN AIR: LEL 1.0 ,UEL 7.0
EXTINGUISHING MEDIA: Alcohol resistant foam, carbon dioxide, or dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Caution: Flammable. A stream of water could
spread fire. Avoid breathing vapors. Keep personnel removed from and upwind of
fire. Wear full protective equipment: Eye/Face Shield, Body (Full Bunker Gear),
Respiratory (SCBA).
UNUSUAL FIRE AND EXPLOSION HAZARDS: Cool fire exposed containers with water
spray (fog). Vapors may travel considerable distance to ignition source
and flash back. Product may float and be reignited at water's surface.
Overexposure to decomposition products may cause a health hazard.