SDS

MATERIAL SAFETY DATA SHEET
THE TESTOR CORPORATION
440 BLACKHAWK PARK AVENUE
ROCKFORD, ILLINOIS 61104
Telephone number: [phone] (M-F 8:00 AM - 4:30 PM CDT)
24 hour Chemtrec telephone number:* [phone] Page 1 of 3
24 hour Chemtrec International number:* [phone] (collect calls accepted.)
*TO BE USED ONLY IN THE EVENT OF CHEMICAL EMERGENCIES INVOLVING
A SPILL, LEAK, FIRE, EXPOSURE, OR ACCIDENT INVOLVING CHEMICALS.
Date prepared: 7/22/2013
This MSDS complies with OSHA 29 CFR 1910.1200 (The Hazard Communication Standard)
*********************************************************************************
----------------- SECTION I - PRODUCT IDENTIFICATION ----------------------------
PRODUCT IDENTITY (TRADE NAME): Water-Base Acrylic Paint Sets: (All Colors)
#9100(T)#9100-6 Auto Detailing Paint Pod Set
#9184(T) Hobby Craft Acrylic Pod Set
#9186(T) Hobby & Craft Acrylic Pod Set
--------------------------------------------------------------------------------
--------------- SECTION II - HAZARDOUS INGREDIENTS & COMPOSTION INFORMATION ---
SPECIFIC_CHEMICAL_NAME CAS_# %_WT OSHA_PEL/TWA ACGIH_TLV/TWA
Propylene Glycol n-Butyl Ether 5131-66-8 6-12 Not Estab. Not Estab.
Dipropylene Glycol n-Butyl Ether 29911-28-2 1-4 Not Estab. Not Estab.
Trimethyl Pentanediol Diisobutyrate 6846-50-0 1-3 Not Estab. Not Estab.
Carbon Black Pigment** 1333-86-4 0.1-4.0 3.5 mg/cu.m. 3.5 mg/cu.m.
Titanium Dioxide Pigment+ 13463-67-7 0.1-20 15 mg/cu.m.* 10 mg/cu.m.*
**Contained at levels 0.1% or greater in colors: Gloss Black, Flat Black, Gloss
Brown, Gloss Royal Blue, Flat Gray, Flat Olive Drab, Neutral Gray, Gunship Gray
+Contained at levels 0.1% or greater in all colors except: Gloss Red, Gloss
Dark Red, Gloss Clear, Flat Red, Gloss Black and Flat Black.
Non-Hazardous and Other Not Avail. Balance * Total Dust
Ingredients Below Reportable Levels
---------------------------------------------------------------------------------
------------------ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS --------------
BOILING RANGE: 212 to 447 deg.F SPECIFIC GRAVITY (Water=1): 1.106 (TYP)
GALLON WEIGHT OF VAPOR PRESSURE: 19 mm Hg @ 20 deg.C (calc.)
PRODUCT (Lbs/Gal): 9.22 (TYP) VAPOR DENSITY: Lighter than air.
PERCENT VOLATILES EVAPORATION RATE: Slower than Ethyl Ether.
(By Volume): 72.5 (TYP)
---------------------------------------------------------------------------------
----------------- SECTION IV - FIRE & EXPLOSION HAZARD DATA ---------------------
FLASH POINT (SFCC): > 200 deg. F
OSHA FLAMMABILITY CLASSIFICATION: Combustible Liquid - CLASS IIIB
FLAMMABLE LIMITS (calc.) IN AIR: LEL 2.6, UEL 12.5
EXTINGUISHING MEDIA: Alcohol resistant foam, carbon dioxide, dry chemical or
water fog.
SPECIAL FIRE FIGHTING PROCEDURES: A stream of water could spread fire. Avoid
breathing vapors. Keep personnel removed from and upwind of fire. Wear full
protective equipment: Eye/Face Shield, Body (Full Bunker Gear), Respiratory
(SCBA).
UNUSUAL FIRE AND EXPLOSION HAZARDS: Cool fire exposed containers with water
spray (fog). Vapors may travel to an ignition source and flash back.
Overexposure to decomposition products may cause a health hazard.
#9001 Acrylic Primary Paint Pod Set
#9101 (T)9101-6 Military Paint Pod Set
#9185(T) Model Car Acrylic Pod Set
#9187(T) Model Car Acrylic Pod Set