Operation and maintenance manual

Section 300-0070
Miscellaneous - Service Tools
2
SM 1419 Rev 4 11-03
15270295 - Valve Button Retainer Expander
15270248 - Valve Guide Installer
15270250 - Valve Guide Remover
15270251 - Valve Seat Insert Installer (Exhaust)
15270247 - Valve Seat Insert Installer (Intake)
15270240 - Valve Seat Remover (Exhaust)
15270241 - Valve Seat Insert Remover (Intake)
15270252 - Valve Spring Compressor (head installed)
15270257 - Valve Stem Seal Installer
15270296 - Head Bolt Resurface
15270304 - Injector Timing Tool
15270302 - Rocker Arms and Shaft Assembly
Crankshaft
15270281 - Crankshaft Protector
15270291 - Engine Barring Tool
15270267 - Front/Rear Oil Seal Expander
15270268 - Front/Rear Oil Seal Installer (std. OS and
wear sleeve)
15270309 - Front/Rear Oil Seal Remover
Piston, Piston Rings and Connecting Rod
15270239 - Piston Ring Pliers
15270278 - Connecting Rod Guides
15270288 - Piston/Connecting Rod Holding Fixture
15270276 - Piston, Fire Ring Groove Gauge
(2.5 mm ring)
15270297 - Piston, Fire Ring Groove Gauge
(3.5 mm ring)
15270256 - Piston Ring Compressor
15270294 - Cylinder Kit Lifter
Gear Train
15270284 - Accessory Drive Service Set
15270277 - Camshaft Gear Pilot
15270265 - Camshaft Gear Torque Holding Tool
15270254 - Camshaft/Idler Gear Lash Adjusting Tool
15270263 - Crankshaft Gear/Remover/Installer
15270264 - Gear Case Alignment Plug
15270269 - Water Pump Lash and Impeller Slip
Tester
15270298 - Accessory Drive Gear Lash Tool
15270300 - Water Pump Gear Lash Tool
Fuel System
15270271 - Diagnostic Jumper Wire
15268969 - Fuel Filter Wrench
15270283 - Fuel Pump Gear Installer
15270237 - Fuel Pump Holding Fixture
15270299 - Fuel Pump Service Kit
15269235 - Group I Terminal Removal Tool
15269234 - Group I Terminal Crimping Tool
15270245 - Group II Terminal Removal
15270258 - Group II Terminal Crimping Tool
15269237 - Group III Terminal Removal Tool
15270270 - Group III Terminal Crimping Tool
15269238 - PROM removal Tool
15270307 - Brass Wire Buffing Wheel (Injector
spray nozzle)
15270235 - Oil Seal Installer Handle
15270236 - Oil Seal Installer Adaptor
15270238 - Oil Seal Remover
15270249 - Injector Tube Installation/Removal Tool
Air Intake System
15270243 - Turbocharger Inlet Shield
15270301 - Turbocharger Gauge Arm Tool
15270306 - Dial Indicator Set
Lube System
15270274 - Oil Cooler Housing Guide Studs
15270246 - Band Type Oil Filter Wrench
Cooling System
15270242 - Radiator and Cooling System Pressure
Tester
15270280 - Water Pump Service Tool Kit
15270269 - Water Pump Lash and Impeller Slip
Tester
15270300 - Water Pump Gear Lash Tool
15270308 - Thermostat Seal Installation Tool
15270305 - Handle
15270292 - Fan Hub/Air Compressor Drive Service Kit
Transmission
The following tools are recommended for Transmission
Maintenance Procedures. These tools should be used
in conjunction with procedures outlined in the
transmission manufacturers service manual.
15270087 - Straight Pin
15270195 - Ring
15270196 - Threaded Insert
15270092 - Puller
15270093 - Puller
15270098 - Driver
15270197 - Driver
15270198 - Driver
15270199 - Driver
15270200 - Driver
15270201 - Driver
15270104 - Driver
15270202 - Driver
15270203 - Driver
15270204 - Driver
15270112 - Measuring Pin
15270115 - Set of Eye Bolts
15270205 - Back-off Screws - M10
15270119 - Adjusting Screws - M10
15270206 - Back-off Screws - M8
15270116 - Adjusting Screws - M8