Operation and maintenance manual

8-7
Interval Ref. No. of Service
Hours Points Identification Service Instructions Points Lubricant Quantities
1 Engine Steam clean 1
7 Radiator and Cooling System Drain, flush and refill. Coolant See Page 13
21/22 Drivelines (Low Maintenance) Check for leaks and damage. - - See Page 12
27 Articulation Pivot Nut Check torque 1 1 425 Nm (1 050 lb ft)
2 000 36 Fuel Cooler Strip, clean and inspect 1
37 Charge Air Cooler Strip, clean and inspect 1
18 Drive Belts Replace all belts.
40 OCDB Filter Replace.
2 250 3 Hydraulic Tank Drain oil and refill. 1 HO See Page 13
- Suction Screens and Strainers Clean. 2
4 000 - Thermostats and Seals Replace.
6 000 34 Engine Oil Cooler Strip, clean and inspect. 1
35 Transmission Oil Cooler Strip, clean and inspect. 1
Notes on 'Lubrication and Service Chart'
Note - Capacities given are approximate - work to dipstick,
sight gauges or level plugs.
Note 1 - Lubricate slowly until excess lube is seen.
Note 2 - Remove plugs and fit lube fittings. Lubricate slowly
until excess lube is seen. Remove fittings and refit
plugs.
Note 3 - Check with the engine idling and the transmission at
its normal operating temperature.
Note 4 - When refilling centre axle ensure that 3rd differential
unit is primed with 1 litre (1.75 UK pints) of oil before
filling drive head.
Note 5 - Remove plug from port on underside of oscillation
hub. Plug is removed to drain the cavity of any oil
that enters the cavity when filling. Remove grommet
and level plug on side of oscillation hub. Add oil if
required. Refit all plugs.
Note 6 - Clean radiator and cooler fins more often when
operating under extremely dusty conditions.
EO - Engine Oil. Refer to 'Recommended Lubricants'.
* - Refer to chart under 'Recommended Lubricants'.
HO - Hydraulic Oil. Refer to 'Recommended Lubricants'.
EPL - Extreme Pressure Lubricant specification
MIL-L-2105 D.
EP, NLGI - Extreme Pressure, Lithium No. 2 Grease (which may,
or may not, contain Molybdenum).
*EP, NLGI - Extreme Pressure, Lithium No. 2 Grease (without
Molybdenum).
EMS19057 - Extreme Pressure, Lithium Complex Grease. Refer to
'Recommended Lubricants'.
HTO - Hydraulic Transmission Oil. Refer to 'Recommended
Lubricants'.
LZ - Lubrizol 6178
PAG Oil - Polyalklene Glycol (PAG) Compressor Lubricating Oil -
Low Viscosity (ISO46).
LUBRICATION AND SERVICE CHART (Continued)