User's Manual

Circuit: Display Interface with DC-DC, with touchscreen
Revision: 1.02
Modified:
Item Designations Qty BIN # Description Package
1 PCB 1
PCB 0016
PCB, Display Interface, revision 1.02, 0.62" FR4, 1oz finished -
2 C114, C115 2
CAP 06802
CAPACITOR, 22pF, 50Vdc, ceramic SMD 0805
3 C122 1
CAP 10602
CAPACITOR, 560pF, 50Vdc, ceramic SMD 0603
4 C103 1 CAP 11503 CAPACITOR, 1000pF, 50Vdc, ceramic SMD 0603
5 C123 1
CAP 13002
CAPACITOR, 2700pF, 50Vdc, ceramic SMD 0603
6 C127 1
CAP 13802
CAPACITOR, 4700pF, 50Vdc, ceramic SMD 0603
7 C108, C113, C121, C124, C131 5 CAP 14904 CAPACITOR, 0.01uF (10,000pF), 50Vdc, ceramic SMD 0603
8 C125, C126 2 CAP 14904 CAPACITOR, 0.01uF (10,000pF), 100Vdc, ceramic SMD 0603
9 C132 1
CAP 15703
CAPACITOR, 0.022uF (22,000pF), 50V, ceramic SMD 0603
10 C128 1 CAP 15902 CAPACITOR, 0.027uF (27nF), 50Vdc, ceramic SMD 0603
11
C104, C105
2
CAP 17204
CAPACITOR, 0.1uF (100nF), 25V, 10%, ceramic SMD 0603
12
C130
1
CAP 19603
CAPACITOR, 1uF, 35Vdc, ceramic SMD 0603
13
C120
1
CAP 22273
CAPACITOR, 10uF, 35V, tantalum SMD 6032
14 R129, R130 2 RES 2961 RESISTOR, 60.4ohm, 1%, 1/8W SMD 0603
15
R105
1
RES 3212
RESISTOR, 100Ω, 1%, 1/8W SMD 0805
16 R134 1
RES 3762
RESISTOR, 300Ω, 1%, 1/8W SMD 0805
17
R101, R103, R106, R110, R111,
R116, R123
7
RES 4502
RESISTOR, 1.0kΩ, 1%, 1/8W SMD 0805
18 R102 1
RES 4842
RESISTOR, 2.0kΩ, 1%, 1/8W SMD 0805
19 R104 1
RES 5673
RESISTOR, 8.2kΩ, 1%, 1/4W SMD 1206
20 R124 1
RES 6122
RESISTOR, 18.7kΩ, 1%, 1/8W SMD 0805
21 R125 1
RES 6282
RESISTOR, 25.5kΩ, 1%, 1/8W SMD 0805
22 R127 1
RES 6382
RESISTOR, 30.1kΩ, 1%, 1/8W SMD 0805
23 R133 1
RES 6492
RESISTOR, 37.4kΩ
, 1%, 1/8W SMD 0805
24
RN101
1
RES 4510
RESISTOR NETWORK, 1kΩ, 8-resistor, 10-pin, 1/16W
Panasonic EXB-A
25 RN102 1
RES 5810
RESISTOR NETWORK, 10kΩ, 8-resistor, 10-pin, 1/16W Panasonic EXB-A
26 F101 1
FUS 1651
FUSE, 0.5A hold, resettable, polyswitch, 24V SMD 1812
27
F102
1
FUS 1953
FUSE, 0.75A hold, resettable, polyswitch, 24V SMD 1812
28
L101
1
IND 0221
INDUCTOR, 0.01uH, 450mA, DCR=130mΩ SMD 1210
29
L103
1 IND 0992 INDUCTOR, 150nH, Imax=2.6A, DCR=0.024 omhs SMD 1210
30
L104
1
IND 5811
Inductor, common mode choke, 22uH, 200mA SMT ACT45B
31
D102, D103
2
SEM 09005
DIODE, LED, green, 2.2V, 16mcd SMD 0603
32
D101
1
SEM 09006
DIODE, LED, orange, 2.0V, 6.3mcd SMD 0603
33 D105, D106 2
SEM 19005
DIODE, schottky, 100V, 1A, single SMA
34
U102
1
ICT 10008
IC, buffer, tri-state, quad, non-inv, 5V TSSOP-14
35 U103 1
ICT 12017
IC, CAN, transceiver, 5V, 1 driver, 1 receiver SOIC-8
36 U106 1
ICT 48003
IC, regulator, 5.0V, 1A, simple switcher, 4.5-60V in TO-263-5
37 U111 1
ICT 48026
IC, regulator, switcher, 75V, 1.5A, buck TSSOP-16
38 U109, U110 2
ICT 36001
IC, optocoupler, dual, transistor output, 150mA per channel SOIC-8
39 U105 1
ICT 56002
IC, supervisor, 4.50V threshold, open drain (no pullup) SOT-23
40 U101 1 ICT 32037 IC, microcontroller, flash, 16k X 16 (32KB) program, CAN, 40MHz SOIC-28
41 S101 1
SWT 0001
SWITCH, DIP, 7-position, extended actuator SMT
42 C133 1
CAP 24072
CAPACITOR, 100uF, 10V, tantalum SMD 7343-31 EIA
43
Y101
1
CLK 0011
CRYSTAL, 7.3728MHz, 18pF, +/- 20ppm SMT
44 BZ101 1
AUD 0001
BUZZER, magnetic, 4-7V, 2.5kHz, 90dB SMT
45 L106 1
IND 4441
INDUCTOR, 470uH +/- 10%, Irms=0.8A, DCR=0.820mΩ SMT
46 L102 1
IND 4442
INDUCTOR, 470uH +/- 10%, Irms=2.6A, DCR=0.133mΩ SMT
47
C101
1
CAP 24014
CAPACITOR, 100uF, 63Vdc, electrolytic
Panasonic VS G
48 J103 1
CON 64502
CONNECTOR, terminal block, 5-pos, receptacle, 0.2", 15A THT
49 J107 1
CON 31530
CONNECTOR, header, 10-pos, 1.25mm, R/A, SMD SMT
50 J101 1 CON 45024 CONNECTOR, modular, jack, 6-6, vert, board lock, panel stops THT
51 J104 1
CON 45020
CONNECTOR, modular, jack, 8-8, vertical, shielded THT
52 J103 1
CON 64503
CONNECTOR, terminal block, 5-pos, plug, 0.2", 15A -
Bill of Materials - ASY 0016 (was ASY 016A)
22-Nov-13