Installation Instructions

Page 3 of 6
04-03-2013
805043PM
MATERIAL SAFETY DATA SHEET
__________________________________________________________________________________________
MSDS. Additional precautions may be necessary based on special
circumstances created by the spill including; the material spilled, the quantity
of the spill, the area in which the spill occurred.
CLEAN-UP: Avoid creating dusts. Cover material with absorbent and moisten and collect
for disposal.
Transport Emergency Phone Number (CHEMTREC): 1-800-424-9300
SECTION 7: HANDLING AND STORAGE
Handling: Harmful or irritating material. Avoid contacting and avoid breathing the material. Use only in
a well ventilated area. Avoid breathing material.
Storage: Store in a cool, dry place.
Consult the Technical Data Sheet for specific storage instructions.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
EYE PROTECTION: Wear safety glasses with side shields when handling this product.
Wear additional eye protection such as chemical splash goggles
and/or face shield when the possibility exists for eye contact with
splashing or spraying liquid, or airborne material. Have an eye wash
station available.
SKIN PROTECTION: Avoid skin contact by wearing chemically resistant gloves and long
sleeved shirt. An apron may be appropriate if splashing can occur.
GLOVES: Nitrile
RESPIRATORY PROTECTION: Respiratory protection may be required to avoid overexposure when
handling this product. Use a respirator if general room ventilation is
not available or sufficient to eliminate symptoms. NIOSH approved
air purifying respirator with dust/mist filter.
Respirators should be selected by and used following requirements
found in OSHA's respirator standard (29 CFR 1910.134).
VENTILATION: Use local exhaust ventilation or other engineering controls to
minimize exposures.
EXPOSURE LIMITS:
Chemical Name ACGIH EXPOSURE LIMITS OSHA PEL
Crystalline silica 0.025 mg/m3 TWA (respirable fraction) ((250)/(%SiO2 + 5) mppcf TWA (respirable));
((10)/(%SiO2 + 2) mg/m3 TWA (respirable));
((30)/(%SiO2 + 2) mg/m3 TWA (total dust))
Portland cement 1 mg/m3 TWA (particulate matter containing
no asbestos and <1% crystalline silica,
respirable fraction)
15 mg/m3 TWA (total dust); 5 mg/m3 TWA
(respirable fraction)
Alumina cement Not established Not established
Calcium carbonate Not established 15 mg/m3 TWA (total dust); 5 mg/m3 TWA
(respirable fraction)
Calcium sulfate 10 mg/m3 TWA (inhalable fraction) 15 mg/m3 TWA (total dust); 5 mg/m3 TWA
(respirable fraction)
Iron oxide 5 mg/m3 TWA (respirable fraction) 10 mg/m3 TWA (as fume)
Magnesium Oxide 10 mg/m3 TWA (inhalable fraction) 15 mg/m3 TWA (total particulate) (as fume)