Safety Data Sheets (SDS)

Page 3 of 6
ACLR CAULK SD SUM WHEAT
Print Date: 06-10-2015 839429PM
SAFETY DATA SHEET
______________________________________________________________________________
GLOVES: Not normally required. Use nitrile gloves if conditions warrant.
RESPIRATORY PROTECTION: Respiratory protection may be required to avoid overexposure when
handling this product. Use a respirator if general room ventilation is
not available or sufficient to eliminate symptoms. NIOSH approved
air purifying respirator with dust/mist filter.
Respirators should be selected by and used following requirements
found in OSHA's respirator standard (29 CFR 1910.134).
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Semi-solid
COLOR: Dark Brown
ODOR: Neutral
ODOR THRESHOLD: Not established
pH: 7.4
FREEZING/MELTING POINT (deg. C): Not established
BOILING POINT (deg. C): Not established
FLASH POINT: Non flammable
EVAPORATION RATE: Not established
FLAMMABILITY: Not a flammable solid or gas
UPPER EXPLOSIVE LIMIT (% in air): Not established
LOWER EXPLOSIVE LIMIT (% in air): Not established
VAPOR PRESSURE (mm Hg): Not established
VAPOR DENSITY: Not established
WEIGHT PER GALLON (lbs.): 13.25
SPECIFIC GRAVITY: 1.590
SOLUBILITY: Not established
OCTANOL/WATER COEFFICIENT: Not established
AUTOIGNITION TEMPERATURE: Not established
DECOMPOSITION TEMPERATURE: Not established
VISCOSITY: No data available.
SOLIDS (% by weight): 81.2
VOC, weight percent 0.60
VOC, U.S. EPA Method 24, less water and exempt
solvents (theoretically determined)
12g/liter of material
SECTION 10: STABILITY AND REACTIVITY
STABILITY: Stable under normal conditions.
CHEMICAL INCOMPATIBILITY: Not established
HAZARDOUS POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide
SECTION 11: TOXICOLOGICAL INFORMATION
Component Toxicity / Toxicology Data:
COMPONENT NAME LD50/LC50
Calcium carbonate ORAL LD50 RAT 6,450 MG/KG
Crystalline silica ORAL LD50 RAT 500 MG/KG
Water ORAL LD50 RAT > 90 ML/KG