SDS

Page 3 of 6
TRIPLE FLEX PART B
Print Date: 06-10-2015 839240PM
SAFETY DATA SHEET
______________________________________________________________________________
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
EXPOSURE LIMITS:
Chemical Name Note ACGIH EXPOSURE LIMITS OSHA PEL
Crystalline silica * (see
below)
0.025 mg/m3 TWA (respirable fraction) ((250)/(%SiO2 + 5) mppcf TWA
(respirable)); ((10)/(%SiO2 + 2) mg/m3
TWA (respirable)); ((30)/(%SiO2 + 2)
mg/m3 TWA (total dust))
Calcium carbonate * (see
below)
No data available. 15 mg/m3 TWA (total dust); 5 mg/m3 TWA
(respirable fraction)
Diatomaceous earth * (see
below)
No data available. 20 mppcf TWA; ((80)/(% SiO2) mg/m3
TWA)
Aluminum oxide * (see
below)
No data available. 15 mg/m3 TWA (total dust); 5 mg/m3 TWA
(respirable fraction)
ENGINEERING CONTROL METHODS:
VENTILATION: Use local exhaust ventilation or other engineering controls to
minimize exposures.
EYE PROTECTION: Wear safety glasses with side shields when handling this product.
Wear additional eye protection such as chemical splash goggles
and/or face shield when the possibility exists for eye contact with
splashing or spraying liquid, or airborne material. Have an eye wash
station available.
SKIN PROTECTION: Avoid skin contact by wearing chemically resistant gloves and long
sleeved shirt. An apron may be appropriate if splashing can occur.
GLOVES: Nitrile
RESPIRATORY PROTECTION: Respiratory protection may be required to avoid overexposure when
handling this product. Use a respirator if general room ventilation is
not available or sufficient to eliminate symptoms. NIOSH approved
air purifying respirator with dust/mist filter.
Respirators should be selected by and used following requirements
found in OSHA's respirator standard (29 CFR 1910.134).
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Solid
COLOR: Gray
ODOR: Odorless
ODOR THRESHOLD: Not established
pH: Not established
FREEZING/MELTING POINT (deg. C): Not established
BOILING POINT (deg. C): Not established
FLASH POINT: Non flammable
EVAPORATION RATE: Not established
FLAMMABILITY: Not a flammable solid or gas
UPPER EXPLOSIVE LIMIT (% in air): Not established
LOWER EXPLOSIVE LIMIT (% in air): Not established
VAPOR PRESSURE (mm Hg): Not established
VAPOR DENSITY: Not established