Safety Data Sheets (SDS)

Page 4 of 7
FULL FLEX MORTAR
Print Date: 06-09-2015 839247PM
SAFETY DATA SHEET
______________________________________________________________________________
SKIN PROTECTION: Avoid skin contact by wearing chemically resistant gloves and long
sleeved shirt. An apron may be appropriate if splashing can occur.
GLOVES: Nitrile
RESPIRATORY PROTECTION: Respiratory protection may be required to avoid overexposure when
handling this product. Use a respirator if general room ventilation is
not available or sufficient to eliminate symptoms. NIOSH approved
air purifying respirator with dust/mist filter.
Respirators should be selected by and used following requirements
found in OSHA's respirator standard (29 CFR 1910.134).
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Solid
COLOR: White
ODOR: Odorless
ODOR THRESHOLD: Not established
pH: Not established
FREEZING/MELTING POINT (deg. C): Not established
BOILING POINT (deg. C): Not established
FLASH POINT: Non flammable
EVAPORATION RATE: Not established
FLAMMABILITY: Not a flammable solid or gas
UPPER EXPLOSIVE LIMIT (% in air): Not established
LOWER EXPLOSIVE LIMIT (% in air): Not established
VAPOR PRESSURE (mm Hg): Not established
VAPOR DENSITY: Not established
WEIGHT PER GALLON (lbs.): 11.20
SPECIFIC GRAVITY: 1.340
SOLUBILITY: Not established
OCTANOL/WATER COEFFICIENT: Not established
AUTOIGNITION TEMPERATURE: Not established
DECOMPOSITION TEMPERATURE: Not established
VISCOSITY: No data available.
SOLIDS (% by weight): 100.0
VOC, weight percent 0.00
SECTION 10: STABILITY AND REACTIVITY
STABILITY: Stable under normal conditions.
CHEMICAL INCOMPATIBILITY: Not established
HAZARDOUS POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide Sulfur containing
gases Aluminum oxide
SECTION 11: TOXICOLOGICAL INFORMATION
Component Toxicity / Toxicology Data:
COMPONENT NAME LD50/LC50
Crystalline silica ORAL LD50 RAT 500 MG/KG
Iron oxide ORAL LD50 RAT > 10,000 MG/KG
Calcium sulfate ORAL LD50 RAT > 3,000 MG/KG