Datasheet

ManualsBrandsTDK-LAMBDA ManualsPSU ComponentsAC/DC PSU module (open frame) Medizinisches Netzteil 50.4 Vdc 5.3 A

CUS200M Series

,QGXVWULDO 7HVW

Single Output 200 to 250W Medical

& ITE Power Supplies

CUS200M Series

www.emea.tdk-lambda.com/cus200m

&RPP

%URDGFDVW

Features Benets

 •IEC60601-1(2xMOPP)&IEC60950-1Approvals •SuitableforB&BFtypeMedicalandITEApplications

 •200WConvectioncooledrating •Nofannoise,goodfornoise-sensitiveenvironments

 •Lowprole(34mm),Standard3”x5”format •Spacesaving&easysystemintegration

 •5VStandbypowersupplyonboard •Noadditionalcircuitryneeded,savescost

 •OperatingAltitudeupto5000m •Supportsglobaluse&globalsalesofequipment

 •HighEfciencyupto94%,Lowoff-load •Excellent“environmentalfootprint”

 powerconsumption(<0.5W)

Specication

Model CUS200M

ACInputVoltage VAC 85-265VAC(1) 

 InputFrequency Hz 47-63Hz   

 InrushCurrent(coldstart) A 35Aat115VAC,70Aat230VAC 

 PowerFactor - MeetsEN61000-3-2ClassA(TypicalPF0.99/0.95)(2) 

 InputCurrent(115/230VAC) A 200Woutput:2.2/1.1A;250Woutput:3.0/1.5A 

 Off-loadPowerConsumption(3) W <0.5Wat230VAC 

 TemperatureCoefcient %/°C <0.02%/°C 

 OvercurrentProtection - 12V:>17.2A,18V:>14.7A,24V:>11A,36V:>7.4A,48V:>5.5A 

 OvervoltageProtection(4) V 12V:13.2-16.2V,18V:19.8-24.3V,24V:26.4-32.4V,36V:39.6-48.6V,48V:52.8-64.8V 

 HoldUpTime(115/230Vinput) ms 16msat200Woutput,12msat250W 

 LeakageCurrent mA <0.3mAat265VAC,60Hz 

 RemoteOn/Off - Applyvoltagetoisolatedterminalstoshutunitdown 

 PowerGood - Isolatedtransistor,On=Good.Gives>5mswarningofACpowerloss 

 StandbyVoltage - 5V0.6A(convection),1A(forcedair) 

 OperatingTemperature °C -20°Cto+70°C.Deratelinearlyto50%loadfrom+50°Cto+70°C 

 StorageTemperature °C -40°Cto+85°C 

 Humidity(noncondensing) %RH 10-95%RH(Operating&Storage)

 Cooling - ConvectionorForcedAirCooled(1.5m/sacrossterminals)

 WithstandVoltage - InputtoGround2kVAC(1xMOPP),InputtoOutput4kVAC(2xMOPPs),OutputtoGround 

   1.5kVAC(1xMOPP)SuitableforBandBFratedmedicalequipment 

 IsolationResistance Ω >100MΩat25°C&70%RH,OutputtoGround500VDC

 Vibration(nonoperating) - 10-55Hz:19.6m/s

constantsweep1minX,Y,Zfor1hour 

 Shock - <196.1m/s

(20G) 

 Immunity - IEC61000-4-2(lv2,3),-3(lv3),-4(lv3),-5(lv3,4),-6(lv3),-8(lv4),-11,EN60601-1-2:2015(Ed4)

 SafetyAgencyCertications - EN/IEC/UL/ES/CSA60601-1,EN/IEC/UL/CSA60950-1,CEMark 

 Conducted&RadiatedEMI - EN55011-B,FCCClassB 

 Weight(Typ) g 350 

 Size(LxWxH) mm 127x76.2x34 

 Warranty yrs 3

0HGLFDO

Notes:

(1) Deratelinearlyto80%loadfrom115to85VACinput

(2) 115/230VACinput 

(3) Referstoinputpowerduringremoteoffandstandby5Vinatnoloadcondition 

(4) CycleACtoreset

Summary of content (6 pages)

PAGE 1
CUS200M Series www.emea.tdk-lambda.com/cus200m 0HGLFDO ,QGXVWULDO 7HVW Single Output 200 to 250W Medical & ITE Power Supplies %URDGFDVW &RPP Features Benefits • IEC 60601-1 (2x MOPP) & IEC 60950-1 Approvals • 200W Convection cooled rating • Low profile (34 mm), Standard 3”x5” format • 5V Standby power supply on board • Operating Altitude up to 5000m • High Efficiency up to 94 %, Low off-load power consumption (<0.
PAGE 2
Model Selector Voltage Adjust Range (V) Max Current Conv (A) Max Current Forced Air (A) Max Power Forced Air (W) Load Reg (mV) Line Reg (mV) Ripple Noise (mV) Efficiency (typical) % (5) CUS200M-12 12V 11.7 - 12.6 16.7 16.7 200.4 120 60 180 92 / 93 CUS200M-18 18V 17.6 - 18.9 11.2 14.0 252.0 180 90 180 92 / 94 CUS200M-24 24V 23.5 - 25.2 8.4 10.5 252.0 240 120 240 92 / 94 CUS200M-36 36V 35.2 -37.8 5.5 7.0 252.0 360 180 360 92 / 94 CUS200M-48 48V 47 - 50.4 4.
PAGE 3
5-2. Output Derating Make sure that the temperature range is maintained. 5.specified Mounting Directions Convection cooling 5-1. Output Derating according to the Mounting Direction MODEL: CUS200M-18, CUS200M-24, CUS200M-48 MOUNTING A,B MOUNTING C,D MOUNTING E (NOTE1) Ta (°C) Recommended standard mounting direction is (A). Mounting direction (B)-(E) are also possible. Refer to the output LOAD (%) LOAD (%) LOAD (%) derating below. -20 - +40 Load (%) 100 of derating curve indicates 100output power.
PAGE 4
Outline Drawing CUS200M/A Series TDK-Lambda CUS200M/A OUTPUT DERATING CA811-01-02/A OUTPUT DERATING VERSUS OPERATING AMBIENT TEMPERATURE (Ta) Output Derating CUS200M/A *COOLING : CONVECTION COOLING FOR ALL MOUNTINGS AND ALL MODELS Ta (°C) MOUNTING A,B MOUNTING C,D MOUNTING E LOAD (%) LOAD (%) LOAD (%) 100 100 80 70 60 50 100 82 65 57 48 40 100 82 65 57 48 - -20 - +25 35 45 50 55 60 Mounting A,B Mounting C,D Mounting E 100 LOAD (%) 80 60 40 20 0 -20 -10 0 10 20 30 40 50 60 70 8
PAGE 5
LOAD (%) Mounting A,B 60 Mounting C,D Mounting E 100 40 LOAD (%) 80 20 60 40 0 20 -20 -10 0 10 20 30 40 50 60 70 Ta (°C) Output Derating versus Operating Ambient Temp (Ta) CUS200M/A 0 -20 -10 0 10 20 30 40 50 60 70 80 80 Ta (°C) OUTPUT DERATING VERSUS OPERATING AMBIENT (Ta) * Cooling: Forced Air Cooling for all Mounting andTEMPERATURE all Models OUTPUTAIR DERATING VERSUS OPERATING AMBIENT TEMPERATURE (Ta) * COOLING: FORCED COOLING * COOLING: FORCED AIR COOLING FOR ALL MO
PAGE 6
TDK-Lambda France SAS TDK-Lambda UK Ltd. 3 Avenue du Canada Parc Technopolis Bâtiment Sigma 91940 les Ulis France Tel: +33 1 60 12 71 65 Fax: +33 1 60 12 71 66 france@fr.tdk-lambda.com www.fr.tdk-lambda.com Kingsley Avenue Ilfracombe Devon EX34 8ES United Kingdom Tel: +44 (0) 12 71 85 66 66 Fax: +44 (0) 12 71 86 48 94 powersolutions@uk.tdk-lambda.com www.uk.tdk-lambda.com Italy Sales Office TDK-Lambda Ltd. Kibbutz Givat Hashlosha 48800 Israel Tel: +9 723 902 4333 Fax: +9 723 902 4777 info@tdk-lambda.