User Instructions

ManualsBrandsT&T Distributors ManualsGas StovesGeocast Rustic Dark Oak Ceramic Beam

2016APRIL12

CAREANDUSESTIFFTHINCARDTOPROTECTTHEBEAM.CUT‐INTHEPAINTWORKCAREFULLYWITHOUTTHEUSE

OFMASKINGTAPE.AMAHLSTICKAND/ORSOMESTIFFTHINCARDWITHASTRAIGHTEDGEWILLHELP.

11. APOTOFGEOCASTTOUCH‐UPSTAINISPROVIDEDINCASEOFSMALLSCRATCHESTOTHEGEOCASTBEAM.

PLEASEPRACTICE,USINGSPARINGLYANDAPPLYINANUMBEROFVERYTHINLAYERS,ALLOWINGTODRY

BETWEENAPPLICATIONS.

12. FINISHOFFBYUSINGAFLEXIBLEHIGHTEMPERATUREMASTICSUCHASFLEXSEAL.



THEFOLLOWINGINSTRUCTIONSAREFORTHEINSTALLATIONOFAHORIZONTALGEOCASTBEAMWITHAMBIENT

LIGHTING.



1. FOLLOWSTEPS1TO8OVERLEAFTHEN:

2. DECIDEWHERETORUNTHECABLEFROMTHEREAROFTHEGEOCASTBEAMTOTHEPOWERSOURCE/POINTAND

PREPARETHECABLEWAY.ITISESSENTIALTHATTHEROUTEYOUCHOOSEISWELLINSULATEDFROMTHEHEAT

OFTHEAPPLIANCE.

3. ATTHISSTAGEFITTHELIGHTSTOTHEBEAMANDTESTBEFOREFINALLYINSTALLINGTHEGEOCASTBEAM.

4. CAREFULLYFOLLOWTHEINSTRUCTIONSWITHTHELIGHTKIT.

5. ITISIMPORTANTTOPLACETHETRANSFORMERTOONEENDORTHEOTHEROFTHEGEOCASTBEAM.

6. LEAVEENOUGHFLEXSOTHATTHETRANSFORMERMAYBEWITHDRAWNTHROUGHONEOFTHEHOLESFORTHE

LIGHTS,SHOULDITEVERNEEDTOBEREPLACED.

7. NOWFOLLOWSTEPS9TO12OVERLEAF.



NOTES



1. IFTHECHIMNEYBREASTISBOWEDITISESSENTIALTHATTHEBEAMISEITHERCUTINORPACKERSBEHINDTHE

BRACKETSAREUSED.NEVERFORCETHEBEAMONTOTHEBRACKETSASTHISCANDAMAGETHEBEAMWHICH

MAYCAUSECRACKSOVERTIMEIFNOTIMMEDIATELY.

2. GEOCASTBEAMSARENOTSUITABLETOBEUSEDASLEGSTOCREATEA“HENGESTYLE”ORMANTEL

INSTALLATION,ANDSHOULDNOTBECUT.

3. GEOCASTBEAMSARENOTCOMBUSTIBLEANDSOCANBEFITTEDCLOSERTOASTOVEAND/ORFLUEPIPETHANA

COMBUSTIBLEWOODENBEAM.THECLEARANCESSHOWNINDIAGRAM1OVERLEAFMUSTBEFOLLOWED.

4. PLEASEENSURETHATTHEREISNODIRECTCONTACTBETWEENTHEGEOCASTBEAMANDANYPARTOFTHE

APPLIANCE,FLUEORREGISTERPLATEANDBRACKETS.

5. PLEASEENSURETHATNOPARTOFTHEGEOCASTBEAMPROTRUDESBELOWTHEBUILDER’SOPENINGINWHICH

THEAPPLIANCESITSANDTHATTHEREAROFTHEBEAMISCOMPLETELYENCLOSED.

6. INCOMMONWITHNATURALWOODENBEAMS,THEREISATOLERANCEOF5mmTOTHEFLATNESSOFTHEREAR

OFTHEBEAM.

7. DONOTUSESELFADHESIVEMASKINGTAPESONTHEBEAMASTHISISLIKELYTOCAUSEDAMAGETOTHE

SURFACEFINISH.

8. FORAMBIENTLITBEAMS,THETOGGLESWITCHMAYBECOMEWARM‐TO‐TOUCHSOITISRECOMMENDEDTHAT

THEFIREISALLOWEDTODIEDOWNANDTHELIGHTSARETURNEDOFFATLEAST20MINUTESLATER.



AFTERCAREANDMAINTENANCE



1. USEONLYASOFTLINTFREECLOTHANDWARMWATERTOCLEAN.DONOTUSEHOUSEHOLDCLEANERSOR

ABBRASIVES.

2. APOTOFGEOCASTTOUCH‐UPSTAINISPROVIDEDINCASEOFSMALLSCRATCHESTOTHEGEOCASTBEAM.

PLEASEPRACTICE,USINGSPARINGLYANDAPPLYINANUMBEROFVERYTHINLAYERS,ALLOWINGTODRY

BETWEENAPPLICATIONS.

3. GEOCASTBEAMSARESUITABLEFORNOMORETHAT20kgUNIFORMLYDISTRIBUTEDLOADONTHESHELFWITH

UPTO6kgCONCENTRATEDLOAD.

4. FORTHEAMBIENTLITBEAMS,LAMPS(MR11)CANBEREPLACEDBYTHEEND‐USER,TAKINGCARETOISOLATEAT

THEMAINSFIRST.THETRANSFORMERCANBEREPLACED.THISSHOULDBECARRIEDOUTBYAQUALIFIED

ELECTRICIAN.