USER MANUAL DV WITH CONTROLLER VERSION 1.01.13 90925372


51

o.2Transportofsectionwithheatpumpunit
Duringtransportation,theunitsection–DVU‐mustalwaysbeintheuprightpositionortiltedlessthan
30˚.Ifitisnecessarytotilttheunitmorethan30˚,thesuctionpipeofthecompressormustpoin tupwards
topreventtheescapeofoilfromthecompressorsump.
o.3Disposaloftheheatpumpsystem‐typeDVU
PriortothedisposaloftheDVUunitsection,therefrigerantintheheatpumpsystemmustbedrainedoff
byaskilledtechnicianfromacertifiedcompany.Aftercorrectevacuationoftherefrigerant,thedisposalof
theDVUunitsectionissimilartothedisposaloftherestofthe
airhandlingunit.
o.4Genereldisassembly–sharpedges
Payattentiontoseveralsharpedgesduringdismantlinganddisposaloftheunit.Toavoidinjury,CE‐marked
cut‐resistantglovesaswellashelmetmustbeused.Themeasuresaredescribedfurtherinthe
Maintenance,DismantlingandDisposalManual.
p.Instructionsformachinerywheretheseareregularlytobetransported
ThesubjectintheMachineryDirectiveaboutmachinerythatareregularlytobetransporteddoesnotexist
fortheTIMEandDVairhandlingunits,becausethoseunitsareforspeciallymadeforoneintended
application.
q.Theoperatingmethodtobefollowedintheeventofbreakdown.Safe
restart.
Usethebelowmentionedprocedureintheeventofbreakdownorblockage:
 Switchoffthepowerandlocktheautomaticcircuitbreakerbypadlocksintheoffposition.
 Removethereasonforbreakdownorblockage.
 Followthestart‐upproceduredescribedinsectionk.

r.Adjustmentandmaintenanceoperations
Mustbeperformedbyskilledtechnicians.
Inconnectionwithdemandsforcompensation,Systemairmustha vefullandunhinderedaccesstoall
relevantreportingonservice,repair,modificationandusesincetheunitwastransferredfromSystemairto
atransportcompanyattheSystemairfactory.Itisaconditionforcompensationthat
maintenanceoutlined
onthefollowingpageshasasaminimumbeenperformed.
r.1Shutdownoftheunittoasafestate.
SwitchtheunittoOFFontheSystemairControlPanel.Seethe‐Operator’sGuide–Annex17.Switchoffthe
automaticcircuitbreakersandblockthembypadlocks.TheautomaticcircuitbreakersaremarkedF1toF4.
Seetheillustrationbelowabouthowtoplaceapadlockoneachautomaticcircuitbreaker.


