Installation Instructions

6
SunRite | Gas-Fired Infra-Red Tank Top Heater Operating Instructions and Owner’s Manual
NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!
LIGHTING INSTRUCTIONS
A. Beforeattemptingtolighttheheater,checkallfittingsand
connectionswithasoapsolution.NEVER USE A MATCH TO
CHECK FOR LEAKS.Shouldagasleakoccur,donotattempt
torepairoruseheater.Returntheheatertoyourdealerorthe
addressgivenonbackpage.
B.Fuel–Thisheatermustbeusedonlywithavaporwithdrawal
LPgasbulkcylinder.THEBULKTANKMUSTBEEQUIPPED
WITHASTANDARDPOLVALVE.
WARNING
USEHD.5PROPANEGASONLY.DONOTUSEANYOTHER
TYPEFUEL.SEEYOURPROPANEDEALERIFYOUHAVEANY
QUESTIONSREGARDINGFUEL.
C.Turntheheater’s“Hi-Med-Lo-Off”regulatorknobto“Med”
(counterclockwise).
D.Tolightheater,placealitmatchinsideholeonrearreflector
marked“lighthere”.(SeeFigure5)THENpushinvalvebutton
onSafetyShutoffValve.Aftertheheaterislit,continueto
holdvalvebuttoninfor30seconds,thenreleasethebutton
slowly.CAUTION:DONOTPUSHINVALVEBUTTONBEFORE
INSERTINGLITMATCH.NEVERSTANDINFRONTOFHEATER
WHILELIGHTING.
E. Ifburnerdoesnotlightwithin30seconds,turntheheater’s
regulatorknobto“off”(clockwise)andallowatleastfive
minutesforgastodissipatebeforeattemptingtorelight.
F. NOTE:Shouldtheorificebecomecloggedasindicatedbylow
volumeofgaswhenoperatingon“Hi”withafullcylinder,
orshouldtheheaterfailtooperateproperlyforanyreason,
returntheheatertothedealerortheaddressgivenonback
pageforrepairorreplacement.DONOTATTEMPTTOREPAIR
ORTAMPERWITHHEATER.
G.Adjustheatoutputbyturningknobtodesiredposition.
H. DO NOT USE THIS HEATER FOR COOKING.
Figure5.
Model:SRC15T
SHUTDOWN AND STORAGE
INSTRUCTIONS
A.Thebulkpropanetank“on-off”valveshouldALWAYSbe
completelyturned“OFF”whentheheaterisnotinuse.
B.Whenshuttingofftheheater,turntheregulatorknobonthe
heaterto“OFF”(clockwise).
C. CAUTION:Afterturningunitoff,heaterwillremainextremely
hot.Allowatleast15minutesforcoolingbeforehandlingand
storing.Detachheaterfrombulktankbeforehandlingand
storage.REMEMBER–POLfittingisaleft-handthread.
D. HEATER STORAGE:Indoorstorageoftheheateris
permissibleonlyifthecylinderisdisconnectedandremoved
fromtheheater.Cylindersmustbestoredoutdoorsoutofthe
reachofchildrenandmustnotbestoredinabuilding,garage
oranyotherenclosedarea.Storecylindersonlyinaccordance
withtheStandardfortheStorageandHandlingofLiquefied
PetroleumGasesANSI/NFPA58andCSAB149.1,NaturalGas
andPetroleumInstallationCode.
E. Seepage7forsparepartslist.
MAINTENANCE
A.Removethermocouple(3)retainingbracketscrewfrombackof
burnerassembly(2).Removebracket.
B. Notepositionofthermocouple(3)inretainingtabsonthe
backoftheBurnerassembly(2).Removethethermocouple.
C.Removewingbolt(18)andfiberwasher(19)thatattachedthe
safetyshut-off(6)totheburnerAssembly(2).
D. Slidethesafetyshut-off(6)fromburnerassembly(2).
E. Removeburnerorifice(20)fromthesafetyshut-off(6).
F. Cleanburnerorificewithcompressedair(80psimax).
G.Directcompressedairthroughtheburner(2)venturitube
towardtheburnerplenumsothatdustcollectedonthegrid
screenwillbeblownoutward.Keepfaceawayfromthegrid
screen.
H. Reassembleheaterinreverseorderofdisassembly.
Model:SRC15T
Model:SRC30T