Use and Care Manual

ManualsBrandsSun Joe ManualsElectric Pressure WashersSPX6000C-XR

, LLC

A Division of Snow Joe

, LLC

OPERATOR’S MANUAL

SAVE THESE INSTRUCTIONS

Model SPX6000C

Form No. SJ-SPX6000C-880E-M

CORDLESS GO-ANYWHERE PRESSURE WASHER

40 V MAX | 1160 PSI | PRESSURE SELECT

IMPORTANT!

Safety Instructions

All Operators Must Read These

Instructions Before Use

mWARNING! This indicates a hazardous situation, which,

if not avoided, could result in death or serious injury.

mCAUTION! This indicates a hazardous situation, which,

if not avoided, could result in minor or moderate injury.

mDANGER! This indicates a hazardous situation, which,

if not followed, will result in death or serious injury.

General Safety

mWARNING! This appliance is not intended for use

by children or by unassisted, unsupervised persons whose

physical, sensory or mental capabilities prevent them from

using it safely. Children should be supervised to ensure that

they do not play with the appliance.

Before starting up your machine, please check it carefully for

any defects. If you nd any, do not start up your machine.

Contact your authorized Snow Joe

+ Sun Joe

dealer or

call the Snow Joe

+ Sun Joe

customer service center at

1-866-SNOWJOE (1-866-766-9563).

mWARNING! When using the pressure washer, basic

safety precautions should always be followed to reduce the

risk of re, electric shock, and personal injury. These include:

• Know your product – Know how to stop the machine and

bleed pressure quickly. Thoroughly familiarize yourself with

the controls.

• Keep bystanders away – All visitors and pets should be

kept a safe distance away from the work area.

• Use the right product – Do not use this machine for any

job except that for which it is intended.

• Dress properly – Do not wear loose clothing or jewelry.

They can get caught in moving parts. Protective rubber

gloves and non-slip footwear are recommended when

working outdoors.

• mCAUTION! – Exercise caution to avoid slipping or falling.

Wear protective footwear that will protect your feet and

improve your footing on slippery surfaces.

• Stay alert – Watch what you are doing. Use common

sense. Do not operate the pressure washer when you are

tired, or under the inuence of alcohol or drugs.

• Do not overreach – Keep proper footing and balance at

all times.

• Avoid unintentional starting – Do not carry a machine with

power with your nger on the trigger. Make sure the switch

is o before insert the battery.

• Remove the battery – Remove the battery from the

pressure washer when it is not in use, before servicing it,

when changing accessories, and when performing any

other maintenance task.

• Use safety glasses – Also use safety footwear, snug-tting

clothing, protective gloves, hearing and head protection.

• Check the water temperature – This pressure washer is

not meant to pump hot water. NEVER connect it to a hot

water supply or pour hot water into the bucket as it will

signicantly reduce the life of the pump.

• Store indoors – NEVER store the pressure washer

outdoors or where it could freeze. The pump could be

seriously damaged.

mWARNING! Do not use this appliance without reading

this instruction manual.

mWARNING! This appliance has been designed for

use with cleaning agents that are recommended by the

manufacturer. The use of other cleaning agents or chemicals

may adversely aect the safety of the appliance.

mWARNING! Do not use the appliance within range of

persons unless they are wearing protective clothing.

mWARNING! High-pressure jets can be dangerous if

subject to misuse. The jet must not be directed at persons,

pets, live electrical equipment, or the appliance itself.

• Do not direct the jet at yourself or others in order to clean

clothes or footwear.

• Risk of explosion – Do not spray ammable liquids.

• Keep children away – This cordless high-pressure washer

must not be used by children or untrained personnel. Close

supervision is necessary when a product is used near

children.

• To ensure appliance safety, use only original replacement

parts from the manufacturer or those approved by the

manufacturer.

mWARNING! During cleaning, maintenance or when

replacing parts, the machine must be disconnected from its

power source by removing the battery.

Summary of content (24 pages)

PAGE 1
CORDLESS GO-ANYWHERE PRESSURE WASHER 40 V MAX | 1160 PSI | PRESSURE SELECT Model SPX6000C Form No. SJ-SPX6000C-880E-M OPERATOR’S MANUAL A Division of Snow Joe , LLC ® IMPORTANT! • Stay alert – Watch what you are doing. Use common sense. Do not operate the pressure washer when you are tired, or under the influence of alcohol or drugs. Safety Instructions • Do not overreach – Keep proper footing and balance at all times.
PAGE 2
mWARNING! High-pressure hoses, fittings, and not wire a battery pack to a power supply plug or car cigarette lighter. Such misuse will permanently disable or damage the battery pack. couplings are important for the safe operation of the appliance. Use only hoses, fittings, and couplings recommended by the manufacturer. • Avoid dangerous environments – Do not charge the battery pack in rain, snow or in damp or wet locations.
PAGE 3
• Do not disassemble – Incorrect reassembly may pose a serious risk of electric shock, fire or exposure to toxic battery chemicals. If the battery or charger are damaged, contact an authorized Snow Joe® + Sun Joe® dealer or call the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563) for assistance. 8. Protect batteries and the tool from overloads.
PAGE 4
Risk of Explosion 9. Charging batteries at a temperature below 50°F (10°C) will cause chemical damage to the cells and may cause a fire. • Do not spray flammable liquids. 10. Do not use batteries that have been exposed to heat during the charging process, as the battery cells may have suffered dangerous damage. • Do not use acids, bases, solvents, or any flammable material in this product. These substances can cause physical injuries to the operator and irreversible damage to the machine. 11.
PAGE 5
Safety Symbols The following table depicts and describes safety symbols that may appear on this product. Read, understand, and follow all instructions on the machine before attempting to assemble and operate. Symbols Descriptions Symbols Descriptions READ THE OPERATOR'S MANUAL(S) – Read, understand, and follow all instructions in the user manual(s) before attempting to assemble and operate. SAFETY ALERT – Indicates a precaution, a warning, or a danger.
PAGE 6
Know Your Cordless Pressure Washer Read the owner’s manual and safety instructions carefully before operating the cordless pressure washer. Compare the illustration below to the cordless pressure washer in order to familiarize yourself with the location of the various controls and adjustments. Save this manual for future reference. 1 1 FRONT 2 3 4 BACK 16 17 5 15 18 14 6 13 7 32 33 20 21 22 31 8 9 34 30 10 11 23 12 29 19 24 0º 15º 25º 40º 28 27 26 25 1. Trigger gun 13.
PAGE 7
Unpacking Assembly 1. The washer must be used on a secure and stable surface in a standing, upright position (Fig. 1). Carton Contents • Water bucket assembly • Base unit Fig. 1 • Trigger gun • Spray wand • Four (4) Quick-Connect nozzles (0º, 15º, 25º, and 40º) • Needle clean-out tool • Soap dispenser attachment • Trigger gun holder • High-pressure hose • Garden hose adapter (female coupler) • 40 V EcoSharp® battery 2. Open the bucket lid, take the base unit out from the bucket (Fig. 2).
PAGE 8
Fig. 3 Fig. 5 Trigger gun holder 1. Flip up Bucket buckle 2. Press the end mWARNING! When the water bucket is fixed on the base unit, do not lift the pressure washer by the handle. Instead, use the tow handle to pull the pressure washer unit along on its wheels (Fig. 6). 4. Align the water inlet on the base unit with the outlet on the bottom of the bucket, and seat the bucket on the base unit. Check alignment to ensure a proper seal and connection (Fig. 4). Fig. 6 Fig.
PAGE 9
7. Unlock the lock latch by moving it down, and insert the high pressure hose into the high pressure hose connection on the end of the trigger gun. Slide the latch back to lock the hose in place (Figs. 8 – 9). Fig. 10 Fig. 8 Lock latch Water outlet High-pressure hose High-pressure hose Twist clockwise while pressing firmly Fig. 9 9. Put the trigger gun with spray wand assembly on the gun holder. Your pressure washer is ready for use (Fig. 11). Fig.
PAGE 10
Battery Pack Operation • Use the battery charge indicator lights to determine when to charge your EcoSharp® iBAT40 lithium-ion battery pack. The equipment is powered by a lithium-ion battery. The battery pack is completely sealed and maintenance free. Battery Charge Level Indicator The battery pack is equipped with a push button for checking the charge level.
PAGE 11
3. Place the battery pack into the charger by sliding the pack as shown to lock it into position. When you insert the battery into the charger, the bottom red light will illuminate to indicate that the battery is charging (Fig. 13). 7. When charging is complete, remove the battery from the charger by pulling the push lock button and sliding the battery backward to unlock it from the charger (Fig. 15). Fig. 15 4. When the bottom light turns green, the battery is fully charged (Fig. 14). Fig.
PAGE 12
The TSS system will work only when there's water in the bucket or the base unit is connected with a water supply. When there's no water connected with the unit, the On/Off button has to be pressed to stop the unit. mIMPORTANT! This system is capable of producing 8 Mpa. To avoid rupture and injury, do not operate this pump with components rated less than 8 Mpa working pressure (including but not limited to spray guns, hose, and hose connections).
PAGE 13
6. If only using the base unit, turn the water supply tap on completely. 7. Push the safety lock on the spray gun handle, then press the trigger for a few seconds until the water flow is steady. Operating the pressure washer in this manner will allow air to escape and discharge residual pressure in the hose (Fig. 20). Fig. 20 Safety lock 9. When re-starting the motor, always keep the trigger pressed. NOTE: The motor only runs when the trigger is operated and shuts off when the trigger is released.
PAGE 14
Working with Detergents 4. Turn on the pressure washer. Pull the trigger to operate the unit. When cleaning with the pressure washer, some cleaning tasks can be solved with water alone, but for most tasks cleaning with detergent allows for more effective dirt removal. mCAUTION! Always test the detergent in an inconspicuous area before use. 5. Apply detergent from the bottom to the top of the dry surface to be cleaned. mWARNING! Use only detergents specifically designed for use with pressure washers.
PAGE 15
mWARNING! Turn off the water supply and squeeze the I) The 0º intense-jet nozzle (orange) is an extremely powerful nozzle that delivers a high-pressure, pencilpoint jet stream. It is used to cut heavy dirt deposits in a small, concentrated area. It is ideal for dissolving stubborn substances, like tar and grease spots on concrete, or for removing caked mud from equipment. Use this nozzle to clean hard-to-reach areas including the facades of 2-story buildings or the undersides of lawn mowers and tractors.
PAGE 16
Maintenance mCAUTION! Before working on the pressure washer, 3. Remove additional debris by back flushing water through the nozzle and spray wand. To do this, place the end of your garden hose (with water running) to the tip of the nozzle, pushing water and debris out of the back opening of the nozzle and spray wand. remove the battery from the compartment. 1. To ensure good performance, check and clean the water inlet filter.
PAGE 17
iCHRG40 5. Do not mix Alkaline, Standard (Carbon-Zinc) or Rechargeable (Nickel Cadmium, Nickel Metal Hydride, or Lithium-Ion) batteries. Federal Communications Commission (FCC) 6. Do not dispose of batteries in fire. 7. Batteries should be recycled or disposed of as per state and local guidelines. mWARNING! Any changes or modifications to this Service + Support unit not expressly approved by the party responsible for compliance could void the user's authority to operate the equipment.
PAGE 18
Troubleshooting • Remove the battery from the compartment before carrying out maintenance on the machine or when checking that its parts are in proper working order. • To avoid unnecessary hassles, consult the following table before contacting customer service with any mechanical issues.
PAGE 19
Optional Accessories mWARNING! ALWAYS use only authorized Snow Joe + Sun Joe® replacement parts and accessories. NEVER use replacement parts or accessories that are not intended for use with this cordless pressure washer. Contact Snow Joe® + Sun Joe® if you are unsure whether it is safe to use a particular replacement part or accessory with your pressure washer. The use of any other attachment or accessory can be dangerous and could cause injury or mechanical damage.
PAGE 20
NOTES 20
PAGE 21
NOTES 21
PAGE 22
NOTES 22
PAGE 23
SNOW JOE® + SUN JOE® CUSTOMER PROMISE ABOVE ALL ELSE, Snow Joe® + Sun Joe® are dedicated to you, our customer. We strive to make your experience as pleasant as possible. Unfortunately, there are times when a product does not work or breaks under normal operating conditions. We think it’s important that you know what you can expect from us. That’s why we created the Snow Joe® + Sun Joe® promise. OUR PROMISE: Snow Joe® + Sun Joe® warrant new products for two years from the date of purchase.
PAGE 24
snowjoe.com mWARNING! This product contains lead, a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling. mWARNING! This product or its power cord contains chemicals, including lead, known to the State of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling.