Operating Guide

29

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



YEARLYMAINTENANCE

CleaningPelletFinesfromtheHopperandAuger

Dependingonthetypeandqualityofpelletsburnedinthestove,someaccumulationofpelletfinesand

dustispossibleinthehopper.Thelowestpartoftheauger,nearthebackofthestove,iswheremostfines

willaccumulate.Withthestoveoff,unplugged,completelycooland

withthehopperempty,useautility

vacuumtoremovethefinesfromtheaugertube.Ifthefinescannotberemovedfromthetopofthehopper:

 Removethebackpanel,usinga

”sockettoremovethescrews .

 Locatetheaugermotorassemblyatthemiddlerearofthestove,andonceitisfound,findthe

twosetscrewsoneithersideofthecastironmountingcollar.

 Usinga

”allenwrench,loosenthesetscrewoneithersideoftheaugermountingcollar.

 Withautilityvacuuminhand,lettheaugerassemblyslideoutoftheaugertubejustenou gh 

sothatthevacuumcanbeusedtoremoveanyfinesfromthisarea.

 Reinstallthe

augerassemblyandtightenthetwosetscrews;reinstallthebackpanel,being

certaintotightentheretainingscrewsontherearofthestove.



CleaningPelletFinesInsideAugerTube

 Removetheaugercoverplate(locatedabovetheaugeratthebottomofthehopper)by

removingthe(8)5/16”screwsthatholditinplace.Usingautilityvacuumremoveanyexcess

dustorfinesthathavecollectedintheaugertubearoundtheauger.

 Re‐installauger

coverplateinreversemethod.

CheckingGaskets

Anairtightsealatthedooropeningiscrucialtoproperstoveperformance.Anyairleaksinthisareacan

notonlycauseadirty,inefficientburnbutcanalsoposeaserioussafetythreat.Becauseofthis,thedoor

gasketshouldalwaysbemaintainedingoodcondition,andreplacedannuallyorsoonerifnecessary.Gasket

tightnesscanbecheckedusingthe“dollar‐bill”method:

 Placeadollarbillbetweenthegasketandthestovebody(atthelocationwherethegasket

meetsthestove).

 Closethedoortightlyandattempttopullthedollarbillout.Ifthedollarbillslidesinandout

easily,thegasketneedstobereplaced.Thistest

shouldberepeatedaroundtheentiregasket

perimeter,asgasketswillsometimessealtightlyononeside,butwillbewornandsealpoorly

onanotherside.

