Operating Guide

25
IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND
REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.
ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR
USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.


WEEKLYMAINTENANCE
BaffleRemoval
 Aswithanymaintenanceconcerningthisunit,besuretheunitis“OFF,”hascompleted
theShut‐Downcycle,andiscompletelycoolBEFOREbeginning.Beawarethatmetal
partsinthefireboxcanremainHOTlongafterthefirehasgoneoutandEVENafterthe
Shut‐Downcycle
iscomplete.Alwaysuseextremecautionwhenhandlingpotentially
hotstoveparts,evenifyouthinktheyshouldbecold.
 WeeklymaintenanceshouldincludethestepslistedinthissectionASWELLASthesteps
listedinthe“DailyMa intenance”section.
 Removethetopbaffle(insidethefirebox,abovethedoor)byliftingitupandpullingit
forward,thentiltingitsidewaystoremoveitfromthestove.Thepartnumberforthe
topbaffleisAC‐CBTB.
 Removeanyashthathasaccumulatedbehindthebaffleinthestove.
 Theuseofautilityvacuumishighlyrecommende dbecauseitwillpreventfly‐ashfrom
fallingthroughtheexhaustholesandintotheexhaustchamber.
 Replacethebafflebyreversingtheabovesteps.Besurethetabsinthebafflefitintothe
matchingholesinthefireboxwallofthestove.Thetopofthebafflewillrestagainstthe
frontwallofthestovewhenitisproperlyinstalled.
Clean‐OutCovers
 Removetheexhaustchamberclean‐outportcovers(lowerleftandright,oneitherside
oftheburnpot).Usea5/16”socketwrenchtoloosenthescrewoneachcover,then
pullthecoverupwardstoremoveitfromthescrew.
 BEFOREvacuumingthechamberout,observethetypeandquantityofashbuild‐up.
Theashdepositedintheexhaustchambershouldbelight,fluffy,greyorwhiteincolor,
andshouldbenohigherthanhalfwayuptheclean‐outport.
 Usingautilitytypevacuumcleaner,vacuumtheflyashoutoftheexhaustchamber.A
shortpieceofhosecanbeattachedtotheendoftheutilityvacuumlineandcanbe
usefulinreachingtheash.Replacetheclean‐outportcoverswhenfinished.
 Aspeciallydesignedashvacuumandpelletstovecleaningkitisavailablefromthe
England’sStoveWorkswebsite;pleasesee:store.heatredefined.com.

MONTHLYMAINTENANCE

 NOTE:Aswithanymaintenanceconcerningthisunit,besuretheunitis“OFF,”has
completedtheShut‐Downcycle,andiscompletelycoolBEFOREbeginning.