Operating Guide

40
IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND
REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.
ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR
USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.


 Reinstalltheventingsystemandpanels. 
 NOTE:Asanoption,thereisaCombustionMotorGasketthatisincludedwithPart#PU‐CBMG,which
allowsyoutoremovethemotor(only)fromthecombustionblowerhousing,cleanthemotorand
insideoftheblowerhousing,andreplace
themotoranditsgasketwithouthavingtoremovetheentire
CombustionBlower.Rememberthattheblowerimpeller,blowertubeandsteelblowerexhausttube
onthestoveshouldbebrushedandvacuumed.


ConvectionBlowerCleaning
 Asalways,becertainthestoveiscoolandunpluggedbeforeservicinganycomponentswithinthe
unit.Sincetheconvectionblowerdoesnothandleanyby‐productsofcombustion,itdoesnot
requireseriouscleaninglikethe exhaustblower.
 However,dustfromthehomeandotherdebrisintheaircanaccumulateonthebladesofthe
convectionblower.Anydustthathasbuiltuponthefanbladescanusuallybeeasilyremovedwith
avacuumorasoftpaintbrush.
 Thebackpanelwillneedtoberemovedfromthestove,usinga5/16”wrench.
 Thecontrol(circuit)boardwillneedtoberemoved,byremovingthetwo5/16”screwsandpulling
thecontrolboardoutofthestove.Somewiretiesmayneedtobecutsothattheboardcanbe
pulledoutofthewayoftheblower(remembertoreplacethem).
 Four5/16”screwswillneedtoberemovedinordertoremovetheconvectionblowerfromthe
stove.Youwilllikelyneedasocketwithalongextension.
 Installtheblowerinthereverseorderasdescribedabove.
 AlsoseetheConvectionBlowerremovalinstructionsintheReplacingComponentssectionofthe
manual.

FINISH
 ThisnewunithasbeenpaintedwithHigh‐Temperaturepaintthatshouldretainitsoriginallookfor
years.
 Iftheunitshouldgetwetandrustspotsappear,thespotscanbesandedwithfinesteelwooland
repainted.ItiscrucialthatonlyHigh‐TemperatureSprayPaintisused(Part#AC‐MBSP),asothers
maynotadheretothesurfaceorwithstandthehightemperatures.
 Similarly,somebrandsofpaintwillnotadheretodifferentbrandsofpaint,sowehighly
recommendusingourproprietaryHigh‐TemperatureSprayPaint.

GASKETS
 Gasketsshouldbeinspectedandreplacedannually.SeetheGasketspageinReplacingComponents
(page49)forinformationandinstructions.
