Operating Guide

ManualsBrandsSummers Heat ManualsPellet Stoves2,000-sq ft Pellet Smartstove

35

IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND

REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.

ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR

USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



CleaningtheBurnPot

Alongwithremovingashesfromthestove,

cleaningtheburnpotistheotheressentialpart

ofdailymaintenancethatwillkeepthestove

operatingatitspeak.Pelletscontainvarying

amountsofimpuritiesandfusiblematerialthat

willaccumulateintheburnpotovertime.Some

pelletswillcontainmuch

higheramountsof

thesefusibleimpurities,thereforeextravigilance

mayberequiredtomaintainacleanburnpot.

Allowingimpuritiestobuildupintheburnpot

canrestricttheairflowtothefire,resultingina

dirty,inefficientburnandcanshortenthelifeof

theburnpot.



NOTE:Theburnpotshouldactuallybecleanedoutbeforeeachstart‐up(beforepressingthe

ONbutton),anddaily.

 Alwaysallowthestovetofinishtheshut‐downcycleandcoolcompletelybeforeperforming

anymaintenanceinsidethefirebox.

 Openthefrontdoortoaccesstheburn

pot.WARNING–TheburnpotcanremainHOTlong

afterthefirehasgoneout,sowearprotectivegloveswheneverhandlingapotentiallyhotburn

pot,ifyouremoveit.

 Removeandcleantheburnpotwearplate(refertotheexplodeddiagramintherearofthis

manual,

andthediagramonthepreviouspage).

 Removeanyashbuild‐upintheareabelowthewearplate.Also,besuretherearenoashesor

obstructionsintheintaketubeunderthewearplate.IMPORTANT:Ashbuild‐upunderthe

wearplatecancausetheunittomalfunction.

 Checkforanybuild‐upinthefrontoftheburnarea.Cleanoutallairholesinthewearplate(if

necessary,a1/8”drillbitcanbeused)‐‐theseairholesshouldbekeptclean,astheysupply

combustionairunderandaroundthepelletfuel.

 The

burnpotassemblyshouldalsobethoroughlycleaned,includingtheburnbox.When

replacingthewearplate,ensurethatitliesflat inthefireboxandnogaps(fromashresidue)

areunderit.Inserttheburnpotbackintothecradleifyouhaveremovedtheentireburnpot,

andbesuretotightenthesetscrews,butdonotover‐tightenthem.

BottomAugerTube

IntakeTube

underWear

Plate

BurnPot