StorCase® Technology Data Express® DE75i-SWC160 Removable SCSI Wide Ultra160 Drive Enclosure with SCA Interface User's Guide
i StorCase® Technology Data Express® DE75i-SWC160 Removable SCSI Wide Ultra160 Drive Enclosure with SCA Interface User's Guide Part No. D89-0000-0109 B01 December 2002 StorCase Technology, Inc. 17600 Newhope Street Fountain Valley, CA 92708-9885 Phone (714) 438-1850 Fax (714) 438-1847 DE75i-SWC160 User's Guide - Rev. B01 StorCase Technology, Inc.
ii LIMITED WARRANTY STORCASE TECHNOLOGY, Incorporated (StorCase) warrants that its products will be free from defects in material and workmanship, subject to the conditions and limitations set forth below. StorCase will, at its option, either repair or replace any part of its product that proves defective by reason of improper workmanship or materials.
iii Free Technical Support StorCase provides free technical support. If you experience any difficulty during the installation or subsequent use of a StorCase product, please contact StorCases Technical Support Department prior to servicing your system. This warranty covers only repair or replacement of defective StorCase products, as described above. StorCase is not liable for, and does not cover under warranty, any costs associated with servicing and/or installation of StorCase products.
iv Declaration of Conformity Company Name: StorCase Technology, Inc.
v Table of Contents INTRODUCTION ..................................................................................................................... Packaging Information .................................................................................................. Serial Numbers .............................................................................................................. Package Contents ................................................................................................
vi List of Figures Figure 1: Figure 2: Figure 3: Figure 4: Figure 5: Figure 6: Figure 7: Figure 8: Figure 9: Package Contents .......................................................................................... 2 DE75i-SWC160 Receiving Frame and Carrier ............................................... 3 Receiving Frame Front Panel ......................................................................... 4 Receiving Frame Unit ID Number and Activity Display .................................
Introduction 1 INTRODUCTION Packaging Information The StorCase Technology Data Express® system is shipped in a container designed to provide protection and prevent damage during shipment. The Data Express unit was carefully inspected before and during the packing procedure at the factory. Bent or broken connectors, or evidence of other damage to the Data Express should be reported to the shipper immediately. Refer to Figure 1 for the package contents.
2 Introduction Package Contents The DE75i-SWC160 product shipment should include the following items. If any item is missing or damaged, contact your StorCase dealer for a replacement. 0454a Da ID Driv e Car Sele rier Disk (No Driv t Incl e ude d) Pow er I/O Cab Cable le ta E xpr ess Cab Cov (Pro er le vide d) ct Cab le Driv Har e Phil 3/16 lipsdwareMountin Flat # 6-32(4ea g HD x ) 0151 1. 2. 3. 4.
Introduction 3 General Description The StorCase Technology Data Express® DE75i-SWC160 is composed of a receiving frame which supports SCSI Wide Ultra160 interfaces and fits within a 5.25" half-height peripheral slot. This 16-bit I/O can support up to 160MByte/sec transfer rates. The receiving frame contains one (1) removable drive carrier designed to provide durable and reliable mounting for one (1) 3.5" form factor, low-profile (up to 1" high) 80-pin Single-Connect Attachment (SCA) SCSI drive (Figure 2).
4 Introduction Receiving Frame Front Panel (Figure 3) The Key Lock/Drive Power Switch performs three (3) functions. The key lock assures proper seating of the device carrier within the receiving frame, turns power to the device carrier on and off, and prevents unauthorized removal or installation of the carrier. For the computer to access data on the DE75i-SWC160 disk drive, the key must be turned counterclockwise to the locked position.
Introduction 5 Figure 4: Receiving Frame Unit ID Number and Activity Display Receiving Frame Rear Panel (Figure 5) DC Power Connector (J1): The Data Express uses a standard 4-pin DC power connector to accept DC power. I/O Connector (J3): The input/output connector provides a standard interface for 16-bit SCSI Wide Ultra160 signals. Option Pins Remote Unit ID Selection: Pins 1-8 of this connector are provided for remote unit SCSI ID selection through the computer system.
6 Introduction Figure 5: Receiving Frame Motherboard (Rear View) StorCase Technology, Inc. DE75i-SWC160 User's Guide - Rev.
Installation 7 INSTALLATION Installing the Drive in the Carrier Preparation While performing the steps in this section, work on a soft surface to prevent excessive shock to the drive being installed. Also refer to the manufacturer's documentation provided with the drive. NOTE: A #2 Phillips screwdriver will be required during this procedure. 1. Remove the drive from its protective packaging. 2. Plastic Drive Bezel: If the drive came equipped with a plastic front bezel, it must be removed. 3.
8 Installation Figure 6: Drive Installation Assembly StorCase Technology, Inc. DE75i-SWC160 User's Guide - Rev.
Installation 9 Installing the Receiving Frame The drive should be installed into the carrier before installing the receiving frame into the mounting bay of a computer or expansion chassis. NOTE: Use a #2 Phillips screwdriver during this procedure. 1. Turn OFF power to the computer. 2. Open the computer system according to the manufacturers instructions. If necessary, temporarily remove any expansion boards that may make installation difficult. 3.
10 Installation Table 1: Option Pin Connector Signal Descriptions PIN Signal Function 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 ID0 GND ID1 GND ID2 GND ID3 GND SYNC GND RLEDA RLEDC DFAULT GND NC GND RMTST GND DLYST GND LKA LKB SCSI ID Ground SCSI ID Ground SCSI iD Ground SCSI ID Ground Drive Synchronization Signal Ground Remote LED Anode Remote LED Cathode Force Drive Fault Signal to Display Ground No Connect Ground Remote Start Ground Delay Start Ground For Factory Use Only For factory
Installation 11 4. With the drive carrier locked into place inside the receiving frame, install the DE75i-SWC160 receiving frame into the drive opening in the computer or expansion chassis. Use the appropriate guides to position the DE75i-SWC160, and fasten it into place with the four (4) #6-32 Phillips screws provided. Figure 8 illustrates the location of the mounting holes.
12 Installation 8. Connect the power cable from the DC power supply in the computer or expansion chassis to the power connector on the DE75i-SWC160 receiving frame. Refer to Figure 5 for the DE75i-SWC160 receiving frame power connector location. 9. Replace any expansion boards that may have been removed earlier. Replace the system cover according to the manufacturers instructions. 10. Reconnect any system or peripheral cables removed earlier. 11. Turn on power to the computer.
Installation 13 5. The new drive may need to be formatted or initialized prior to use with the operating system and applications software. Refer to the drive and/or computer manufacturer's documentation for formatting information. Figure 9: Unit ID Select Switch Location DE75i-SWC160 User's Guide - Rev. B01 StorCase Technology, Inc.
14 Installation This Page Left Blank Intentionally. StorCase Technology, Inc. DE75i-SWC160 User's Guide - Rev.
Appendix A - Specifications/Dimensions 15 APPENDICES DE75i-SWC160 User's Guide - Rev. B01 StorCase Technology, Inc.
16 Appendix A - Specifications/Dimensions Appendix A - Specifications/Dimensions SCSI Data Express subsystems conform to the Small Computer Systems Interface (SCSI) Standard set by the American National Standards Institute (ANSI). The following DE75i-SWC160 specifications and dimensions are provided for reference only.
Appendix A - Specifications/Dimensions 17 Figure A-1: DE75i-SWC160 Physical Dimensions (Dimensions are for reference only) DE75i-SWC160 User's Guide - Rev. B01 StorCase Technology, Inc.
18 Appendix B - Attaching the ON/OFF Key Appendix B - Attaching the ON/OFF Key The following information will provide the necessary steps to attach the ON/OFF key to the key lock mechanism so that it is non-removable, preventing accidental key loss. The procedure can be reversed at a later date to revert back to a removable key. 1. Make certain power is OFF to the receiving frame. Locate the rectangular shaped key lock mechanism access hole on the inside of the receiving frame.
Appendix C - Optional Accessories 19 Appendix C - Optional Accessories Carrying Case Drive Carrier DX300-DE-C Carrying Case 0460 Figure C-1: Carrying Case The optional molded plastic carrying case is designed to transport the DE75i-SWC160 carrier from one site to another in a safe, impact and moisture resistant environment. Its compact dimensions, 7 long x 9 wide x 3.5 high, make it easy to carry and to store. The foam lining is contoured to fit a single Data Express carrier with a 1" form factor.
20 Appendix C - Optional Accessories Drive Plug Figure C-2: Drive Plug The drive plug (P/N DX75C/300C-PLUG) is designed to fill system or external enclosure bays that are occupied by receiving frames that have no carrier units installed. The purpose of the plug is to provide an attractive and functional method of directing proper air flow to the other installed devices in the system or external enclosure. StorCase Technology, Inc. DE75i-SWC160 User's Guide - Rev.
Reader's Comments 21 Reader's Comments Please take a few moments when your computer system is up and running to send us your ideas and suggestions for improving our products and documentation.
Reader's Comments CUT ALONG THIS LINE FROM BOTTOM TO TOP OF PAGE 22 FOLD ALONG THIS LINE AND STAPLE SHUT NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES B U S I N E S S R E P LY M A I L FIRST CLASS MAIL PERMIT NO. 10686 SANTA ANA, CA POSTAGE WILL BE PAID BY ADDRESSEE TECHNOLOGY CORPORATION 17600 NEWHOPE STREET FOUNTAIN VALLEY CA 92708-9885 StorCase Technology, Inc. DE75i-SWCU2 User's Guide - Rev.
