SDS

SAFETY DATA SHEET
PAGE: 3 PRODUCT: M4055 Black Lap Sealant
=====================================================================
8. EXPOSURE CONTROL/PERSONAL PROTECTION :
ENGINEERING CONTROLS: LOCAL EXHAUST: PREFERABLE
MECHANICAL EXHAUST: ACCEPTABLE-USE ONLY
CLASS I GROUP D APPROVED DEVICES.
9. PHYSICAL AND CHEMICAL PROPERTIES:
SPECIFIC GRAVITY: 1.085
DENSITY: (IN LBS): 9.05
VAPOR DENSITY: 3.66
EVAPORATION RATE (nBuAc=1): .51
SOLUBILITY IN WATER: NIL
BOILING RANGE (F): 278-290
PHYSICAL STATE: Black paste
% VOLATILE BY VOLUME: 46.13
AUTOIGNITION TEMPERATURE: 870 F
DECOMPOSITION TEMPERATURE: NOT AVAILABLE
FLASH POINT: TAG CLOSED CUP: 79 F
VAPOR PRESSURE AT 20C (MM OF HG): 11
(VOC) CONTENT: 400.4 g/liter
APPEARANCE: black paste
ODOR: CHARACTERISTIC HYDROCARBON SOLVENT
ODOR THRESHOLD: NO DATA
PH: NOT APPLICABLE
MELTING POINT/FREEZING POINT: -53 F
PARTITION COEFFICIENT: n-octanol/water= NO DATA
EXPLOSIVE/FLAMMABLE LIMITS: (LEL): 1.1 (UEL): 6.6
10. STABILITY AND REACTIVITY:
GENERAL: THIS PRODUCT IS STABLE AND HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
INCOMPATIBLE MATERIALS AND CONDITIONS TO AVOID: AVOID STRONG OXIDIZING AGENTS.
AVOID ALL SOURCES OF IGNITION. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL A
CONSIDERABLE DISTANCE TO AN IGNITION SOURCE AND FLASHBACK.
HAZARDOUS DECOMPOSITION PRODUCTS: NONE
11. TOXICOLOGICAL INFORMATION:
NOT IDENTIFIED AS A CARCINOGEN BY NTP, IARC OR OSHA
HEALTH EFFECTS:
LIKELY ROUTES OF EXPOSURE: skin adsorption, inhalation
DELAYED AND IMMEDIATE CHRONIC EFFETS FROM SHORT AND LONG-TERM EXPOSURE:
Skin: dry skin, dermatitis, de-fatting of the skin with chapping and cracking.
Inhalation: Inebriation, followed by headache and nausea. Dizziness, convulsions and unconsciousness in severe cases.
Anorexia and nervousness may persist for several months following acute overexposure.
NUMERICAL MEASURES (ACUTE TOXICITY ESTIMATE):
12. ECOLOGICAL INFORMATION:
AQUATIC AND/OR TERRESTRIAL EXOTOXICITY: UNKNOWN
PERSISTENCE AND DEGRADABILITY: UNKNOWN
BIOACCUMLATIVE POTENTIAL: UNKNOWN
13. DISPOSAL CONSIDERATIONS:
THIS MATERIAL IS CONSIDERED A HAZARDOUS WASTE FOR DISPOSAL PURPOSES. SEE 40 CFR PART 261.7
FOR FURTHER INFORMATION CONCERNING THE DISPOSITION OF EMPTY CONTAINERS. HAZARDOUS
WASTES MAY NOT BE LANDFILLED! REFER TO 40 CFR PART 261 SUBPART C FOR DEFINITIONS OF
HAZARDOUS WASTE.
SAFETY DATA SHEET