Trampoline & Enclosure Assembly Instructions WANT TO ENVIE DE MAT DIAMETER 7.8 ft x 11 ft (2.4 m x 3.4 m) MINIMUM NET HEIGHT FROM MAT 6 ft (1.8 m) SAUTER? TIME. ONE AT A FOIS. IT SAFE! UNE À LA JUMP? DO SÉCURITÉ! EN TOUTE FAITES-LE MAT HEIGHT FROM GROUND 3 ft (0.9 m) MAXIMUM USER WEIGHT 220 lbs (100 kg) The information in this document is subject to change without notice. © Copyright Springfree® Trampoline Inc. 2005, 2015. All rights reserved.
WARNING Read the warnings on this page and those contained in the User Guide before you assemble and use the trampoline and enclosure. No somersaults or flips. Landing on the head or neck can cause serious injury, paralysis, or death, even when landing in the middle of the bed. No more than one person at a time. Multiple jumpers increase the chances of loss of control and collision and can result in serious head, neck, back, leg, arm or other injuries.
WARNING A. Keep small children at least 25 ft (7.5 m) away while assembling the trampoline; they could be injured by improperly assembled rods releasing and ejecting from the frame. B. Do not attempt to use the trampoline until it is completely assembled. C. Be aware that when loaded, the rods can spring back and may cause injury. In particular, keep your face well clear of the rods during assembly or disassembly. An improperly installed rod could release and cause facial injury or blindness. D.
1 A If for an any rea easson you need d to remove a rod from the mat, do not twist or rotate the m at edge as shown. This cou ould cause serious inju njurry or damage the e tram mpoline. Si vous devez désinstaller une tiges du tapi tapiss, ne tordez et et ne tournez pas le bord du tapis. Cela peut entra ner de graves blessures ou des dommages au trampoline.
2 C B A D E F Part Quantity Part G Quantity A Curved Frame Sections 4 E Center Posts 6 B Straight Frame Sections 2 F Small Bolts & Nuts 12 C Orange Bent Legs 2 G Large Bolts & Nuts 6 D Yellow Legs 4 H C-clips (Attached to Frame) 10 Lay out the remaining parts as shown. The coloured stickers all face upwards. If you are missing any parts please contact Springfree® Trampoline directly. SCAN HERE or visit http://springfr.ee/g4-step-2 for a helpful installation video for Step 2.
3 5 4 3 1 6 2 WARNING - Use the tools provided to fasten the nuts. Do not over tighten the nuts. Do not use power driver, torque wrench, or drill. TIP - Fastening the final two frame sections often requires additional effort. Two people may be required for assembly. Connect and fasten one frame section at a time together with the large nuts and bolts. When finished, the bolt head should be flush with the frame and face out from the center of the trampoline (the nut should face the center).
4 Incorrect Position Correct Position NOTE - Before proceeding, double check that all of the bolts and nuts are tightened. Use the tools provided to fasten the nuts. Do not over tighten the nuts. Do not use power driver, torque wrench, or drill. Lay out the mat with the yellow stripes facing upwards inside the trampoline frame. The blue tags on the mat should approximately align with the blue stickers on the frame.
5 NOTE - As you install the white mat rods into the mat rod sockets the net will become tight against the frame. Handle the net with care and be sure that it does not get caught or it may tear. Locate the green tag on the bottom edge of the net and match it with one of the green stickers on the frame. Holding the net so that the green tag is facing you, gently place the rest of the net inside the frame as shown. DO NOT let go of the green tag.
6a 5 4 5 1 2 6 3 WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. WARNING - Both people must maintain a steady grip on the rod until it is securely installed in the mat rod holder. NOTE - Before you install the first white mat rod into a mat rod holder, read the instructions in Step 6b and 6c. NOTE - Following the sequence shown spreads the tension evenly across the mat.
6b 1 Have one person position themselves inside the frame of the trampoline while the other stands outside as shown. Incorrect Position Correct Position 2 Inside Person: Ensure that the mat rod holder is correctly positioned with the small tag positioned outside the mat rod holder pocket. 3 Inside Person: Take hold of the rod with both hands and maintain a steady grip until it is securely installed in the mat rod holder. Outside Person: Hold the white mat rod with your palm facing up.
6c 7 Outside Person: Rocking from your heels to the balls of your feet, use your body weight to push the white mat rod towards the center of the mat. 8 Inside Person: As the outside person pushes, carefully pull the rod in and up in the direction of the mat rod holder. Inside Person: Guide the white mat rod up and over the back edge of the mat rod holder and into position. Check that the rod is fully seated in the mat rod holder before continuing.
7 8 9 7 10 12 11 WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. NOTE - Follow the mat rod installation sequence. Do not install multiple mat rods in one location. If you do not follow this sequence, it will be very difficult to attach the mat. NOTE - Each time you circle the trampoline, check that the center posts of the leg sections are correctly seated under the trampoline frame.
8 WARNING - Do not use the trampoline until it is completely assembled. Failure to follow these instructions may cause rods to break or eject from the trampoline frame. NOTE - Check that the net is not caught on the trampoline frame or the bolts – if the net catches, it may tear. Moving clockwise around the frame, carefully slide the net up to the top of the white mat rods. Starting at a corner, carefully pull the net up over the edge of the mat.
9 2 1 Secure Unfold and align WARNING - Treat any loaded rod with caution until you are sure it is properly installed or uninstalled. Keep your face well away from any loaded rod. Assemble the black net rods as shown.
10 SERIAL NUMBER NUMÉRO DE SÉRIE G41530 WANT TO ENVIE DE SAUTER? AT A TIME. IT SAFE! ONE FOIS. UNE À LA JUMP? DO SÉCURITÉ! EN TOUTE FAITES-LE RECORD PURCHASE DATE IN THE SPACE PROVIDED / ENREGISTREZ LA DATE D'ACHAT DANS L'ESPACE PRÉVU: WARNING - Never attempt to remove a black net rod from its net rod pocket or disengage (unlock) the rod sleeve while the black net rod is under tension. NOTE - Please record the purchase date of your trampoline on the net serial number tag.
11 ENVIE DE AT A TIME. IT SAFE! ONE FOIS. UNE À LA JUMP? DO WANT TO SÉCURITÉ! EN TOUTE FAITES-LE SAUTER? WARNING - Make sure you read all warnings and precautions found in the User Guide before using the trampoline WARNING - If you anticipate severe weather, consider lowering the enclosure, moving the trampoline to a sheltered location or disassembling the trampoline completely. For increased stability, your trampoline comes with sandbags.
