Spike 14in Easy Rider Chopper Kids Bike 836/5967 933/9947 Important - Please read these instructions fully before performing any maintenance activities on the bike
WARNING! The bicycle is not suitable for the fitting of a luggage carrier and a child seat. The bicycle is not designed for public roads use. To avoid injury, please do not sit on the front oil tank and rear box. IMPORTANT! It is the responsibility of parents or guardians to ensure the safety of this bicycle including when used.
Part Stem bolt Handlebar clamp nut Seat post bolt Saddle clamp nuts Pedals Front wheel nuts Rear wheel nuts Cable pinch bolt Torque(Nm) 17-19 Nm 17-19 Nm 16-18 Nm 16-18 Nm 40 Nm 22-25 Nm 25-29 Nm 6-8 Nm
Replaced worn brake blocks or brake pads immediately!
ADJUSTING CHAIN TENSION Most children’s bikes have one gear and as a result the chain tension is very important. The chain should be able to move approximately 12mm(6mm up and 6mm down)at the mid-point between the front and rear gear sprockets. Chain Adjustment 30 WARNING:Do not attempt chain repairs.If there is a problem with the chain, have a bicycle service shop make any repairs. B A fig 16 Adjustment (fig 16) : The chain must be at the correct tightness.
Replace wheel when rim wear serious by visual check.
Lubrication Information Note: The frequency of maintenance should increase with use in wet or dusty conditions. Do not over lubricate- remove excess lubricant to prevent dirt build up. Never use a degreaser to lubricate your chain(WD-40 TM ). WARNING: Do not over lubricate.If lubricant gets on rims,tires or brake shoes, it will reduce control and braking performance and may require a longer stopping distance.Injury to the rider can occur.
