Owner manual

REPAIR AND MAINTENANCE SAFETY
NEVER operate your log splitter when it is in poor mechanical condition or in need of repair.
Periodicallycheckthatallnuts,bolts,screws,hydraulicttingsandhoseclampsaretightened.
NEVER alter your log splitter in any manner such as adding a rope or extension to the control lever or adding to the width
or height of the wedge. Such alterations may cause your log splitter to be unsafe and will void the warranty.
Perform all recommended maintenance procedures before using your log splitter.
Replace all damaged or worn parts immediately.
ALWAYS check the level of hydraulic oil and engine oil before operation.
ALLreplacementpartsmustmeetmanufacturer’sspecications.
Page 4
HYDRAULIC SAFETY
HYDRAULIC SAFETY
The hydraulic system of your log splitter requires careful inspection along with the mechanical parts. Be sure to
replace frayed, kinked, cracked or otherwise damaged hydraulic hose and components.
NEVER checkforleaksofhydraulicuidwithyourhand.Fluidescapingfromasmallholecanbealmostinvisible.
Escapinguidunderpressurecanhavesufcientforcetopenetrateskincausingseriouspersonalinjuryorevendeath.
Leaks can be detected by passing a piece of cardboard over the suspected leak and looking for discoloration.
ALWAYS seekprofessionalmedicalattentionimmediatelyifinjuredbyescapinghydraulicuid.Seriousinfectionorreac-
tion can develop if proper medical treatment is not administered immediately.
ALWAYS be sure to relieve all pressure by shutting off the engine and moving the valve control handle back and forth
shoulditbecomenecessarytoloosenorremoveanyhydraulictting.
NEVERadjustthehydraulicvalve.Thepressurereliefvalveonyourlogsplitterispresetatthefactory.Onlyaqualied
service technician should perform this adjustment.