Owner manual

REARVIEWOFCONTROLPANEL
GROUND
+12-24Vdc
RED
BLACK
LIGHTBAR2-GREEN
LIGHTBAR2-YELLOW
LIGHTBAR2-BLUE
LIGHTBAR2-WHITE
LIGHTBAR1-WHITE
LIGHTBAR1-BLUE
LIGHTBAR1-YELLOW
LIGHTBAR1-GREEN
LIGHTBAR2-RED
LIGHTBAR1-RED
LIGHTBAR1
LIGHTBAR2
SPLIT ARROW LED TRAFFIC MASTER Page 4
FAILURE TO FOLLOW THE WARNINGS OR
INSTALLATION AND USER INSTRUCTIONS CAN RESULT
IN LOSS OF WARRANTY COVERAGE.
ThefollowinginstallationinstructionsprovidedirectionformountingtheTraf-
cMastertomostlightbarframes.Questionsaboutaspecicapplication
shouldbedirectedtotheTechnical Service Hotline at [phone].
PERMANENT MOUNTING
Priortomounting,considerationshouldbegiventocablelocationandlamp
replacement.Thecableshouldexittheendcaponthedriver’ssideunless
otherwisespecied.Thelampmodulereplacementprocedureisexplained
intheMaintenancesectionofthismanual.
REAR DECK AND LIGHT BAR MOUNTING
TheSplitArrowLEDTrafcMastershouldbemountedusingtheadjustable
“L” brackets which are provided.  Refer to page 5 for specic mounting
instructions.Inaddition,noteFigure2,relatingtomountingcongurations
andSTANDARDorOPTIONALwiringspecication.Seepage7,Figure5
forspecicwiring.
1. Ifalightbarisalreadymountedonthevehicle,removethelightbarfrom
thevehicleroofandturnitupsidedown.Restitonaclothorsomeother
softsurface.Itisnotnecessarytodisconnectthewiring.
2. Selectandassembletheadjustable“L”Bracketthattsyourspecic
needs.(SeeFig.1)StandardBracket-recommendedforreardeckand
lightbarmounting.HeavyDutyBracket-forusewhenTrafcMasterwill
besubjecttohighwind,vibration,and/orseverestress.
Page 7 SPLIT ARROW LED TRAFFIC MASTER
CONTROL MODULE WIRING
NOTE
DONOTUSEFUSIBLELINKS,CIRCUITBREAKERS
ORGLASSFUSES!!!
1. ChoosetheidealmountinglocationfortheControlModule.Ittsintoany
standardvehicleconsolethatisdesignedtoholdradioorotherelectronic
equipment.Italsoworkswellwhenmountedunderthevehicle’sdash.
Figure 5. Standard and Optional Wiring Schematics
“STANDARD” LED TRAFFIC MASTER WIRING
Figure 1. “L” Bracket Assembly
HeavyDutyBracket
LOCK WASHER
FLAT WASHER
NUT
BOLT
(5x15mm)
Standard Brack-