Revised 4.29.13 97011-3 OWNERS MANUAL Covers the following models: C27-XM C27-XA C27-8M C27-8A C27-10M C27-10A C44-XM C44-XA C44-9M C44-9A 5670 La Costa Canyon Ct. Las Vegas, NV. 89139 800-798-4521 Fax: 702-798-7064 contact@snaploc.com www.snaploc.
TABLE OF CONTENTS Warranty.......................................................................................................3 Operation & Maintenance.............................................................................4 Dimensions...................................................................................................6 Battery Replacement....................................................................................7 Battery Pack Assembly..........................................
WARRANTY Carts, excluding finishes, casters, wheels are warranted for (1) year from date of original purchase. Power unit components are warranted for 90 days from the date of original purchase. We will repair, without any charge, any defect due to faulty material or workmanship. These warranties do not cover failures due to abuse, misuse, improper installation, accidental damage or when repairs of modifications have been made or attempted to be made by anyone other than Snap-Loc.
OPERATION & MAINTENANCE How long do the batteries last on a single charge? It is completely dependent upon how much weight is being carried, the type of terrain, and the softness or hardness of the surface. We estimate a range from a minimum of two hours of continuous use, up to six hours of continuous use. PLEASE NOTE: Most use is not continuous, so actual use time is typically much longer.
OPERATION & MAINTENANCE Can I operate my Power Cart in the rain? Yes. Everything is splash proof sealed. However, we do not suggest driving through deep water. Will driving my Power Cart through deep water damage it? Yes. If the drive system or electronics are submerged beneath water, fatal damage is likely. How steep of a hill will my Power Cart climb? It depends on the weight carried, traction and how soft the terrain is.
DIMENSIONS LETTER DESCRIPTION DIMENSION A MAX HEIGHT 40” B1 MAX LENGTH - 27” CHASSIS 44” B MAX LENGTH - 44” CHASSIS 62” C HANDLE WIDTH 18” D HANDLE HEIGHT 38” E FRONT WHEEL BASE, DIRT HOG TIRE 24” E2 FRONT WHEEL BASE, DUAL AG TIRE 33” 2 1 27” CRATED DIMENSION, DUAL AG/DIRT HOG TIRE (L x W x H) 64” x 41” x 45” 44” CRATED DIMENSION, DUAL AG/DIRT HOG TIRE (L x W x H) 82” x 41” x 45” DESCRIPTION * WEIGHT* CART BODY WITH DIRT HOG TIRE 100 lbs CART BODY WITH DUAL AG TIRE 120 lb
BATTERY REPLACEMENT Replacement Battery Specs: 12v, 12 amp/ hr lead acid sealed, AGM type. Universal Battery model no UB12120 or equivalent. Two (2) Batteries required. B 1. Remove the batter pack from the cart. A 2. Remove the four (4) #10 screws holding the lid in place. 3. Carefully remove the batteries, and disconnect the spade terminals. RECYCLE YOUR OLD BATTERIES. 4. Reconnect the battery and circuit breaker wires to the new batteries as shown.
BATTERY PACK ASSEMBLY 8
BATTERY PACK ASSEMBLY 1 No Part No Description 1 MI-12-4068 BATTERY BOX TOP/BOTTOM WELDMENT 1 2 MI-07-0287 BATTERY BOX COVER 1 3 PI-11-0159 SM-BATTERY 12V 12 A.H.
HANDLE & CHASSIS ASSEMBLY 10
HANDLE & CHASSIS ASSEMBLY 1 No Part No 1 MI-12-4079 CART HANDLE C TWIST 1 A 2 MI-08-0836 FORMED CHANNEL 2” X 1” X 11 GA X 26 - 1/2” (27” MODEL) 4 2B MI-08-0864 FORMED CHANNEL 2” X 1” X 11 GA X 43 - 1/4” (44” MODEL) 4 3 MI-07-0290 COVER - DRIVE CONTROLLER BOX 1 4 PI-08-0053 THROTTLE CONTROL TWIST GRIP 1 5 PI-11-00271 SM - BATTERY CHARGER 24V SEAL LEAD ACID TYPE / AGM TYPE 1 6 MI-07-0238 COVER - CONTROL BOX 1 7 PI-01-0397 SCREW #6 - 32 x 3/4” 2 8 PI-01-0398 NUT - HEX #6
AXLE ASSEMBLY 12
AXLE ASSEMBLY 1 2 No Part No 1 MI-08-0844 FORMED POWER CART MOTOR MOUNT 1 2 MI-12-3568 TRANSAXLE ASSEMBLY MOUNTING BRACKET 1 3 MI-12-4066 MOTOR BRACE LEFT 1 4 MI-12-4065 MOTOR BRACE RIGHT 1 5 MI-08-0837 FORMED-CHANNEL 4-3/4" x 1-1/8" x 11 GA x 23" 1 6 MI-12-4046 LATCH BRACKET 1 7 PI-08-0048 TRANSAXLE ASSEMBLY 24 V 1 8 18080 G-PIN LOCK KIT 1 9 PI-06-0055 CASTER-SPC-10 FLAT FREE 2 10A PI-06-00972 CASTER-WHEEL-13x5.
OPTIONAL ADD ONS 10 Cu Ft Dump Hopper (70107) 8 Cu Ft Dump Hopper (70130) 9 Cu Ft Hopper (70116) Trailer Dolly Attachment (70109) 2” Ball Dirt Hog Tire 13”, 2 Ply Dual Ag Tire 13”, 2 Ply 14
DECALS Size = 5 in Wide x 3 in Tall CHARGE PORT WARNING Maximum Capacity: Ground level 750 lbs (294 kg), 3:1 Grade 500 lbs ( 226 kg). Never operate unit on a slope greater than 3:1, or with more than 750 lbs ( 294 kg). Take proper measure to insure good traction, especially on hills. For material only, not for personnel. When operating unit in reverse, DO NOT WALK BACKWARDS. Walk beside the unit, using your right hand to control the throttle. NOTICE Charge after every use.
