Instructions / Assembly

ManualsBrandsSlackers ManualsOther90 ft. Eagle Zipline Kit

B4 Adventure 4040 Holly Street Unit 10 • Denver Colorado 80216 • 303.339.0482

www.b4adventure.com

ZIPLINE KIT W/SEAT INSTRUCTIONS AND SAFETY RULES

READ CAREFULLY!

Thank you for your purchase of the Slackers™ Zipline! This product was engineered to provide

safe fun for all ages when the instructions and rules are followed. Please read and follow all

instructions carefully when installing and using your Slackers™ Zipline. All riders must read and

understand the instructions and Safety Rules before riding. Failure to read and follow the

instructions and Safety Rules could lead to serious injury or death. Please keep these instructions

available for future review and use. We are sure this product will provide you with years of fun

and enjoyment.

1. BE SAFE! - ALWAYS FOLLOW THESE SAFETY RULES

 To be setup and installed only by an Adult.

 Adult supervision is required at all times.

 Not recommended for children under 8 years of age

 Maximum weight 250lbs (113kg).

 Wear suitable shoes and close fitting clothing. No jewelry, scarves or other loose clothing.

 Do not wear a helmet as its straps may become entangled and cause serious injury

 Make sure everything is installed correctly and inspect and test the line before each use.

 If worn or damaged parts are found, contact Brand 44 for replacement parts – DO NOT

substitute with other, non-b4 parts or failure resulting in injury may result. To order parts:

303-339-0482

 Remain seated for the entire ride, wait until you have stopped COMPLETELY before letting go

of the trolley or dismounting seat.

 One rider only at a time.

 Keep people and animals at least 25ft (7.62 m) away from the zipline course when in use.

 Never use the line when it is wet or if there is rain or lightning in the area.

 Do not place fingers or hair inside of trolley or serious injury may result.

250LB

/113KG

max.

Summary of content (9 pages)

PAGE 1
ZIPLINE KIT W/SEAT INSTRUCTIONS AND SAFETY RULES READ CAREFULLY! Thank you for your purchase of the Slackers™ Zipline! This product was engineered to provide safe fun for all ages when the instructions and rules are followed. Please read and follow all instructions carefully when installing and using your Slackers™ Zipline. All riders must read and understand the instructions and Safety Rules before riding. Failure to read and follow the instructions and Safety Rules could lead to serious injury or death.
PAGE 2
Kit Contains: D A A. (1) Steel Trolley size 11in(3.36m) x 8in (2.44m) with sealed ball bearing pulleys E providing smooth operation, fitted with grips that offer a non-slip, notched finish, B providing exceptional grip and handling. B. (1) Main Cable length varies with model, 3/16in (.48cm) (galvanized steel cable, w/looped eye on one end. C C. (1) Sling Cable 5 foot (1.53m), 3/16in (.48cm) steel cable w/looped eye on F each end. D. (1) Turnbuckle 6in (15.24cm) Steel w/ 2 eye bolts & nuts. E.
PAGE 3
CABLE ATTACHMENT HEIGHT GUIDELINE WITH SEAT-Level Course General Set up: Start Point Height for Course (space between trees) Height to set 90 ft.* 80 ft. 70 ft. 60 ft. 50 ft. 40 ft. 30 ft. End Point Initial Setting 132 in. 126 in. 120 in. 114 in. 108 in. 102 in. 96 in. 84 in. *Space between trees-measure it! Do not add additional slope to the cable! It will not improve the ride and may create a danger to the rider.
PAGE 4
Assembly TIP: To keep the sling cable from sliding down the starting point tree during installation, place a small nail(not included) into the bark on the backside of the tree at the correct height per the Height Guideline. And do the same procedure at finishing/end point tree as well. Let the cable rest on top of the nail (Do not drive the nail through the cable!) during installation-Remove nail(s) when finished. Step 3: Unwind the course cable along your zipline course removing any twists.
PAGE 5
Pull the cable as tight as possible and secure with one of the three u-clamps (#1) as far from the finish point as your cable allows. With your helpers using brooms or poles at points along the cable pushing the cable up and taking the weight off of the cable, pull all of the slack out of the cable that you can by loosening and tightening the u-clamp as you pull out the slack.
PAGE 6
2. Rider Instructions 1. 2. 3. 4. 5. 6. 7. 8. 9. Only one rider at a time. Do not move in front, behind or in close proximity to a moving rider. Hold the trolley handles tightly while the Zipline is in motion. Mounting the seat While standing on launching platform, slide the seat between your legs Figure 1 then grab onto the trolley grips and launch! Rider must remain seated – no standing, kneeling or other positions. Dismounting the seat- Wait until you have come to a complete stop.
PAGE 7
 Perform the Stress Testing frequently.  Use only b4 replacement parts. WHEN FOLLOWED CORRECTLY, THESE INSTRUCTIONS WILL PROVIDE FOR LONG LASTING AND SAFE USE OF YOUR SLACKERS™ ZIPLINE. Important Product Disclaimer and Notice Activities involving the installation and use of ziplines are inherently hazardous by their nature. Poor installation, poor site selection, inadequate rider instruction, poor adult supervision or improper use can cause severe injury or death.
PAGE 8
TABLE X3.1 Fall Height In Feet From Which a Life Threatening Injury Would Not Be Expected Type of Material(in deep) 6”(15.3cm) 9” (22.9cm) 12” (30.5cm) Double Shredded Bark Mulch 6’(1.83m) 10’(3.05m) 11’(3.35m) Wood Chips 6’(1.83m) 7’(2.13m) 12’(3.66m) Fine Sand 5’(1.52m) 6’(1.83m) 9’(2.74m) Fine Gravel 6’(1.83m) 7’(2.13m) 10’(3.05m) materials if they are installed and maintained at depths of 6, 9 and 12 inches(15.3, 22.9 and 30.
PAGE 9
Brand 44 • 4040 Holly Street #10 • Denver Colorado 80216 • 303.339.0482 Website: www.slackersline.com email: info@brand44co.