Service Manual Instruction Manual

Stabil-TRAK™ System and Boom Interlock System
10-18
6036, 6042, 8042, 10042, 10054
10.9 STABIL-TRAK™ BOOM INTERLOCK ELECTRICAL CIRCUIT OPERATION AND
TROUBLESHOOTING (10054)
Note: Before using the 10054 Stabil-TRAK System
Troubleshooting chart and diagrams, complete Section
10.7.2, “Stabil-TRAK™ System Test Procedures,” and
Section 10.10, “Boom/Outrigger Interlock System Test,”,
to determine what part of the system is not functioning
properly.
10054 Stabil-TRAK™ System Troubleshooting
BOOM EXTEND MODE 1 BOOM EXTEND MODE 2 BOOM EXTEND MODE 3
Refer to the mode Section
, “10054 Stabil-TRAK™
Electrical Circuit Boom
Extend Mode 1.”
Refer to the mode Section
, “10054 Stabil-TRAK™
Electrical Circuit Boom
Extend Mode 2.”
Refer to the mode Section , “10054
Stabil-TRAK™ Electrical Circuit
Boom Extend Mode 3.”
Machine
Conditions
Switch/
Relay
Solenoid
Ignition On
Boom Below 40°
Boom Retracted
PB Released
Trans. Fwd. or Rev.
Outriggers Raised
Ignition On
Boom Below 40°
Boom Extended To
42 Series Extension Limit
PB Released
Trans. Fwd. or Rev.
Outriggers Raised
Ignition On
Boom Below 40°
Boom Extended Beyond
42 Series Extension Limit
PB Applied By Interlock Sys.
Trans. In Neutral By Interlock Sys.
Outriggers Lowered
Solenoid 12A
Stabil-TRAK Components Affected By
Boom Interlock System
EE DE
Solenoid 12B E E DE
Solenoid 3 DE DE E
Solenoid 4A DE DE DE
Solenoid 4B DE DE DE
Boom Angle Sensor C C O
Boom Switch Relay E E DE
Stabilizer Lock Relay DE DE E
Stabilizer Light OFF (DE) OFF (DE) ON (E)
Ignition Switch C C C
Park Brake Switch O O O
Park Brake Light OFF (DE) OFF (DE) ON (E)
BOOM EXTEND INTERLOCK SYSTEM TROUBLESHOOTING
Boom Extend Interlock Sensor C O O
Boom Extend Interlock Relay E DE DE
Boom Extend Lockout Relay E DE DE
Outrigger Pressure Switches O O C
Left Outrigger Lockout Relay DE E E
Right Outrigger Lockout Relay DE E E
Stabilizer Interlock Relay DE DE E
Stabilizer Lock-Up Relay DE DE E
Extend Circuit Solenoid Valve E E E
Secondary Function Manifold
Park Brake Solenoids
EE DE
Park Brake Interlock Relay DE DE E
Park Brake Disengage Relay E E DE