Magnum Energy Integration Guide

REV1128
18
SimpliPhi Power, Inc. | 3100 Camino Del Sol | Oxnard, CA 93030, USA | [phone] | [e-mail] | SimpliPhiPower.com
| 7 |
4.0 – Program Settings for PHI Batteries
In order to maintain the Warranty, it is critical to ensure that the appropriate settings for the desired
Warranty are programmed in all of the system components. This section will cover the basic concepts and
settings for Magnum Energy equipment.
4.1 – Depth of Discharge
In order to optimize performance and the life of your system and PHI batteries, SimpliPhi Power
recommends programming the equipment settings for 80% Depth of Discharge (DoD). This qualifies for
the SimpliPhi 10-year / 10,000 cycle Warranty on the batteries. Greater DoD is possible but will result in
reduced cycle life. In real-world installation, best practices recommend you use a standby generator or a
grid connection to maintain 80% DoD. Refer to the PHI 3.5 kWh Battery Warranty to compare DoD
settings and the associated Warranty.
CAUTION: If a firmware update is executed on Magnum Energy equipment, ALL the settings must
be reverified. The programmed settings shown in the following tables must be applied based on
desired Warranty/cycle life. The recommended is 80% depth of discharge.
4.2 – Inverter Settings
Table 1.0 – Program Settings for SimpliPhi PHI 3.5 – 24V/48V Battery w/ Magnum General Settings
General
10k Cycles
(80% DOD)
5k Cycles
(90% DOD)
3.5k Cycles
(100% DOD)
MS4024 / MS4448 4kW Inverter
ME-ARC
Remote Control
SHORE
Shore Max (A) 5 - 60
AGS (if used)
01 AGS Control - AGS
OFF, Enable Test, Enable w/QT
05 Start Volts (V) - Start VDC (V)
25.3 / 50.6
METER
05 BM: Setup - BM Charge Eff
Auto
BM Amp Hours
1
(Ah)
[200-2500]
138Ah per PHI3.5 24V
(3 minimum = 414Ah)
69Ah per PHI3.5 48V
(3 minimum = 207Ah)
SETUP
02 Low Batt CutOut
2
- LBCO (V)
25.1 / 50.2
24.8 / 49.6
24 / 48
03 Absorb Time - Absorb Hrs (Hrs) 0.1
04 Battery Type - BatType
CC/CV
Max Amps
1
(A)
45A per PHI3.5 24V
34A per PHI3.5 48V
Chg Volts (V) 28 / 56 28 / 56 28 / 56
EndChg
DC Amps
DoneAmps (A)
4 / 2
MaxTime (Hrs)
OFF
Recharge (V) 25.3 / 50.6
05 Charge Rate - Max Charge
3
(%)
50