MSDS
Page 3 of 5 Revision A October 1, 2016
Materials listed on this data sheet are contained in varying percentages in this product. Exact percentages are proprietary
and will not be disclosed other than as required in accordance with the regulations. If a lamp is broken, some of the
following materials may be released:
Chemical Name
CAS Number
% by wt.
Quartz, fused
60676-86-0
0-30
(1, 2) Mercury
7439-97-6
<0.1
Aluminum Oxide
1344-28-1
0-<0.03
Thallium Iodide
7790-30-9
<0.002
Glass (Borosilicate)
---
50-86
Barium Peroxide
1304-29-6
0-<0.6
Yttrium Vanadate
13566-12-6
0-<0.5
(1) These chemicals are subject to the reporting requirements of section 313 of Title III of the Superfund Amendments
and Reauthorization Act of 1986 and 40 CFR Part 372.
(2) The mercury in this product is a substance known to the state of California to cause reproductive toxicity if ingested.
[California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65).]
NIOSH/OSHA Occupational Health Guidelines for Chemical Hazards and/or NIOSH Pocket Guide to Chemical
Hazards lists the following effects of overexposure to the chemicals/materials tabulated below when they are
inhaled, ingested, or contacted with skin or eye:
Glass - Glass dust is considered to be physiologically inert and as such has an OSHA exposure limit of 15 mg/M3
for total dust and 5 mg/M3 for respirable dust. The ACGIH TLVs for particulates not otherwise classified are 10
mg/M3 for total dust and 3 mg/M3 for respirable dust.
Quartz, Fused - Fibrosis of the lungs causing shortness of breath and coughing has been associated with silica
exposure.
Mercury - Exposure to high concentrations of vapors for brief periods can cause acute symptoms such as
pneumonitis, chest pains, shortness of breath, coughing, gingivitis, salivation and possibly stomatitis. May cause
redness and irritation as a result of contact with skin and/or eyes.
Barium Peroide – May be fatal if swallowed. Harmful dust. Avoid skin and eye contact.
Yttrium Vanadate – Inhalation of vanadium compounds can cause irritation of the nose, throat and respiratory tract.
Eye contact and prolonged, repeated skin contact may also cause irritation. Studies of workers exposed to this
material showed no evidence of chronic or systemic effects.
Aluminum Oxide (Alumina) - Alumina is a non-toxic material which is very low in free silica content. Sharp edged
particles can irritate the eyes, perhaps the skin, and definitely the mucous membranes of the respiratory tract.
All other components of this product do not pose a significant risk of respiratory and/or physical effects.
---------------------------------------------------------------------------------------------------------------------------------------------------
IV. EMERGENCY AND FIRST AID PROCEDURES:
---------------------------------------------------------------------------------------------------------------------------------------------------
Glass Cuts: Perform normal first aid procedures. Seek medical attention as required.
Inhalation: If discomfort or irritation to the nose and throat develop, remove from exposure and seek medical
attention as needed. If breathing has stopped, perform artificial respiration; keep affected person warm and at
rest; get medical attention as soon as possible.
Ingestion: In the unlikely event of ingesting a large quantity of material, seek medical attention immediately.
Contact, Skin: Thoroughly wash affected area with mild soap or detergent and water and prevent further contact.
Seek medical attention as needed.