User Manual
Table Of Contents
- PRECAUTIONS TO BE OBSERVED BEFORE AND DURING SERVICING TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY
- WARNING TO SERVICE PERSONNEL
- MICROWAVE MEASUREMENT PROCEDURE
- FOREWORD AND WARNING
- PRODUCT DESCRIPTION
- GENERAL INFORMATION
- OPERATION
- TROUBLESHOOTING GUIDE
- TEST PROCEDURES
- [1] Procedure A: MAGNETRON ASSEMBLY TEST
- [2] Procedure B: POWER TRANSFORMER TEST
- [3] Procedure C: HIGH VOLTAGE RECTIFIER TEST
- [4] Procedure D: HIGH VOLTAGE CAPACITOR TEST
- [5] Procedure E: THERMAL CUT OUT TEST
- [6] Procedure F: SECONDARY INTERLOCK SWITCH TEST
- [7] Procedure F: PRIMARY INTERLOCK SYSTEM TEST
- [8] Procedure G: MONITOR SWITCH TEST
- [9] Procedure H: BLOWN MINITOR FUSE TEST
- [10] Procedure I: NOISE FILTER TEST
- [11] Procedure J: CONTROL PANEL ASSEMBLY TEST
- [12] Procedure L: RELAY TEST
- [13] Procedure M: FOIL PATTERN ON THE PRINTED WIRING BOARD TEST
- TOUCH CONTROL PANEL ASSEMBLY
- PRECAUTIONS FOR USING LEAD-FREE SOLDER
- COMPONENT REPLACEMENT AND ADJUSTMENT PROCEDURE
- [1] WARNING
- [2] OUTER CASE REMOVAL
- [3] POWER TRANSFORMER REMOVAL
- [4] HIGH VOLTAGE RECTIFIER ASSEMBLY AND HIGH VOLTAGE CAPACITOR REMOVAL
- [5] MAGNETRON REMOVAL
- [6] CONTROL PANEL ASSEMBLY REMOVAL
- [7] OVEN LAMP AND LAMP SOCKET REMOVAL
- [8] POSITIVE LOCK CONNECTOR (NO-CASE TYPE) REMOVAL
- [9] ANTENNA MOTOR REMOVAL
- [10] COOLING FAN MOTOR REMOVAL
- [11] POWER SUPPLY CORD REPLACEMENT
- [12] DOOR SENSING SWITCH/SECONDARY INTERLOCK SWITCH AND MONITOR SWITCH REMOVAL
- [13] DOOR SENSING SWITCH/SECONDARY INTERLOCK SWITCH AND MONITOR SWITCH ADJUSTMENT
- [14] DOOR PARTS REMOVAL
- [15] ANTENNA MOTOR SHAFT REPLACEMENT
- [16] INSTALLATION OF CERAMIC SHELF
- CIRCUIT DIAGRAMS
- Parts List
R21LCF
5 – 1
R21LCF
Service Manual
CHAPTER 5. GENERAL INFORMATION
[1] GROUNDING INSTRUCTIONS
This oven is equipped with a three prong grounding plug. It must be plugged into a wall receptacle that is properly installed and grounded in accor-
dance with the National Electrical Code and local codes and ordinances.
In the event of an electrical short circuit, grounding reduces the risk of electric shock by providing an escape wire for the electric current.
WARNING: Improper use of the grounding plug can result in a risk of electric shock.
Electrical Requirements
The electrical requirements are a 120 volt 60 Hz, AC only, 15 amp. or more protected electrical
supply. It is recommended that a separate circuit serving only this appliance be provided. When
installing this appliance, observe all applicable codes and ordinances. A short power-supply cord is
provided to reduce risks of becoming entangled in or tripping over a longer cord. Where a two-
pronged wall-receptacle is encountered, it is the personal responsibility and obligation of the cus-
tomer to contact a qualified electrician and have it replaced with a properly grounded three-
pronged wall receptacle or have a grounding adapter properly grounded and polarized. If the
extension cord must be used, it should be a 3-wire, 15 amp. or higher rated cord. Do not drape
over a countertop or table where it can be pulled on by children or tripped over accidentally.
CAUTION: DO NOT UNDER ANY CIRCUMSTANCES CUT OR REMOVE THE ROUND
GROUNDING PRONG FROM THIS PLUG.
[2] OVEN DIAGRAM
1. OVEN
1. Back splash cover
2. Side splash cover
3. Oven light
4. Ceramic shelf
5. Control panel
6. Cavity face plate
7. Door latch openings
8. Door latches
9. Door hinges
10.Door seals and sealing surfaces
11. Door handle
12.Oven door with see-through window
13.Air ventilation cover and openings
14.Power supply cord
15.Air intake openings
16.Outer case cabinet
2. TOUCH CONTROL PANEL
3-Pronged
Plug
Grounded
Receptacle Box
Grounding Pin
3-Pronged Receptacle
1
14
13
912
11
76
5
15
16
10
3 2
4
8
TIME GUIDE FOR ONE SERVING
15 - 30 sec.
Bagel, Roll
Muffin, Pastry
Pie Slice
30 - 60 sec.
Hot Dog
Pizza Slice
Small Sandwich
1-2min.
Beverage, Soup
Large Sandwich
Popcorn, 1.5 oz.
2-3min.
Casserole, Stew
Chili, Chowder
Popcorn, 3.5 oz.
With the door closed,turn the timer to
the desired time. Oven will begin
operating immediately.
To shut oven off manually,return timer
to "0".
INSTRUCTIONS
0
10
20
30
40
50
1
1.5
2
2.5
3
4
5
6
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
Light Up Dial for
setting cooking time.