Installation manual

- 5 - Ford Racing Technical Support (800)FORD-788
M-12071-A50
REVISION 2
6.0 HARNESS WIRE COLORS AND CONNECTOR LOCATIONS
BK = Black GY = Gray PK = Pink W = White
BR = Brown LB = Light Blue P = Purple Y = Yellow
DB = Dark Blue LG = Light Green R = Red
DG = Dark Green O = Orange T = Tan
Connector
# Connects to Wire Colors
1................................ Fuel Injector #1……………………………….. R, T
2……………………… Fuel Injector #2……………………………….. R, W
3……………………… Fuel Injector #3……………………………….. R, BR/Y
4……………………… Fuel Injector #4……………………………….. R, BR/LB
5……………………… Fuel Injector #5……………………………….. R, T/BK
6……………………… Fuel Injector #6……………………………….. R, LG/O
7……………………… Fuel Injector #7……………………………….. R, T/R
8……………………… Fuel Injector #8……………………………….. R, LB
9……………………… Throttle Position Sensor (TPS)……………… BR/W, GY/R, GY/W
10……………………. Idle Air Control (IAC) Solenoid……………….R, W/LB
11……………………. Engine Coolant Temp (ECT) Sensor………. GY/ R, LG/R
12……………………. Mass Air Flow (MAF) Meter…………………. R, BK, T/LB, LB/R
13……………………. Air Charge Temp (ACT) Sensor……………. GY/R, GY
14……………………. SPOUT Connector……………………………. R, PK
15……………………. Thick Film Ignition (TFI) Module…………….. O/R, T/Y, R/LG,
R/LB, PK, GY/O
16……………………. Coil…………………………………………….. R/LG, T/Y
17……………………. System Ground (DIRECTLY to battery!!)….. Black
18……………………. 12V SUPPLY (USE AN INLINE FUSE!!)….. Red
19……………………. A/C Clutch Connector……………………….. BK/Y, BK/W
20……………………. Barometric Pressure (BAP) Sensor………… BR/W, GY/R, LG/BK
21……………………. Left Oxygen (O2) Sensor……………………. GY/Y, BK/W, R/BK
22……………………. Right Oxygen (O2) Sensor………………….. GY/Y, BK/W, GY/LB
23……………………. Inertia Switch Connector……………………. PK, PK/BK
24……………………. Self Test Connector…………………………. PK/LG, LB/O, GY/R, W/P
25……………………. 15-Pin Disconnect……………………………. PK/LG, R/LB, BK, T/Y
PK, DG/Y, P, R/LG
26……………………. Fuse Relay Control Module (FRCM)………. ----------------------------------
27……………………. 60-Pin Connector, PCM……………………... ----------------------------------
28.............................. EGR Vacuum Regulator (EVR)..................... R, BR/PK
29.............................. EGR Position Sensor (EGR)......................... BR/W, GY/R, BR/LG
30.............................. Electric Fan Lead (See Page 13).................. O