Unit installation

035-000040-001 Page 17 of 18 DVA IOM 1.3 08-18-2014
AIR HANDLERS AND FAN
COILS
t ĂƌƌĂŶƚLJZĞŐŝƐƚƌĂƟŽŶĂŶĚ^ƚĂƌƚ-up Report
Warranty Registration Form: Complete
and submit this form within ten (10) days of
start-up to comply with the terms of the
Magic Aire warranty. Form must be com-
pleted to clearly indicate startup for each
unit being registered.
Mail Form(s) to Magic Aire
Warranty Department
501 Galveston St.
Wichita Falls, TX, 76301 or
Email [e-mail]
STARTUP REPORT
Group Checklist Item Yes No
Electrical/Operational
Does electrical service correspond to unit nameplate?
-Nameplate Supply Voltage/Phase
Voltage:
Phase:
-Nameplate Rated FLA motor current (Amps).
Actual Motor Current:
Does all field wiring conform to unit wiring diagram?
Is field-provided freeze protection present? (for DX and hydronic coils)
Is fan wheel turning the correct direction?
Are mixing box dampers operating properly?
Is the filter clean?
Structural
Is unit properly supported?
Is unit installed level (necessary for proper condensate drainage)?
Is properly sized condensate trap present?
Is the condensate disposal system operating correctly?
Is auxiliary external condensate drain pan installed as recommended
by the installation manual? (not required for valid warranty)
DX Systems
Is expansion valve bulb properly installed and insulated?
Is equalizer line connected to the suction line Schrader valve (or to
suction line if field-provided TXV)?
Has the DX system been charged with refrigerant according to the
condensing unit manufacturer’s instructions?
Piping Check
Is unit piping correct and insulated to prevent condensation?
Are the control valve packages piped correctly?
Are Valve packages properly insulated?
Are there any leaks detected?
-in the interior of the unit?
-at unit piping connections?
-at valve packages or other piping modified in the installation?
Job Name City
Sales Order # Unit Tag
Model Number Serial Number
Installer Quantity of Units