Quesitons? Comments? call SENCO's toll-free Action-line: 1-800-543-4596 or e-mail: toolprof@senco.com PC2017 Gasoline Air Compressor OPERATING INSTRUCTIONS Document #MTM011 Revised Date: 062104 (Replaces 07/10/03) © 2004 by SENCO Products, Inc. Warnings for the safe use of this air compressor are included in this manual.
TABLE OF CONTENTS INTRODUCTION ................................................................................................................ 3 SAFETY ALERT ................................................................................................................ 3 INSPECTION...................................................................................................................... 3 SAFETY WARNINGS ..........................................................................................
INTRODUCTION Congratulations on the purchase of your new Senco® Air Compressor! You can be assured your Senco® Air Compressor was constructed with the highest level of precision and accuracy. Each component has been rigorously tested by technicians to ensure the quality, endurance and performance of this air compressor. This operator's manual was compiled for your benefit.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF EXPLOSION OR FIRE POTENTIAL CONSEQUENCE Serious injury or death may occur from normal sparks in the engine ignition system or engine exhaust/ muffler. PREVENTION Always operate air compressor in a well ventilated area free of flammable vapors, combustible dust, gases or other combustible materials. If spraying flammable material, locate the air compressor at least 20 feet away from the spray area.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF BURSTING POTENTIAL CONSEQUENCE Serious injury or death may occur from an air tank explosion if air tanks are not properly maintained. PREVENTION Drain air tank daily or after each use to prevent moisture buildup in the air tank. If air tank develops a leak, replace the air tank immediately. Never repair, weld or make modifications to the air tank or its attachments.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD RISK OF BURNS RISK OF FLYING OBJECTS POTENTIAL CONSEQUENCE Serious injury could occur from touching exposed metal parts. These areas can remain hot for some time after the air compressor is shutdown. Soft tissue damage can occur from the compressed air stream. PREVENTION Never allow any part of your body or other materials to make contact with any exposed metal parts on the air compressor.
SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR HAZARD PREVENTION POTENTIAL CONSEQUENCE RISK FROM NEGLIGENCE Risk of injury from negligent use. Never allow children or adolescents to operate this air compressor! Stay alert-watch what you are doing. Do not operate the air compressor when fatigued or under the influence of alcohol or drugs. Know how to stop the air compressor. Be thoroughly familiar with controls. RISK OF AIR COMPRESSOR DAMAGE Risk of major repair.
PDAC046-062304-DLG PC2017 GASOLINE AIR COMPRESSOR FEATURES 8 Senco® Gasoline Air Compressor Manual 2004
PC2017 FEATURES REVIEW AIR INTAKE FILTER: This filter is designed to clean air coming into the pump. To ensure the pump continually receives a clean, cool, dry air supply this filter must always be clean and ventilation opening free from obstructions. Replace filter when necessary. AIR COMPRESSOR PUMP: To compress air, the pistons move up and down in the cylinders. On the downstroke, air is drawn in through the air intake valves while the exhaust valves remain closed.
PREPARATION INITIAL SET-UP: 1. Read safety warnings before setting-up air compressor. 2. Ensure the oil level is above the minimum notch and below the maximum notch on the dipstick. If low, add Senco® part number PC0344 compressor pump oil. LOCATION: CAUTION In order to avoid damaging the air compressor, do not incline the air compressor transversely or longitudinally more than 10°. 1. Place air compressor at least 12 inches away from obstacles that may prevent proper ventilation.
OPERATION PRE-START CHECKLIST: 1. Check oil level. Add if necessary. 2. Remove any moisture in the air compressor air tank. Remove excessive pressure with an air tool, then open the air tank drain valve in the bottom of the air tank. Close tightly when drained. WARNING Risk of bodily injury. NEVER attempt to open the drain valve when more than 10 PSI of air pressure is in the air tank! 3. Make sure the engine switch is in the "OFF" position. 4. Make sure all safety valves are working correctly. 5.
TROUBLESHOOTING 1. Engine will not start. PROBABLE CAUSE Various engine problems. 2. Noisy operation. SYMPTOM REMEDY Refer to engine manual accompanying your air compressor. SYMPTOM PROBABLE CAUSE Loose engine pulley or pump flywheel. REMEDY Tighten pulley and or flywheel. Lack of oil in the pump. Add correct amount of oil. Check for bearing damage. Carbon deposits on pistons or valves. Bearing, piston or connecting rod failure. 3. Air leaks from safety relief valve.
TROUBLESHOOTING SYMPTOM 8. Insufficient pressure at air tool or accessory. PROBABLE CAUSE Pressure regulator knob not turned to high enough pressure or defective pressure regulator. REMEDY Adjust pressure regulator knob to proper setting or replace. Restricted air intake filter. Clean or replace. Air leaks. Check for leaks and repair. Hose or hose connections are too small or long. Replace with larger hose or connectors. Slipping belt. Tighten or replace.
Notes 14 Senco® Gasoline Air Compressor Manual 2004
Specifications Model # PC2017 Engine Oil Type SAE 10W 30 Oil Capacity 20 oz. Low Oil Protection Oil Alert Fuel Type Unleaded Gasoline 86 Octane Minimum Fuel Capacity .95 Gallon Maximum No Load RPM 3200 Number of Cylinders 2 Compression Stages 1 Bore/Stroke 2.5" x 1.88" RPM 1380 Flywheel 10" Lubrication Splash Oil Quantity 17.3 oz.
SENCO COMPRESSOR AND PARTS WARRANTY This compressor has been designed and constructed using the highest standards of material and workmanship. COMPRESSOR WARRANTY: The length of this guarantee is one year (two years on the pump) from date of purchase by the original retail purchaser. During this period, Senco Products, Inc., will repair or replace at Senco's option, any original part or parts for the original retail purchaser.
