User Manual

9 Transporting and Storing Your Vehicle
Transporting
When you need to transport your Segway Dirt eBike, it is recommended to use soft ratchet straps to secure your vehicle.
Use two ratchet straps in the front and two in the rear. Place the straps around a frame contact point. Check that the straps
do not contact any control cables or electrical wirings. Tighten the straps until the front suspension is compressed about
half-way. Too much pressure could damage the fork seals. Follow the manufacturer's instructions of the ratchet straps you
use. Avoid using a rope, which can loosen and cause the motorcycle to fall over.
If you use a motorcycle trailer or truck to transport your Segway Dirt eBike, be sure to secure it in an upright position.
I. Maintenance Guideline
WARNING
Do not dispose of this product in a landfill, by incineration, or by mixing with household trash. Serious
danger/ injury can occur because of the electrical components and the battery. Refer to the local laws
and regulations regarding recycling and/or disposal.
The first inspection (or first maintenance) should be done in the range of 6.2– 18.6 miles (10–30 km) in
mild, off-road conditions. In the case of high off-road intensity, it is recommended to conduct the first
inspection in the range of 1.2– 6.2 miles (2–10 km).
Inspection items
● Spokes - Tightness of the spokes of the front and rear wheels
● Handlebar (headset) - Clearance of the headset at the handlebar
● Chain - Tightness of the chain
● Belt - Tightness of the belt (the belt of a new vehicle may produce some friction sounds, which can be
eliminated by applying wax on both sides of the belt or ignored)
● Shock absorber and oil - Adjustment of the shock absorber and a check for oil leakage and proper
installation of the compression spring and rebound damping device (Note: don't turn the adjustment
knob to the very right or left end.)
● Handlebar (screws) - Tightness of all handlebar screws
Maintenance schedule
Note: The vehicle must not be powered “on” in the maintenance process.
● Before each ride: chain cleaning and lubrication
● Once every six months: front shock absorber maintenance, brake oil replacement, and rear shock
absorber maintenance
● Belt replacement: once every 4971 miles (8,000 km) for clean and flat road and 2485 miles (4,000 km)
for off-road conditions; cleaning will not be effective in the case of abnormal sounds
● Chain replacement: once every 4971 miles (8,000 km)
Storing
Make sure your Segway Dirt eBike is all clean and dry to prevent rusting. Store in a dry and well-ventilated place. If you are
not going to use the vehicle for more than a month, please make sure the main switch is turned off and disconnect the
battery plugs. Also make sure to fully charge the battery to protect the battery life.
3029
10 Maintenance