Index: Page Product 2 Safety Procedures 2 Mounting Location 3 Tools 3 Installation 4 Lamp Replacement/Disposal And Parts List 5 Troubleshooting Warranty 6 6&7 All Noble Air Purifiers are designed to address Heating and Air Conditioning air handling units. Noble air purifiers use ultraviolet germicidal light at a frequency of 254 nanometers to disinfect biological growth in return or supply air stream .
1. 2. 3. 4. • • • • • Install the lamp where you have easy access. Make sure before drilling into equipment that there is nothing in the way that would be damaged. The lamp should be installed a minimum of 2-3 inches, maximum 36 inches away from the coil or pan surface. When looking for a mounting location, try to install the unit away from non UV resistant plastics, rubber, and other non metallic materials. Shield these components using sheet metal, aluminum tape, or metal conduit.
• • • 1. 2. 3. 4. 6. CAUTION: Ultraviolet light can be harmful to your sight, do not look at the lamp when it is illuminated. Black Wire 9. • White Wire 8. Protect all non-UV resistant materials from direct UV exposure with aluminum tape or metal conduit. Green Wire 7. For metal ductwork use the Noble Air unit (after the cover has been removed) as a template mark for the lamp, sight glass and securing holes at the desired installation location. Remove the unit.
1. Place the supplied mounting template on the duct board at the desired location. Use duct tape to secure the template to the duct board. (Fig. A) 2. Bend holding tabs towards you. (Fig. B) 3. Use a utility knife to cut a rectangular hole in the duct board and remove the rectangular piece that has been cut. (Fig. C & Fig. D) 4. Bend holding tabs into duct work to secure the mounting template. (Fig. E & Fig. F) 5.
The Noble Air Ultraviolet Germicidal Lamp is designed for 9000-11,000 hours of continuous operation. After 9000 hours intensity of the lamp inside the duct diminishes and should be replaced. Even if the lamp is still illuminated, replacement of the lamp is recommended by a qualified HVAC Service Technician. • 1. 2. 3. 4. 5. 6. The installation should be done by a qualified HVAC contractor. Disconnect electrical service Remove Noble Air cover. Disconnect the lamp connector from the lamp base.
If the unit does not work, check the following: Electrical Supply/Wiring—Verify that the electrical Lamp—Verify that the lamp is not broken and is properly seated in the lamp connector. To check this, follow service is operating correctly. steps in the ’Lamp Replacement’ section with one exBallast—If lamp still is not illuminating, check the ception : you should not remove and replace the lamp. wiring to the ballast.
WARRANTY LIMITATIONS This warranty will be voided if the covered equipment (only Noble Air replacement parts or units are warranteed) is removed from the original installation site. This warranty does not cover damage or defect resulting from: 1 2 Accident, neglect or unreasonable use or operation of the equipment, including operation of electrical equipment at voltages other than the range specified on the unit name plate.
Since the first ultraviolet irradiation system was used successfully in 1909, ultraviolet irradiation has had a 94 year performance history. Noble Air uses the ultraviolet wavelength at 253.7nm, ultraviolet radiation lethal to microorganisms. Noble air purifiers can reduce mold, bacterial, or viral airborne microbes in all areas of a H e a t i n g V e n t i l a t i o n a n d A i r The Noble Air Purifier is the perfect choice for small or large applications . Noble Air uses Conditioning system (HVAC).
Noble Air Purification 6009 and 6018 units are mounted in the return or supply to accommodate most HVAC systems. The units install anywhere in the system to disinfect molds, bacteria and viruses. The housing is steel and comes in 2 sizes (9” and 18” lamps). All units are manufacturer assembled and tested. Models 6009 and 6018: The power source is a electronic, Class P, Sound rated A, Type HL, NO PCB’s, type 1 outdoor ballast meeting EMI requirements of CFR Title 47 Part 18 consumer.
