Operation Manual

Instruction Manual Electrobloc EBL 101 C
14
Date: 30.09.2008 811.553 BA / EN
Frost protection valve output max. 0.1 A
D+ point max 1 A
Characteristic charging curve IUoU
Final charging voltage 14.3 V
Charge current 18 A in the entire mains voltage range,
electronically limited, minus the
charge current into the vehicle battery
Voltage for float charge 13.8 V with automatic switchover
New charge cycle, with battery voltage below 13.8 V
Switchover to main charging with a few seconds delay
Main c harge
I
Full charge
Uo
Float charge
U
1 h wi th lead ac id
8 h wi th lead gel
Time
14,3
13,8
Solar
charging
V
Fig. 3 Example of the charging voltage curve on the EBL 101 C Electrobloc
I Main charge with maximum 18 A charging current, electronically limi-
ted, up to final charging voltage. Start of charge also for totally dischar-
ged batteries.
Uo Automatic changeover to full charge with constant 14.3 V. The duration
of the fully charge phase depends on the type of battery and can be
adjusted at the device:
U Automatic changeover to trickle charge with constant 13.8 V. In the
trickle charge phase, the voltage at the output of the charging module
is constant.
Start of a new charging cycle by switching over to main charge, if the battery
voltage falls below 13.8 V for more than 5 seconds when loaded. Start of
charge also for totally discharged batteries. The internal charge module can
also be operated without living area battery.
For mains operation, the starter battery is also charged (with maximum
charge current of 6 A).
Maximum permitted charge current 14 A, protected with 15 A;
Depending on the solar charge regulator used, either only the living area
battery is charged or the living area battery and the starter battery.
Simultaneous loading of living area battery by alternator
Batteries connected in parallel via a cut-off relay
Switch-off voltage: dynamic,
controlled by control and switch panel
Minimum battery voltage for approx. 11.0 V
Switch-on via the
12 V main switch on the
control and switch panel:
Battery charging, living
area battery with mains
connection
Battery charging, starter
battery with mains
connection
Battery charging via
solar charge regulator
Battery charging
during mobile operation
Battery monitor