Specifications

4. Clean the area where the glass and gasket are to be installed.

5. Install the new flat self-adhesive gasket on the edge of the inside surface of the outer door

frame around the opening and cut off surplus gasket to make a tight joint.

(The side with the adhesive adhere the gasket to the inside of the outer door frame).

6. Carefully place the glass on the outer door frame and install the inner door frame using the

screws previously removed. Hold the parts together and install the screws only two turns.

Install the flat part of the P-gasket oriented so it will fit between the outer door frame and the

inner door frame. (When installing the P-gasket cord, use your fingers or a screwdriver to push

the flat part of the gasket under the inner door frame. Make sure the gasket is not pushed in so

far that the round part will not seal against the door opening of the stove.)

Gradually and evenly tighten the inner door frame screws in an alternating pattern around the

frame (enough to be sure the door gasket stays in place), then fully tighten the screws.

7. Carefully turn around the door and install the tube gasket between the glass and the outer

door frame with your fingers.

8. Install the door on to the fireplace again in reverse order of disassembly (see under 1).

Make sure to maintain the same distance between the door edges and the insert on both sides

and that the door and the latch work properly.

6.6 Replacement part list:

Caution: Use only original SCAN DSA 4 replacement parts. Do not use substitute materials.

Description Part Number

Glass Panel 223885

Gasket, Tadpole – 5.75 ft. Door Seal 223948

Gasket, .25 in. Rnd - 5 ft. / Interior Glass seal 129644

Gasket, Flat – 5 ft. / Exterior Glass seal K5521200007

Door Latch Pawl 222805

Pin, Smoke Baffle Supports 223049

Upper Smoke Baffle w Edge Guard 157098

Lower Smoke Baffle 223888

Smoke Baffle Set, w/ support pins 157054

Side Panel, Skamol 223887

Rear Panel, Skamol 223889

Combustion Panel Set, Sides & Rear 157052

Bottom Fire Brick, L & R 223891

Bottom Fire Brick, Center 223890

Firebrick Set, Complete 157053

Primary Air Valve Kit, Black 157092

Primary Air Valve Kit, Gray 1157093

Replacement Door, Black 157046

Surround Clip & Leg Levelers

157071