REFRIGERATOR BOTTOM MOUNT FREEZER BASIC : RF195AB/RF197AB/ RF217AB MODEL NAME : RF195ABRS RF195ABWP RF197ABRS RF197ABWP RF217ABRS RF217ABWP REFRIGERATOR RF195ABBP RF195ABPN RF197ABBP RF197ABPN RF217ABBP RF217ABPN CONTENTS 1. PRECAUTIONS(SAFETY WARNINGS) 2. PRODUCT SPECIFICATIONS 3. DISASSEMBLY AND REASSEMBLY 4. TROUBLESHOOTING 5. EXPLODED VIEW & PARTS LIST 6. PCB DIAGRAM 7. WIRING DIAGRAM 8.
WARNING IMPORTANT SAFETY NOTICE The service guide is for service men with adequate backgrounds of electrical, electronic, and mechanical experience. Any attempt to repair a major appliance may result in personal injury and property damage. The manufacturer or dealer cannot be responsible for the interpretation of this information. SAMSUNG ELECTRONICS AMERICA, INC. Technical Service Guide Copyright ⓒ2009 All rights reserved.
Contents 1. PRECAUTIONS(SAFETY WARNINGS) ······························4 2.
1. PRECAUTIONS(SAFETY WARNINGS) ● Due to the risk of electric shock, be sure to unplug the unit before servicing. ● Use the right electronic equipment for your new Refrigerator. Make sure to check out the right model name, rated voltage and current, operating temperature, etc. ● Upon repair, make sure that harnesses are not to be water-penetrated and are bundled tight. Should not be detached by a certain amount of external force.
PRECAUTIONS(SAFETY WARNINGS) Read all instructions before repairing the product and keep to the instructions in order to prevent danger or property damage. CAUTION/WARNING SYMBOLS DISPLAYED SYMBOLS means Prohibition”. Warning Caution Indicates that a danger of death or serious injury exists. means Do not disassemble”. means No contact”. means The things to be followed”. means Power cord should be unplugged from the consent” Indicates that a risk of personal injury or material damage exists.
PRECAUTIONS(SAFETY WARNINGS) ❈ Please ler users know following warnings & cautions in detail. Warning & Caution Do not allow users to put bottles or kinds of glass in the freezer. Do not allow users to store narrow and lengthy bottles or foods in a small multipurpose room. Do not allow users to store pharmaceutical products, scientific materials, etc., in the refrigerator. ● Freezing of the contents may inflict a wound.
2. PRODUCT SPECIFICATIONS 2-1) Introduction of Main Function ● The SAMSUNG bottom mount freezer in 2009 has the following characteristics. Surround Multi Flow ● Uniform cooling for each shelf by a center positioned fan and duct with multiple flow effluences. Twin Cooling System ● The refrigerator and the freezer have two evaporators. Given this independent system, the freezer and the refrigerator are cooled individually as required and are, therefore, more efficient.
PRODUCT SPECIFICATIONS 2-2) Specifications ELECTRICAL SPECIFICATIONS Defrost Control ···································· From 12 to 64 hrs Thermo Bimetal Protector ··········140°F(60℃)(off) 104°F(40℃)(on) Defrost Thermistor(502AT) ·········R : 62.6°F(12℃) F : 57.2°F(14℃) Electrical Rating ···························AC115V 60Hz 11.6 Amps Maximum Current Leakage ··································· 0.5 mA Maximum Ground Path Resistance ··························0.
PRODUCT SPECIFICATIONS 2-3) Interior Views Door Bin Push it up and slide it out to disassemble. Light Moving Tray Pull it out to disassemble. Glass Shelf Pull it out until its stop Tilt down and slide it out.
PRODUCT SPECIFICATIONS 2-4) Model Specification SAMSUNG ITEM SPEC RF195, RF197, RF217 Appearance Noise Performance (RF217) Product Zone Cooling Tech Twin Cooling Door Shape Contour Special Room Cool Select Pantry Cooling F-Room 220↓ 177.3 Speed(Min) R-Room 220↓ 179.1 F-Room -26.0↓ -29.9 R-Room 2.0↓ -1.6 F-Room -18.0↓ -21.3 R-Room 5.0↓ -4.3 89.6℉(32°C) 109.4℉(43°C) Temperature Distribution (Fridge) F-Room 2.0↓ 0.6 R-Room 2.0↓ 0.8 Run Time N-N 65%↓ 51.
PRODUCT SPECIFICATIONS 2-5) Model Specification &Specification Chart Free Standing Model Model Number/ BOM code Swing/Auto Ice Maker Drawer/Auto Ice Maker 3 Door RF195 Dimension (WxDxH)Inch/mm 32¼x28¼x70(817x715x1778) Capacity (net) (cu.ft/l) Dimension (Net : Inch/mm) Weight (lb) RF197 RF217 32¼x28¼x70(817x715x1778) 32¼x230¼x70(817x765x1778) Total (17.8 / 504.0) (17.8 / 504.0) (19.7 / 557.8) Refrigerator (12.1 / 342.6) (12.1 / 342.6) (13.3 / 376.6) Freezer (5.7 / 161.4) (5.7 / 161.
PRODUCT SPECIFICATIONS Specification Model RF19 *,RF21* Compressor Components for Freezer Defrost Sensor Defrost Cycle Refrigerator Freezer Evaporator Bimetal Room Temperature Sensor Components Defrost Related Components Items Model MK162DL1U-E09 Starting type AC Oil Charge FREOL α-10 Freezer SPLIT FIN TYPE Refrigerator SPLIT FIN TYPE Condenser Forced and Natural Convection Type Dryer Molecular shieve XH-9 Capillary tube(Dia x Length) R : 0.032” x 157” (0.82mm x 4000mm) / F : 0.
PRODUCT SPECIFICATIONS Items Specification Model RF19 *,RF21* Defrost Heater(FRE) Heated at F Defrost AC 120V, 240W Defrost Heater(REF) Heated at R Defrost AC115V, 120W Model 4TM412SFBYY-53 Temp.ON 275 ± 9°F(135±5°C) Temp.OFF 141.
PRODUCT SPECIFICATIONS 2-6)Dimensions of Refrigerator (Inches) MODEL A B C D E RF19* RF21* 24 ⅜ 28 ½ 30 ½ 46 ½ 41 26 ¼ 30 ½ 32 ½ 48 ½ 43 14
PRODUCT SPECIFICATIONS 2-7) Refrigerant Route in Refrigeration cycle Compressor → Sub-condenser → Side Cluster → Hot Pipe → Dryer → R Capillary → R Evaporator → F Evaporator → Suction Pipe → Compressor 15
PRODUCT SPECIFICATIONS 2-8) Cooling Air Circulation (AXIAL FLOW FAN) (AXIAL FLOW FAN) 16
3. DISASSEMBLY AND REASSEMBLY 3-1) PRECAUTION • Unplug the refrigerator before cleaning and making repairs. • Do not dissemble or repair the refrigerator by yourself. - It may cause risk of causing a fire, malfunction and/or personal injury. • Remove any foreign matter or dust from the power plug pins. - Otherwise there is a risk of fire. • Do not use a cord that shows cracks or abrasion damage along its length or at either end. • Do not plug several appliances into the same multiple power board.
DISASSEMBLY AND REASSEMBLY 3-2) Refrigerator Door Part Name How To Do 1. Remove the 3 screws holding down the top table and remove it. 2. Disconnect electric wire on the top of the refrigerator. Refrigerator Door 3. Remove the 3 hex bolts that hold the hinge on the top of the refrigerator with the 7/16” socket wrench. 4. Remove the screw that holds the ground wire with a philips screwdriver(+). 5. Separate the Hinge from the electric wire and ground wire.
DISASSEMBLY AND REASSEMBLY Part Name How To Do Descriptive Picture 6. Lift the door straight up to remove. Be careful not to drop and scratch the doors while removing the doors. Refrigerator Door 7. Separate the cap on the middle hinge. 3-3 ) Freezer Door(RF195) Part Name How To Do Freezer Door 1. Remove the screw attached to the left and right middle hinges with a philops screwdriver(+). Remove the 2 hex head bolts attached to the left and right middle hinges with an allen wrench(3/16”).
DISASSEMBLY AND REASSEMBLY 3-3 ) Freezer Door(RF195) Part Name How To Do Descriptive Picture 2. Remove the Middle Hinge connected to the Freezer. Freezer Door 3. Disassemble the Freezer door by lifting it upward. Be careful not to drop and scratch the Freezer door 4. Disassemble the Cap on the Low Hinge. 3-3 ) Freezer Door(RF217,RF197) Part Name Freezer Door How To Do 1. After opening the Freezer door,lift the drawer box.
DISASSEMBLY AND REASSEMBLY Part Name How To Do Descriptive Picture 2. Remove 4 hex head bolts from both sides with a socket wrench(7/16”). Freezer Door 3. Lift up the freezer door from the rails. Be careful not to drop and scratch the freezer door. 3-4) Freezer Door Switch Part Name How To Do 1. Remove 1 screw at the lower part of the Freezer. Freezer Door Switch 2. Separate the Cap. 3. Separate the Housing.
DISASSEMBLY AND REASSEMBLY 3-5) Refrigerator Light Part Name How To Do Descriptive Picture 1. Remove the lamp cover by pulling it down as pushing the rear of lamp cover. Refrigerator Light 2. Remove the lamp by turning counterclockwise. 3-6) Glass shelves Part Name Glass shelves How To Do 1. When pulling out the shelf, if it is not slid out well, lift it up slightly and pull out again.
DISASSEMBLY AND REASSEMBLY 3-7) Moving tray Part Name How To Do Moving tray 1. When pulling out the Moving tray, if it is not slid out well, lift it up slightly and pull out again. Descriptive Picture 3-8) Vegetable & Fruit Drawers Shelf Part Name How To Do 1. Remove the vegetable & fruit drawer by pulling the roller part and lifting it up. Vegetable & Fruit Drawers Shelf 2. Remove the vegetable & fruit drawer shelf by pulling it out. (Refer to the picture) 3.
DISASSEMBLY AND REASSEMBLY 3-9) Gallon Door Bin Part Name Door Bin How To Do Descriptive Picture 1. Simply lift the bin up and pull straight out. (Refer to the picture) 3-10) Evaporator In Refrigerator Part Name How To Do 1. Remove the screw cap with a flat-blade screwdriver. Evaporator In Refrigerator 2. Unscrew a screw. 3. Unscrew two screws. And remove the hook by pulling it from the lower part and pushing the cover down.
DISASSEMBLY AND REASSEMBLY Part Name How To Do 4. Remove the housing cover by pushing both lateral sides of the housing cover and pulling it out. (Refer to the picture) Evaporator In Refrigerator 5. Disconnect the housing connector part. (Refer to the picture) 6. Remove the evaporator by Lifting the bottom side of it up and pulling it out.
DISASSEMBLY AND REASSEMBLY 3-11) Door Handle Freezer Part Name How To Do Descriptive Picture Insert the small flat-head driver to the hole at the bottom of Cap Handle and pull the handle assembly out to the front side with turning driver to one side. Door Handle Freezer CAUTION : Turn the handle assembly though 90 degrees to allow access to the bottom fixing position. - Required Tools : Flat Head Driver Ø0.12~0.13"(Ø3.0~3.3mm) 3-12) Freezer Light Part Name How To Do Freezer Light 1.
DISASSEMBLY AND REASSEMBLY 3-13) Evaporator Cover In Freezer Part Name How To Do Descriptive Picture 1. Remove the freezer door and freezer drawer by pulling out the drawer and then unscrewing 2 screws. Lift up the evaporator cover. Evaporator Cover In Freezer 2. Disengage the housing connector and remove the evaporator cover. 3-14) Evaporator InFreezer Part Name How To Do 1. Remove the housing cover by pushing both lateral sides of housing cover part and pulling it out.
DISASSEMBLY AND REASSEMBLY 3-15 ) Motor Fan Part Name How To Do 1. Unscrew 4 screws of cover compressor. 2. Disengage the housing connector. (Refer to the picture) Motor Fan 3. Remove the hooker of support circuit motor by lifting the hooker up and pulling it out. 4. Remove the screw with a flatblade screwdriver. (Refer to the picture) 5. Remove the motor fan by pulling the fan out while graping the motor part.
DISASSEMBLY AND REASSEMBLY Part Name How To Do 6. Unscrew 2 screws fixed in the motor. Motor Fan 7. Remove the hook of the motor cover with a flat-blade (-) screwdriver and then remove the motor.
4. TROUBLESHOOTING 4-1) Check items before failure diagnosis 4-1-1. TEST mode (Manual operation / Manual defrost function) ● ● ● If Energy Saver Key + Fridge Key on the front of panel are pressed simultaneously for 8 seconds, the test mode will be activated and all displays on the front of panel will be off.
TROUBLESHOOTING 2) Manual defrost (R : Fresh food compartment) function 2-1) If any key is pressed one more time during manual operation (Fresh food compartment), "rd" shows in the display and then manual operation will be canceled at once and fresh food compartment will be defrosted. 2-2) At this moment, alarm beeps for 3 seconds from the beginning, and then beeps 0.1 sec ON/ 1 sec OFF during manual defrost (Fresh food compartment) function.
TROUBLESHOOTING ❷ ❶ ① If Power Freeze Key + Power Cool Key are pressed simultaneously for 8 seconds, the error mode self-diagnosis will be canceled. 2) Self-diagnostic function during normal operation ❷ ❶ 2-1) If Power Freeze Key + Power Cool Key are pressed simultaneously for 6 seconds during normal operation, the temperature setting display will operate for 2 seconds (ALL ON/OFF 0.5 sec each).
TROUBLESHOOTING Self-diagnosis CHECK LIST NO Trouble item Display LED 1 Ice Maker Sensor Error R-1-ⓐ ICE MAKER SENSOR part error. 2 R-Sensor Error R-1-ⓑ R SENSOR part error. 3 R-DEF-Sensor Error R-1-ⓒ R defrost SENSOR part error. 4 R-FANError R-1-ⓓ R inner fan motor part error. 5 Ice Maker function Error R-1-ⓔ ICE MAKER operation error. 6 R-DEF. - Heater Error R-1-ⓖ R defrost part error. 7 Ambient-Sensor Error F-1-ⓐ External SENSOR part error.
TROUBLESHOOTING Self-diagnostics check list LED Item R-1-ⓐ Ice Maker Sensor Error R-1-ⓑ R-Sensor Error R-1-ⓒ R-DEF-Sensor Error Trouble contents Display error : In case of Separation of sensor housing part, contact error, disconnection, short circuit. Display error by temperature : when the sensing temperature is more than 149℉ (+65℃) or less than -58℉(-50℃). Diagnostic method When checking the voltage of MAIN PCB CN90 #3 ↔ #4 : Shall be between 4.5V~1.0V.
TROUBLESHOOTING 4-1-3. Load condition display function ❶ ❶ ① If Power Freeze Key + Power Cool Key are pressed simultaneously for 6 seconds, All ON/OFF will blink in 0.5 intervals for 2 seconds. ② If you press Fridge key after pressing the above keys, the load condition mode will start. 1) If Power Freeze Key + Power Cool Key are pressed simultaneously for 6 seconds during normal operation, the temperature setting display of the fresh food and freezer compartments will blink ALL ON/OFF in 0.
TROUBLESHOOTING Load mode Check list Display LED Display contents R-1-ⓐ R-FAN High When fresh food compartment FAN High operates, applicable LED ON. R-1-ⓑ R-FAN Low When fresh food compartment FAN Low operates, applicable LED ON. R-1-ⓒ R-DEF Heater R-1-ⓓ Start Mode R-1-ⓔ Overload condition When ambient temperature is more than 93℉(34℃), LED ON. R-1-ⓕ Low temperature condition When ambient temperature is less than 72℉(22℃), LED ON.
TROUBLESHOOTING 4-1-4. Display / Exhibition mode setting function ❶ ❶ ① If Power Freeze Key + Freezer Key are pressed for 3 seconds, exhibition / display mode will be started. 1) If Power Freeze Key + Freezer Key are pressed simultaneously for 3 seconds during normal operation, exhibition / display mode will be started with buzzer sound ("Ding-dong"). 2) If above Power Freeze Key + Freezer Key are pressed repeatedly, exhibition / display mode will be canceled.
TROUBLESHOOTING ① If Freezer Key + Power Cool Key are pressed simultaneously for 12 seconds, option setting mode will be started. Key control method after changing to option mode.
TROUBLESHOOTING 2) After changing to the option mode, fresh food compartment "0", freezer compartment "0" will be displayed. (Basically, fresh food compartment "0", freezer "0" would be set at shipping process, but setting value could be changed for the purpose of improving quality at mass producing process.
TROUBLESHOOTING 4-1-5. Option TABLE 1) Temperature changing table of freezer compartment Setting ITEM Freezer Temp Shift MODEL NW2 FDR Fridge Room 7-SEG 0 Reference Value Setting value Freezer Compartment Code Temp. compensation 0 0 1 -1 ℉(-0.5℃) 2 -2 ℉(-1.0℃) 3 -3 ℉(-1.5℃) 4 -4 ℉(-2.0℃) 5 -5 ℉(-2.5℃) 6 -6 ℉(-3.0℃) 7 -7 ℉(-3.5℃) 8 +1 ℉(+0.5℃) 9 +2 ℉(+1.0℃) 10 +3 ℉(+1.5℃) 11 +4 ℉(+2.0℃) 12 +5 ℉(+2.5℃) 13 +6 ℉(+3.0℃) 14 +7 ℉(+3.5℃) 15 +8 ℉(+4.
TROUBLESHOOTING 4-2) Diagnostic method according to the trouble symptom(Flow Chart) DATA1.Temperature table Resistance value and MICOM port voltage of sensor according to the temperature SENSOR CHIP : based on PX41C ℃ ℉ -50 -49 -48 -47 -46 -45 -44 -43 -42 -41 -40 -39 -38 -37 -36 -35 -34 -33 -32 -31 -30 -29 -28 -27 -26 -25 -24 -23 -22 -21 -20 -19 -18 -17 -16 -15 -14 -13 -12 -11 -10 -9 -8 -7 -6 -58 -56.2 -54.4 -52.6 -50.8 -49 -47.2 -45.4 -43.6 -41.8 -40 -38.2 -36.4 -34.6 -32.8 -31 -29.2 -27.4 -25.6 -23.
TROUBLESHOOTING 4-2-1. If the trouble is detected by self-diagnosis - The error of sensor will be displayed on the front of display. When the error of sensor is detected at initial power ON, display of abnormal sensor part will blink. - The appliance will not stop operating when the error of sensor is detected during operation of the appliance. But normal cooling might be not operated if the appliance is operated by the emergency operation mode.
TROUBLESHOOTING 2) If R Sensor has trouble ERROR Code Start DATA1. Temperature Table Is Main PCB Connector CN30 inserted correctly? YES ** Measuring point of resistance value according to Sensor ** R : CN30 #3 ↔ #8 Measure the resistance value ** ∞Ω : Short trouble / ∞Ω : Open trouble Is R Sensor unit normal? Refer to circuit diagram in the manual Sensor MICOM/Connector number Connector CN30#6(White) to REG1 R HEAT-SINK PCB typical Ground Voltage is measured between 4.6V ~ 0.
TROUBLESHOOTING 3) If R DEF Sensor has trouble ERROR Code Start DATA1. Temperature Table ** Measuring point of resistance value according to Sensor ** R-DEF : CN30 #4 ↔ #8 Measure the resistance value ** ∞Ω : Short trouble / ∞Ω : Open trouble Is Main PCB Connector CN30 inserted correctly? YES Is R DEF Sensor unit normal? Refer to circuit diagram in the manual Sensor MICOM/Connector Number Connector CN30-#4(Orange) and REG1 R DEF Heat-Sink PCB common Ground Voltage is measured between 4.6V ~ 0.
TROUBLESHOOTING 4) If Ambient Sensor has trouble ERROR Code Start DATA1. Temperature table ** Measuring point of resistance value according to Sensor ** Ambient : CN31#1 ↔ #3 Measure the resistance value ** Placed in the right top table of upper hinge.
TROUBLESHOOTING 5) If F Sensor has trouble ERROR Code Start DATA1. Temperature table ** Measuring point of resistance value according to Sensor ** F : CN30 #5 ↔ #8 Measure the resistance value ** ∞Ω : Short trouble / ∞Ω : Open trouble Is Main PCB Connector CN30 inserted correctly? YES Is F Sensor unit normal? Refer to circuit diagram in the manual Sensor MICOM/Connector number Connector CN30-#5(Yellow) and F REG1 Heat-Sink PCB common Ground Voltage is measure between 4.6V ~ 0.
TROUBLESHOOTING 6) If F DEF Sensor has trouble ERROR Code Start DATA1.
TROUBLESHOOTING 4-2-2. If FAN does not operate (F, R, C - FAN) -. The refrigerator of this model has BLDC FAN moror. BLDC motor is driven by DC 7~12V. -. On the normal condition of COMP ON, it operates together with F-FAN motor. If door is opened and closed once at a high ambient temperature, it will be operated after 1 minute delay. Therefore, you are advised not to taken it for an error. -. If there is a trouble, you should select the self-diagnostic function to check the trouble before power off.
TROUBLESHOOTING 4-2-3. If Ice Maker does not operate 1. Water is automatically supplied to the Ice Maker by temperature & time and Ice Maker dispenses cubed or crushed ice. 2. Power is applied to the one end of wires all the time, so be careful when disassembling and shell refer to its exploded diagram in any case. 3. Ice Maker operation shall be checked after pressing the Ice Maker Test S/W.(Freezer Ice Maker) it is impossible to check when the power is disengaged.
TROUBLESHOOTING 4-2-4. If defrost does not operate (F, R DEF Heater) - If defrost has trouble, select the self-diagnostic function to detect the error of defrost heater before Power off.
TROUBLESHOOTING 4-2-5. If Power is not supplied Caution At the power of main PCB, AC input power and a high voltage over DC170V(325V)are occurred. Please take care of yourself on repair and measurement. Start - Refer to function and 'reference' parts in the manual when checking Main PCB Common PCB Ground REG1 Heater Sink Input Voltage 115V ± 15% Is plug connected in ? Connect plug again, & check the plug loosening.
TROUBLESHOOTING 4-2-6. If compressor does not operate Preliminary Inspection "Check the compressor with selecting the manual operation" 1. Compressor does not work, unless 5mins pass after satisfying the temperature. 2. Compressor does not work during defrosting. 3. Compressor does not work because it sensing low temperature, unless the fridge & freeze sensor is connected.
TROUBLESHOOTING 4-2-7. If alarm sounds continuously without stop (Related with buzzer sound) Preliminary Inspection 1. The alarm of freezer / fridge will sound(Ding-dong) after 2minutes from initial door open, and it keeps sounding(ding-dong) at 1 minutes intervals when opening afterward. 2. The alarm sounds because MICOM sense as door-open when door is not pressed completely. So refrigerator inner lamp will be OFF after 10minutes from sensing door-open.
TROUBLESHOOTING ③ If buzzer does not sound If buzzer does not sounds when button is pressed, manual operation is started, or door is opened, separate Main PCB and then check the breakage of buzzer, bad soldering, etc. (It is recommended to replace Main PCB when the failure of parts is occurred after checking.
TROUBLESHOOTING 4-2-8. If Panel PCB does not work normally ① When lightning of Panel PCB is disabled Start Check parts trouble, fallen PCB Pattern, Solder connection of parts Is the PANEL PCB normal? Yes Is the connector of PANEL PCB part inserted correctly? Yes Is the connector of upper hinge COVER inserted correctly? Yes · Check the connecting part of left/right CABI upper hinge according to left/right opening of door.
TROUBLESHOOTING ② If Panel PCB Key is not selected Start Is Panel PCB connector inserted correctly? No Reinsert the connector and check the bad contact. No Are any keys are pressed from 6 of keys? No Reassemble the Panel PCB Cover Yes Is connector of upper hinge cover inserted correctly? No Reinsert the connector and check the bad contact.
TROUBLESHOOTING 4-2-9. If refrigerator Room Lamp does not light up (F,R - Same condition) 1. When you replace the lamp of freezer/fridge, please power off/unplug AC Cord to avoid an electric shock. 2. Please keep in mind you could get burnt by the excessive heating of an incandescent light bulb. 3. Bimetal is installed in the refrigerator Lamp. Check that if Lamp may be OFF by bimetal. (It may be deleted per model.
TROUBLESHOOTING 4-2-10. No water supply to the ice maker. Preliminary Inspection 1. Water supplies directly to water valve. Please shut off the water supplying prior to repair. 2. Power is applied to the one end of wires. Be careful when disassembling not to get an electric shock. 3. To check the Ice Water Valve operation, shall press the Ice Maker Test switch and then check the operation.
5 .
EXPLODED VIEW& PARTS LIST ■ Parts List of Freezer (RF217AB) NO CODE-NO PART NAME 1 1-1 1-2 1-3 1-4 1-5 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 10-1 10-2 10-3 11 12 12-1 12-2 12-3 13 14 15 16 16-1 16-2 16-3 16-4 16-5 16-6 16-7 16-8 16-9 DA97-06669A DA63-04455A DA63-04456A DA63-04457A DA66-10104A DA71-20145A DA90-04793A DA61-03189A DA67-01231A DA63-05155A DA96-00480A DA60-90005A DA61-02901A DA61-04462A DA47-00243C DA63-04296A 4713-001206 DA97-06703A DA61-04464A DA61-04512A DA66-00436A DA61-04507A DA97-06702A DA61-
■ Parts List of Freezer (RF197AB) NO CODE-NO PART NAME 1 1-1 1-2 1-3 1-4 1-5 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 10-1 10-2 10-3 11 12 12-1 12-2 12-3 13 14 15 16 16-1 16-2 16-3 16-4 16-5 16-6 16-7 16-8 16-9 DA97-06669A DA63-04455A DA63-04456A DA63-04457A DA66-10104A DA71-20145A DA90-04793A DA61-03189A DA67-01231A DA63-05155A DA96-00480A DA60-90005A DA61-02901A DA61-04462A DA47-00243C DA63-04296A 4713-001206 DA97-06703A DA61-04464A DA61-04512A DA66-00436A DA61-04507A DA97-06702A DA61-04465A DA61-04513A DA66-00
EXPLODED VIEW& PARTS LIST 5-2) Refrigerator 2 1 1-1 2-1 9 1-2 2-2 8 13 4 4-1 1-3 1-4 4-2 1-5 1-6 1-6 3 6 3-1 6-1 7 3-2 6-2 7-1 7-2 10 5-2 10-5 10-4 10-2 10-3 5 10 5-1 10-5 10-4 10-5 10-4 10-1 10-2 10-3 10-5 10-4 12 10-1 12-5 12-8 12-2 12-1 11-17 11-1 11-15 11-6 11-4 11-7 11-11 11-12 11-16 11-21 11-2 11-3 11-18 11-5 12-4 11-9 11 11-13 12-6 11-10 11-8 11-20 62 11-19 12-9 12-7
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator (RF217AB) NO CODE-NO PART NAME 1 1-1 1-2 1-3 1-4 1-5 1-6 2 2-1 2-2 3 3-1 3-2 4 4-1 4-2 5 5-1 5-2 6 6-1 6-2 7 7-1 7-2 8 9 10 10-1 10-2 10-3 10-4 10-5 11 11-1 11-2 11-3 11-4 11-5 11-6 11-7 11-8 11-9 11-10 11-11 11-12 11-13 11-14 11-15 11-16 11-17 11-18 DA97-06686A DA64-02645A DA64-02647A DA61-04511A DA61-04510A DA61-04505A DA63-00202A DA97-06674A DA63-04464A DA63-04465A DA97-06675A DA64-02645A DA64-02647A DA97-00663D DA64-00448B DA67-01807H DA97-07058A D
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator (RF217AB) NO CODE-NO PART NAME 11-19 11-20 11-21 12 12-1 12-2 12-3 12-4 12-5 12-6 12-7 12-8 12-9 13 DA63-40167A DA64-02065A DA96-00042A DA96-00461C 6501-000123 DA32-00006S DA47-00243C DA47-00244B DA59-00357B DA60-90005A DA61-03644A DA61-03683A DA61-04148A DA61-05292A GROMMET-COVER CHIL TRIM-COVER EVAP REF ASSY-HARNESS MOTOR ASSY EVAP-REF CABLE TIE SENSOR TEMP THERMO BIMETAL-PROTECTOR HEATER-METAL SHEATH EVAP REF RIVET-AVEX PLATE-EVAP HEATER FIXER-SENS
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator (RF197AB) NO CODE-NO PART NAME 1 1-1 1-2 1-3 1-4 1-5 1-6 2 2-1 2-2 3 3-1 3-2 4 4-1 4-2 5 5-1 5-2 6 6-1 6-2 7 7-1 7-2 8 9 10 10-1 10-2 10-3 10-4 10-5 11 11-1 11-2 11-3 11-4 11-5 11-6 11-7 11-8 11-9 11-10 11-11 11-12 11-13 11-14 11-15 11-16 11-17 11-18 DA97-06686A DA64-02645A DA64-02647A DA61-04511A DA61-04510A DA61-04505A DA63-00202A DA97-06674A DA63-04464A DA63-04465A DA97-06675A DA64-02645A DA64-02647A DA97-00663D DA64-00448B DA67-01807H DA97-07058A D
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator (RF197AB) NO CODE-NO PART NAME 11-19 11-20 11-21 12 12-1 12-2 12-3 12-4 12-5 12-6 12-7 12-8 12-9 13 DA63-40167A DA64-02065A DA96-00042A DA96-00461C 6501-000123 DA32-00006S DA47-00243C DA47-00244B DA59-00357B DA60-90005A DA61-03644A DA61-03683A DA61-04148A DA61-05292A GROMMET-COVER CHIL TRIM-COVER EVAP REF ASSY-HARNESS MOTOR ASSY EVAP-REF CABLE TIE SENSOR TEMP THERMO BIMETAL-PROTECTOR HEATER-METAL SHEATH EVAP REF RIVET-AVEX PLATE-EVAP HEATER FIXER-SENS
EXPLODED VIEW& PARTS LIST 5-3) Cabinet 1 1-5 2 1-4 1-7 2-1 2-2 1-2 1-6 1-3 1-8 1-1 3-1 3-2 3 5 8 10 4 9 4-4 6 4-2 5 4-3 5-2 4-1 5-4 5-1 12 5-3 12-1 7 11 12-3 12-5 12-4 12-4-3 15 12-4-7 12-4-5 15-2 15-1 13 17 12-2 12-4-2 12-4-1 15 16 12-4-4 17 15-2 14 15-1 13-3 14-2 13-1 14-1 13-4 13-2 13-1 67
EXPLODED VIEW& PARTS LIST ■ Parts List of Cabinet (RF217AB) NO CODE-NO PART NAME SPEC QUAN TITY 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 1-8 2 2-1 2-2 3 3-1 3-2 4 4-1 4-2 4-3 4-4 5 5-1 5-2 5-3 5-4 6 7 8 9 10 11 12 12-1 12-2 12-3 12-4 12-4-1 12-4-2 12-4-3 12-4-4 12-4-5 12-4-6 12-5 13 13-1 13-2 13-3 13-4 14 14-1 14-2 DA97-07654A DA34-00043C DA41-00635A DA61-05316A DA64-02960A DA61-04052A DA64-02071A DA64-02981A DA96-00571A DA97-06715B DA61-04475B DA63-02527A DA97-06716B DA61-04476B DA63-02527A DA97-07514A DA61-049
EXPLODED VIEW& PARTS LIST ■ Parts List of Cabinet (RF217AB) NO CODE-NO 15 15-1 15-2 15-3 16 17 DA97-06688B DA61-04977A DA61-04490A DA71-50240B DA61-04702A DA61-01920A PART NAME ASSY SUPPORT-FOOT FRONT FOOT-FRONT SUPPORT-FOOT FRONT BRACKET-CABI CASTER-FRONT CASTER-RIVET SPEC NW2-FDR,FOOT FRONT(DA61-04977A) / 2 AW2-PJT,PP+MSWR10,-,BLACK,-,-,- / 2 NW2,SHP1,T4.0,-,-,-,- / 2 T3-PJT,SBHG1,T1.6,-,-,-,AW-PJT,PP,-,35,NTR,35,PP+TPE (ZPC2),MSWR10,OD8.
EXPLODED VIEW& PARTS LIST ■ Parts List of Cabinet (RF197AB) NO CODE-NO PART NAME SPEC QUAN TITY 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 1-8 2 2-1 2-2 3 3-1 3-2 4 4-1 4-2 4-3 4-4 5 5-1 5-2 5-3 5-4 6 7 8 9 10 11 12 12-1 12-2 12-3 12-4 12-4-1 12-4-2 12-4-3 12-4-4 12-4-5 12-4-6 12-5 13 13-1 13-2 13-3 13-4 14 14-1 14-2 DA97-07654A DA34-00043C DA41-00635A DA61-05316A DA64-02960A DA61-04052A DA64-02071A DA64-02981A DA96-00571A DA97-06715B DA61-04475B DA63-02527A DA97-06716B DA61-04476B DA63-02527A DA97-07514A DA61-049
EXPLODED VIEW& PARTS LIST ■ Parts List of Cabinet (RF197AB) NO CODE-NO 15 15-1 15-2 15-3 16 17 DA97-06688B DA61-04977A DA61-04490A DA71-50240B DA61-04702A DA61-01920A PART NAME ASSY SUPPORT-FOOT FRONT FOOT-FRONT SUPPORT-FOOT FRONT BRACKET-CABI CASTER-FRONT CASTER-RIVET SPEC NW2-FDR,FOOT FRONT(DA61-04977A) / 2 AW2-PJT,PP+MSWR10,-,BLACK,-,-,- / 2 NW2,SHP1,T4.0,-,-,-,- / 2 T3-PJT,SBHG1,T1.6,-,-,-,AW-PJT,PP,-,35,NTR,35,PP+TPE (ZPC2),MSWR10,OD8.
EXPLODED VIEW& PARTS LIST 5-4) Disassembly of Freezer Door 2-1 2-3 2-6 2-2 2-7 2-5 1 2 2-8 2-4 1-10 1-11 1-14 1-16 1-6 1-8 1-9 1-12 1-13 1-1 1-15 1-1-1 1-7 1-1-3 1-1-2 1-2 1-3 1-5 1-1-4 4 72
EXPLODED VIEW& PARTS LIST ■ Parts List of Freezer Door (RF217AB, RF197AB) NO CODE-NO PART NAME SPEC QUAN TITY 1 1-1 1-1-1 1-1-2 1-1-3 1-1-4 1-2 1-3 1-4 1-5 1-6 1-7 1-8 1-9 1-10 1-11 1-12 1-13 1-14 1-15 1-16 2 2-1 2-2 2-3 2-4 2-5 2-6 2-7 2-8 DA90-05229A DA91-02887A DA67-02332A DA67-02331A 6002-001122 DA61-03769A DA97-07722A DA61-03153B DA61-03155B 6002-000613 DA63-05034A DA63-05033A 6002-000215 DA61-04471A DA61-05327A DA67-02343A DA67-02344A DA61-05215A DA61-04474B DA66-00682A DA61-04335B DA97-07683A D
EXPLODED VIEW& PARTS LIST 5-5) Disassembly of Refrigerator Door Left 1-1 1 2 3 5 9 2-2 2-4 6 2-1 10 11 2-3 1-7 1-6 1-5 1-2 4 1-3 1-4 4-3 4-5 4-4 4-7 4-2 4-1 4-15 4-6 4-16 7 8 4-10 4-12 4-11 4-9 4-8 74
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator Door-Left (RF217AB, RF197AB) NO CODE-NO PART NAME SPEC QUAN TITY 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 2 2-1 2-2 2-3 2-4 3 4 4-1 4-2 4-3 4-4 4-5 4-6 4-7 4-8 4-9 4-10 4-11 4-12 4-13 4-14 4-15 4-16 5 6 7 8 9 10 11 DA91-02889A DA61-03769A 6001-001377 6002-001120 6009-001475 DA61-02383A DA61-03211A DA63-40294A DA97-07896A DA64-03069A DA67-02391A DA67-02392A 6002-000215 DA97-07668A DA97-07661A DA61-05315A DA47-00245E DA61-05291A DA62-02212A DA62-02294A DA63-03
EXPLODED VIEW& PARTS LIST 5-6) Disassembly of Refrigerator Door Right 2 4 7 1-1 2-2 1 3 2-4 5 7-1 6 2-1 7-2 8 2-3 9 10 1-7 1-6 1-4 1-5 1-2 1-3 76
EXPLODED VIEW& PARTS LIST ■ Part List of Refrigerator Door-Right (RF217AB, RF197AB) NO CODE-NO 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 2 2-1 2-2 2-3 2-4 3 4 5 6 7 7-1 7-2 8 9 10 DA91-02888A DA61-03769A 6001-001377 6002-001120 6009-001475 DA61-02383E DA61-03212A DA63-40294A DA97-07896A DA64-03069A DA67-02391A DA67-02392A 6002-000215 DA97-07668A 6002-000468 DA61-02984A DA64-01985A DA97-07681A DA63-05042A DA63-05050A DA63-05131A DA63-05035A DA63-05036A PART NAME ASSY DOOR FOAM REF R MAGNET SCREW-MACHINE SCREW-TAPPIN
5 .
■ Parts List of Freezer (RF195AB) NO CODE-NO PART NAME 1 1-1 1-2 1-3 1-4 1-5 2 2-1 2-2 2-3 3 4 5 6 7 8 9 10 10-1 10-2 10-3 11 12 12-1 12-2 12-3 13 14 15 16 16-1 16-2 16-3 16-4 16-5 16-6 16-7 16-8 16-9 DA97-06670A DA63-04455A DA63-04456A DA63-04450A DA66-10104A DA71-20145A DA90-04793A DA61-03189A DA67-01231A DA63-05155A DA96-00480A DA60-90005A DA61-02901A DA61-04462A DA47-00243C DA63-04296A 4713-001206 DA97-06720A DA61-04464A DA61-04516A DA66-00436A DA61-04508A DA97-06718A DA61-04465A DA61-04515A DA66-00
EXPLODED VIEW& PARTS LIST 5-2) Refrigerator 2 1 1-1 2-1 9 1-2 2-2 8 13 4 4-1 1-3 1-4 4-2 1-5 1-6 1-6 3 6 3-1 6-1 7 3-2 6-2 7-1 7-2 10 5-2 10-5 10-4 10-2 10-3 5 10 5-1 10-5 10-4 10-5 10-4 10-1 10-2 10-3 10-5 10-4 12 10-1 12-5 12-8 12-2 12-1 11-17 11-1 11-15 11-6 11-4 11-7 11-11 11-12 11-16 11-21 11-2 11-3 11-18 11-5 12-4 11-9 11 11-13 12-6 11-10 11-8 11-20 80 11-19 12-9 12-7
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator (RF195AB) NO CODE-NO PART NAME 1 1-1 1-2 1-3 1-4 1-5 1-6 2 2-1 2-2 3 3-1 3-2 4 4-1 4-2 5 5-1 5-2 6 6-1 6-2 7 7-1 7-2 8 9 10 10-1 10-2 10-3 10-4 10-5 11 11-1 11-2 11-3 11-4 11-5 11-6 11-7 11-8 11-9 11-10 11-11 11-12 11-13 11-14 11-15 11-16 11-17 11-18 DA97-06686A DA64-02645A DA64-02647A DA61-04511A DA61-04510A DA61-04505A DA63-00202A DA97-06674A DA63-04464A DA63-04465A DA97-06675A DA64-02645A DA64-02647A DA97-00663D DA64-00448B DA67-01807H DA97-07058A D
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator (RF195AB) NO CODE-NO PART NAME 11-19 11-20 11-21 12 12-1 12-2 12-3 12-4 12-5 12-6 12-7 12-8 12-9 13 DA63-40167A DA64-02065A DA96-00042A DA96-00461C 6501-000123 DA32-00006S DA47-00243C DA47-00244B DA59-00357B DA60-90005A DA61-03644A DA61-03683A DA61-04148A DA61-05292A GROMMET-COVER CHIL TRIM-COVER EVAP REF ASSY-HARNESS MOTOR ASSY EVAP-REF CABLE TIE SENSOR TEMP THERMO BIMETAL-PROTECTOR HEATER-METAL SHEATH EVAP REF RIVET-AVEX PLATE-EVAP HEATER FIXER-SENS
EXPLODED VIEW& PARTS LIST 5-3)Cabinet 1 1-5 2 1-4 1-7 2-1 2-2 1-2 1-6 1-3 1-8 1-1 3-1 3-2 3 5 8 10 4 9 4-4 6 4-2 5 4-3 5-2 4-1 5-4 5-1 12 5-3 12-1 7 11 12-3 12-5 12-4 12-4-3 15 12-4-7 12-4-5 15-2 15-1 17 13 19 16 14 12-2 18 17 12-4-2 12-4-1 12-4-4 18-3 18-2 18-1 13-3 14-2 13-1 14-1 13-4 13-2 13-1 83
EXPLODED VIEW& PARTS LIST ■ Parts List of Cabinet (RF195AB) NO CODE-NO PART NAME SPEC QUAN TITY 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 1-8 2 2-1 2-2 3 3-1 3-2 4 4-1 4-2 4-3 4-4 5 5-1 5-2 5-3 5-4 6 7 8 9 10 11 12 12-1 12-2 12-3 12-4 12-4-1 12-4-2 12-4-3 12-4-4 12-4-5 12-4-6 12-5 13 13-1 13-2 13-3 13-4 14 14-1 14-2 DA97-07654A DA34-00043C DA41-00635A DA61-05316A DA64-02960A DA61-04052A DA64-02071A DA64-02981A DA96-00571A DA97-06715B DA61-04475B DA63-02527A DA97-06716B DA61-04476B DA63-02527A DA97-07514A DA61-049
EXPLODED VIEW& PARTS LIST ■ Parts List of Cabinet (RF195AB) NO CODE-NO 15 15-1 15-2 15-3 16 17 DA97-06688B DA61-04977A DA61-04490A DA71-50240B DA61-04702A DA61-01920A PART NAME ASSY SUPPORT-FOOT FRONT FOOT-FRONT SUPPORT-FOOT FRONT BRACKET-CABI CASTER-FRONT CASTER-RIVET SPEC NW2-FDR,FOOT FRONT(DA61-04977A) / 2 AW2-PJT,PP+MSWR10,-,BLACK,-,-,- / 2 NW2,SHP1,T4.0,-,-,-,- / 2 T3-PJT,SBHG1,T1.6,-,-,-,AW-PJT,PP,-,35,NTR,35,PP+TPE (ZPC2),MSWR10,OD8.
EXPLODED VIEW& PARTS LIST 5-4) Disassembly of Freezer Door 1 1-1 1-2 1-1-1 1-1-2 1-1-3 86
EXPLODED VIEW& PARTS LIST ■ Parts List of Freezer Door (RF195AB) NO CODE-NO 1 1-1 1-1-1 1-1-2 1-1-3 1-2 CODE---CODE---DA61-03769A DA61-02773A 6001-001377 DA97-07722A PART NAME ASSY DOOR FRE(SWING) ASSY DOOR FOAM FRE(SWING) MAGNET STOPPER-DOOR SCREW-MACHINE ASSY-GASKET DOOR FRE SPEC HERMES,-,5x7x18,-,-,1200Gauss CORE,POM,-,-,-,NTR,TH,+,-,M5,L25,ZPC(WHT),SWRCH18A,FP,NW2-FDR,BLACK,-,- 87 QUAN TITY 1 1 1 1 1 1 REMARK
EXPLODED VIEW& PARTS LIST 5-5) Disassembly of Refrigerator Door Left 1-1 1 2 3 5 9 2-2 2-4 6 2-1 10 11 2-3 1-7 1-6 1-5 1-2 4 1-3 1-4 4-3 4-5 4-4 4-7 4-2 4-1 4-15 4-6 4-16 7 8 4-10 4-12 4-11 4-9 4-8 88
EXPLODED VIEW& PARTS LIST ■ Parts List of Refrigerator Door-Left (RF195AB) NO CODE-NO PART NAME SPEC QUAN TITY 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 2 2-1 2-2 2-3 2-4 3 4 4-1 4-2 4-3 4-4 4-5 4-6 4-7 4-8 4-9 4-10 4-11 4-12 4-13 4-14 4-15 4-16 5 6 7 8 9 10 11 DA91-02889A DA61-03769A 6001-001377 6002-001120 6009-001475 DA61-02383A DA61-03211A DA63-40294A DA97-07896A DA64-03069A DA67-02391A DA67-02392A 6002-000215 DA97-07668A DA97-07661A DA61-05315A DA47-00245E DA61-05291A DA62-02212A DA62-02294A DA63-03454B DA63
EXPLODED VIEW& PARTS LIST 5-6) Disassembly of Refrigerator Door Right 2 4 7 1-1 2-2 1 3 2-4 5 7-1 6 2-1 7-2 8 2-3 9 10 1-7 1-6 1-4 1-5 1-2 1-3 90
EXPLODED VIEW& PARTS LIST ■ Part List of Refrigerator Door-Right (RF195AB) NO CODE-NO 1 1-1 1-2 1-3 1-4 1-5 1-6 1-7 2 2-1 2-2 2-3 2-4 3 4 5 6 7 7-1 7-2 8 9 10 DA91-02888A DA61-03769A 6001-001377 6002-001120 6009-001475 DA61-02383E DA61-03212A DA63-40294A DA97-07896A DA64-03069A DA67-02391A DA67-02392A 6002-000215 DA97-07668A 6002-000468 DA61-02984A DA64-01985A DA97-07681A DA63-05042A DA63-05050A DA63-05131A DA63-05035A DA63-05036A PART NAME ASSY DOOR FOAM REF R MAGNET SCREW-MACHINE SCREW-TAPPING SCREW-S
6. PCB DIAGRAM 6-1) PCB L ayout with part position (Main Board) 1. DC12V,5V, & GND are supplied from SMPS PCB. 2. FAN MOTOR driving part : Supply the power from 8.3V~12V to motor according to the motor type (F,R,C,ICE). 3. EEPROM : Save and record every kinds of data. 4. Transmit inputted signals from every sensor into MICOM after eliminate the noise. 5. Departure part : Generate the CLOCK which needs to conrol MICOM program RESET control circuit part : Initialize the program by sensing power ON/OFF. 6.
PCB DIAGRAM 6-2) Connector Layout with part position (Main Board) CN90 - Ice Maker ~ : OPEN : OPEN : Sensor : Test Switch : Full Switch : Horizontal Switch : CN76 - BLDC Motor : C-FAN signal input volt : F-FAN signal input volt : R-FAN signal input volt : C-FAN operation signal : F-FAN operation signal : R-FAN operation signal : CN31 - Sensor : Ambient : CN30 - Sensor & Switch : F-Door Switch : R-Door Switch : R-Sensor : R-DEF-Sensor : F-Sensor : F-DEF-Sensor : : CN50 ~ : Panel LED Driver : Display Swit
7.
8.
SchematicDiagram 8-2) Main 96
272, Oseon-Dong, Gwangsan-Gu, Gwangju-City, Korea, 506-253 TEL : 82-62-950-6193, 6896 FAX : 82-62-950-6829 - This Service Manual is a property of Samsung Electronics Co., Ltd. Any unauthorized use of Manual can be punished under applicable International or domestic law. © Samsung Electronics Co., Ltd. Refrigerator Division 2008.
