Programming instructions

ManualsBrandsSamsung ManualsHousehold AppliancesF1053V

Mr Richard Solomon

RFI Global Services Limited

Your Reference:

Date: 5 October 2005

Dear Mr Solomon

MANUFACTURER OR ACCREDITED AGENT: Psion Teklogix

ECE REGULATION/EEC DIRECTIVE: R10 &72/245

Job No. Vehicle Type/Component Approval No. Index Rev. No.

EAF067676 8530 10R-023560 Not applicable

“ “ “ “ e11*72/245*95/54*3560*00 “ “

1. This vehicle component has been tested and meets the requirements of the above ECE

Regulation/EEC Directive. I enclose a set of approval documents, comprising the approval, test

report and your documentation duly authenticated.

2. If you think there are any errors in the enclosed package, please contact Andrew Meadows,

telephone 0117 952 4187, e-mail andrew.meadows@vca.gov.uk

immediately. Please be aware

that from the date of issue we have a three week holding period, any corrections required after

this time will need to be corrected via an extension, index revision or correction 1 certificate, as

appropriate.

ROAD TRAFFIC ACT 1988 - SECTION 80

3. The Secretary of State for Transport authorises, under section 80 of the Road Traffic Act 1988,

the above manufacturer or accredited agent to apply to the motor vehicle part specified, the

appropriate mark designated in the Motor Vehicles (Designation of Approval Marks) Regulations

1979, as amended. The conditions attached to this authorisation are set out overleaf.

4. If this approval results in a change being needed to a vehicle information document issued under

the goods vehicle or passenger car national type approval scheme, you should notify us (i.e. submit

a 'notifiable alteration') as soon as possible, using the address VCA (Whole Vehicle), Room 1.2,

The Eastgate Office Centre, Eastgate Road, Bristol BS5 6XX.

5. VCA is continually scrutinising the quality of the service it provides to customers, in order to

discover more ways in which the standard can be improved. If you have a specific complaint

concerning the way this job has been dealt with, our customer services leaflet gives guidance on

the best approach. If you would like a copy, please contact the undersigned.

Yours sincerely

JAMES SIBLEY

Product Certification

Summary of content (138 pages)

PAGE 1
Mr Richard Solomon RFI Global Services Limited Your Reference: Date: 5 October 2005 Dear Mr Solomon MANUFACTURER OR ACCREDITED AGENT: Psion Teklogix ECE REGULATION/EEC DIRECTIVE: R10 &72/245 Job No. EAF067676 “ “ Vehicle Type/Component Approval No. 8530 10R-023560 “ “ e11*72/245*95/54*3560*00 Index Rev. No. Not applicable “ “ 1. This vehicle component has been tested and meets the requirements of the above ECE Regulation/EEC Directive.
PAGE 2
1. CONDITIONS 3. CONDITIONS FOR MOTOR VEHICLES 1.1 This Approval may be withdrawn at any time and while held is subject to the following conditions. 3.
PAGE 3
Switchboard: Main Fax: E-mail: Web Site: 1 The Eastgate Office Centre Eastgate Road Bristol BS5 6XX United Kingdom +44 (0)117 951 5151 +44 (0)117 952 4103 general@vca.gov.uk www.vca.gov.
PAGE 4
ECE REGULATION NO: 10.02 STU 7. Address(es) of assembly plant(s): See section 5 8. Additional information (where applicable): See Appendix 9. Technical service responsible for carrying out the tests: RFI Global Services Limited 10. Date of test report: 5 October 2005 11. Number of test report: RFI/EMCE1/RP47590JD01A 12. Remarks (if any): See Appendix 13. Place: BRISTOL 14. Date: 15. Signature: 16.
PAGE 5
ECE REGULATION NO: 10.02 STU Appendix to Type Approval Communication Certificate No: 10R-023560 concerning the type approval of an electrical/electronic sub-assembly under Regulation No: 10 1. Additional information 1.1. Electrical system rated voltage: Plug in either 12V or 24V battery, negative ground 1.2 This ESA can be used on any vehicle type with the following restrictions: To be fitted to commercial vehicles with a system voltage within 1.1 above, negative earth 1.2.
PAGE 6
1 The Eastgate Office Centre Eastgate Road Bristol BS5 6XX United Kingdom Switchboard: Main Fax: E-mail: Web Site: +44 (0)117 951 5151 +44 (0)117 952 4103 general@vca.gov.uk www.vca.gov.
PAGE 7
2/245/EEC AS LAST AMENDED BY 95/54/EC 0.8 Address(es) of assembly plant(s): As section 0.5 above SECTION II 1. Additional information (where applicable): See Appendix 1 2. Technical service responsible for carrying out the tests: RFI Global Services Limited 3. Date of test report: 5 October 2005 4. Number of test report: RFI/EMCE1/RP47590JD01A 5. Remarks (if any): See Appendix 2 6. Place: BRISTOL 7. Date: 5 OCTOBER 2005 8. Signature: 9.
PAGE 8
72/245/EEC AS LAST AMENDED BY 95/54/EC APPENDIX to EEC Type Approval Certificate No: e11*72/245*95/54*3560*00 concerning the type approval of an electric/electronic sub-assembly with regard to Directive 72/245/EEC as last amended by Directive 95/54/EC 1. Additional information: 1.1 Electrical system rated voltage: Plug in either 12V or 24V battery 1.2 This ESA can be used on any vehicle type with the following restrictions: To be fitted to commercial vehicles with a system voltage within 1.
PAGE 9
1 The Eastgate Office Centre Eastgate Road Bristol BS5 6XX United Kingdom Switchboard: Main Fax: E-mail: Web Site: +44 (0)117 951 5151 +44 (0)117 952 4103 general@vca.gov.uk www.vca.gov.
PAGE 10
TABLE OF CONTENTS VCA Job Number: EAF067676 EUT: Vehicle Mount Terminal 8530 Section 1). General Information Section 2). Appendix 1: Identification of the ESA chosen to represent the type. Section 3).
PAGE 11
INFORMATION DOCUMENT RELATING TO VCA JOB NUMBER EAF067676 RELATING TO TYPE APPROVAL OF AN ESA WITH RESPECT TO ELECTROMAGNETIC COMPATIBILITY (72/245/EEC) AS LAST AMENDED BY 95/54/EC. Vehicle Mount Terminal 8530 0. GENERAL 0.1 Make (trade name of manufacturer): Psion Teklogix 0.2 Type and general commercial description (s): Vehicle Mount Terminal 8530 0.3 Means of identification of type, if marked on the component/separate technical unit: Not Applicable. 0.3.1 Location of that marking: Not Applicable.
PAGE 12
1. This ESA shall be approved as a Component / STU. Component 2. Any restrictions of use and conditions for fitting: The restrictions for use as regards this application are the test configuration used during the test. Any deviation from this configuration may compromise the EMC performance of the system.
PAGE 13
Engineering Bill of Materials 2100 Meadowvale Blvd.
PAGE 14
BOM 1008015-002 Rev A5 Device 1002023 Qty 1 Sorted By BAAN Number Description SOFTWARE 8525/30 CE V4.
PAGE 15
BOM 1008015-002 Rev A5 Device 1008014 Qty 0 Sorted By BAAN Number Description DOCUMENT SCHEMATIC 8525/30 MAIN LOGIC BOARD Process Code: SCH BAAN Description Line 1: DOC SCHEMATIC MLB 8525/30 Product Type: VK0 BAAN Description Line 2: MAIN_LOGIC_BOARD Item Group DOC Reference Designators: 1008087 2 1008211 Process Code: CMP BAAN Description Line 1: LABEL BLANK PCA 0.25"X1.0" Product Type: XE0 BAAN Description Line 2: WHITE MYLAR 0.
PAGE 16
BOM 1008015-002 Rev A5 Device 9000501 Qty 9 Sorted By BAAN Number Description TRANSISTOR MOSFET P-CHAN ENHANCEMENT 360MW 40V 6R_RDS SOT-23 Process Code: CMP BAAN Description Line 1: TRANSISTOR FET P-CHAN 50V Product Type: XE0 BAAN Description Line 2: SMT SOT-23 350MW Item Group XTR Reference Designators: 9000515 8 BSS84P FAIRCHILD NC7SZ125P5X ON SEMICONDUCTOR M74VHC1G125DFT? BAAN Description Line 1: IC BUFFER TRI-STATE OUTPUT TOSHIBA TC7SZ125FU Product Type: XE0 BAAN Description L
PAGE 17
BOM 1008015-002 Rev A5 Device 9000533 Qty 1 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 63K4 OHM ±1% AVX KYOCERA CR05-6342F-? CMP BAAN Description Line 1: RESISTOR 1/16W 63K4 OHM 1% KOA RK73H1E?6342F Product Type: XE0 BAAN Description Line 2: SMT 0402 ROHM MCR01?F6342 Item Group RES PANASONIC ERJ2RKF6342? SAMSUNG RC1005F6342? FAIRCHILD FDS6961A DALE WSL1206 0.
PAGE 18
BOM 1008015-002 Rev A5 Device 9000558 Qty 1 Sorted By BAAN Number Description DIODE SMT POWER SCHOTTKY 40V 2A Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group DIO Reference Designators: 9000559 6 CMP BAAN Description Line 1: DIODE SMT ZENER 18V SOT23 Product Type: XE0 BAAN Description Line 2: 225MW Item Group DIO Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group ICT 1 CMP BAAN Desc
PAGE 19
BOM 1008015-002 Rev A5 Device 9000906 Qty 1 Sorted By BAAN Number Description CAPACITOR 4F -10+30%TOL 2.
PAGE 20
BOM 1008015-002 Rev A5 Device 9000958 Qty 1 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 26K7 OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES Reference Designators: 9000963 2 CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group ICT 9000983 CMP BAAN Description Line 1: IC PC CARD PWR SWITCH Product Type: XE0 BAAN Description Line 2: 5V/3V TSSOP8 Item Group ICT 1 CMP BAAN De
PAGE 21
BOM 1008015-002 Rev A5 Device 9001544 Qty 1 Sorted By BAAN Number Description CON SD CARD/MMC CONNECTOR, MANUAL INSERTION WITH CARD DETECT AND WRITE PROTECT SWITCHES Process Code: CMP BAAN Description Line 1: CONNECTOR SD I/O Product Type: XE0 BAAN Description Line 2: MANUAL INSERTION Item Group CON Reference Designators: 9001547 4 9001558 Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group TRS 1 9001562 CMP BAAN Description Line 1: I
PAGE 22
BOM 1008015-002 Rev A5 Device 9001579 Qty 2 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 137K OHM ±1% AVX KYOCERA CR05-1373F-? CMP BAAN Description Line 1: RESISTOR 1/16W 137K OHM 1% KOA RK73H1E?1373F Product Type: XE0 BAAN Description Line 2: SMT 0402 ROHM MCR01?F1373 Item Group RES PANASONIC ERJ2RKF1373? SAMSUNG RC1005F1373? MURATA GRM36COG330J050AD AVX 4025A330JAT2A 4 Process Code: CMP BAAN Description Line 1: CAPACITOR 50V 33PF 5% VENKEL C0402COG500-330J Pr
PAGE 23
BOM 1008015-002 Rev A5 Device 9001598 Qty 1 Sorted By BAAN Number Description IC LINEAR LDO REGULATOR 1.
PAGE 24
BOM 1008015-002 Rev A5 Device 9002773 Qty 1 Sorted By BAAN Number Description IC DISPLAY CONTROLLER CMOS S1D13806 144 TQFP INDUSTRIAL TEMP Process Code: CMP BAAN Description Line 1: IC LCD CONTROLLER CMOS TQFP144 Product Type: XE0 BAAN Description Line 2: INDUSTRIAL TEMP Item Group ICT Reference Designators: 9002922 1 9002929 Process Code: CMP BAAN Description Line 1: CONNECTOR PLUG VERT 120 PIN Product Type: XE0 BAAN Description Line 2: DUAL 7MM B-B 0.
PAGE 25
BOM 1008015-002 Rev A5 Device 9002936 Qty 6 Sorted By BAAN Number Description TRANSISTOR MOSFET POWER P_CHAN LOGIC LEVEL 11A -30V R02_RDS SO-8 Process Code: CMP BAAN Description Line 1: TRANSISTOR P_CH FET -30V -11A Product Type: XE0 BAAN Description Line 2: SO-8 Item Group XTR Reference Designators: 9002940 1 9002945 Process Code: CMP BAAN Description Line 1: CONNECTOR 10 PIN RA MICRO 3MM Product Type: XE0 BAAN Description Line 2: MOLEX MICRO FIT 3MM DUAL Item Group CON 1 900294
PAGE 26
BOM 1008015-002 Rev A5 Device 9002950 Qty 4 Sorted By BAAN Number Description IC, SOFT START POWER SWITCH 2A SO-8 Process Code: CMP BAAN Description Line 1: IC POWER SWITCH 2A SOFT START Product Type: XE0 BAAN Description Line 2: SO-8 Item Group ICT Reference Designators: 9002955 1 Process Code: CMP BAAN Description Line 1: IC LDO 5V 150MA 20UA QUIESC Product Type: XE0 BAAN Description Line 2: LINEAR_REGULATOR Item Group ICT 4 9003331 Process Code: CMP BAAN Description Line 1:
PAGE 27
BOM 1008015-002 Rev A5 Device 9003414 Qty 1 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 40K2 OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES Reference Designators: 9003428 15 CMP BAAN Description Line 1: CAPACITOR 50V 10UF ±10% Product Type: XE0 BAAN Description Line 2: CERAMIC SMT 2220 X5R Item Group CAP 13 CMP BAAN Description Line 1: CAPACITOR 16V 10UF +80%/-20% Product Type: XE0 BAAN Description Line
PAGE 28
BOM 1008015-002 Rev A5 Device 9003433 Qty 4 Sorted By BAAN Number Description CAPACITOR CERAMIC SMT 1812 X7R 50V 2U2 ±10% Process Code: CMP BAAN Description Line 1: CAPACITOR 50V 2.
PAGE 29
BOM 1008015-002 Rev A5 Device 9003455 Qty 1 Sorted By BAAN Number Description IC MEMORY NAND FLASH 32M X 16 BIT 2.7-3.
PAGE 30
BOM 1008015-002 Rev A5 Device 9004472 Qty 1 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 44R2 OHM ±1% AVX KYOCERA CR05-44R2F-? CMP BAAN Description Line 1: RESISTOR 1/16W 44R2 OHM 1% KOA RK73H1ELTD44R2F? Product Type: XE0 BAAN Description Line 2: SMT 0402 ROHM MCRO1?F44R2 Item Group RES SAMSUNG RC1005F44R2? SPAE-NAUR 676-018 SPAE-NAUR 659-002 4 Process Code: CMP BAAN Description Line 1: Product Type: XM0 BAAN Description Line 2: Item Group WSR 4 CMP BAAN Desc
PAGE 31
BOM 1008015-002 Rev A5 Device 9004509 Qty 1 Sorted By BAAN Number Description IC SINGLE FET BUS SWITCH 250PSEC ACTIVE LOW ENABLE SC70 PKG Process Code: CMP BAAN Description Line 1: IC SINGLE FET BUS SWITCH Product Type: XE0 BAAN Description Line 2: 250PSEC ACTIVE LOW ENABLE SC70 Item Group ICT Reference Designators: 9004510 1 9004511 Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group ICT 2 9004512 CMP BAAN Description Line 1: IC 2-IN
PAGE 32
BOM 1008015-002 Rev A5 Device 9004558 Qty 1 Sorted By BAAN Number Description IC LDO REGULATOR 2V5 1A5 SOT223-5 Process Code: CMP BAAN Description Line 1: IC LDO REGULATOR 2V5 1A5 Product Type: XE0 BAAN Description Line 2: SOT223-5 Item Group ICT Reference Designators: 9006461 2 Process Code: CMP BAAN Description Line 1: CONNECTOR 1.25MM 2 PIN SMT R.A Product Type: XE0 BAAN Description Line 2: SINGLE ROW 1.
PAGE 33
BOM 1008015-002 Rev A5 Device 92984 Qty 1 Sorted By BAAN Number Description RESISTOR SMT 1206 250MW 100R 5% Process Code: CMP BAAN Description Line 1: RESISTOR .
PAGE 34
BOM 1008015-002 Rev A5 Device 94724 Qty 1 Sorted By BAAN Number Description IC INTERFACE SMT SOIC8 Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group ICT Reference Designators: 94751 0.
PAGE 35
BOM 1008015-002 Rev A5 Device 96321 Qty 6 Sorted By BAAN Number Description FER, 220R@100MHZ,6A,SMT,0805 Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group FER Reference Designators: 96331 1 CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group FER CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group FER CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line
PAGE 36
BOM 1008015-002 Rev A5 Device 97234 Qty 4 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 27R4 OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES Reference Designators: 97236 1 CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES 97248 CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES 97256 CMP BAAN Description Line 1: Product Type: XE0
PAGE 37
BOM 1008015-002 Rev A5 Device 97272 Qty 23 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 1K00 OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES Manufacturer VISHAY RES SMT 0402 1/16W 1K00 OHM 1% Reference Designators: 97273 1 R192, R317, R318, R319, R363, R364, R365, R366, R373, R374, R375, R376, R377, R378, R379, R381, R382, R383, R387, R604, R615, R616, R62 RESISTOR SMT 0402 1/16W 1K10 OHM ±1% Process Code: CMP BAAN D
PAGE 38
BOM 1008015-002 Rev A5 Device 97296 Qty 146 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 10K0 OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES Manufacturer VISHAY RES SMT 0402 1/16W 10K0 OHM 1% Reference Designators: 97299 1 R125, R127, R128, R129, R134, R136, R137, R139, R142, R145, R149, R153, R156, R164, R165, R166, R180, R181, R182, R184, R185, R186, R187, R188, R190, R193, R197, R200, R201, R202, R203, R204, R205,
PAGE 39
BOM 1008015-002 Rev A5 Device 97316 Qty 1 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 68K1 OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES Reference Designators: 97320 77 Manufacturer VISHAY RES SMT 0402 1/16W 68K1 OHM 1% RESISTOR SMT 0402 1/16W 100K OHM ±1% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES 1 RES SMT 0402 1/16W 100K OHM 1% R103, R104, R105,
PAGE 40
BOM 1008015-002 Rev A5 Device 97370 Qty 5 Sorted By BAAN Number Description CAPACITOR CERAMIC SMT COG 0402 50V 18P ±5% Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group CAP Reference Designators: 97371 39 Manufacturer MURATA Part Number GRM36COG180J050AD AVX 4025A180JAT2A MURATA GRM36COG101J050AD MURATA GRM36X7R103K016AD MURATA GRM36X7R102K050AD MURATA GRM36X7R472K025AD CAP CER SMT 18P 50V 5% 0402 C71, C72, C73, C74, C75 CAPACITOR CE
PAGE 41
BOM 1008015-002 Rev A5 Device 97453 Qty 21 Sorted By BAAN Number Description RESISTOR SMT 0402 1/16W 0R0 OHM JUMPER Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group RES RES SMT 0402 1/16W 0R0 OHM Reference Designators: 97467 1 R138, R171, R172, R173, R214, R234, R239, R249, R392, R395, R398, R399, R410, R45, R587, R588, R592, R601, R608, R609, R611 IC, LVCMOS, QUAD BUF, HI-Z PWR DOWN, 5V-TOL Process Code: CMP BAAN Description Line 1: Product
PAGE 42
BOM 1008015-002 Rev A5 Device 97648 Qty 1 Sorted By BAAN Number Description DIODE POWER SCHOTTKY 40V 3A SMT Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group DIO Reference Designators: 97661 2 CMP BAAN Description Line 1: INDUCTOR SMT 10UH 20% SHIELDED Product Type: XE0 BAAN Description Line 2: 1.
PAGE 43
BOM 1008015-002 Rev A5 Device 97857 Qty 1 Sorted By BAAN Number Description IC INTERFACE TRANSCEIVER RS232D 3TX_5RX 120KBPS 3_3/5V LO_PWR I-TEMP SSOP28 Process Code: CMP BAAN Description Line 1: IC RS232 TRANSCEIVER 3TX_5RX Product Type: XE0 BAAN Description Line 2: 120KPS 3_3/5V I-TEMP SSOP28 Item Group ICT Reference Designators: 97862 1 INTERSIL ICL3243IA MAXIM MAX3243EEIA VISHAY CRCW04029313F? AVX KYOCERA CR05-9313F-? Process Code: CMP BAAN Description Line 1: RESISTOR 1/16W 93
PAGE 44
BOM 1008015-002 Rev A5 Device 97871 Qty 221 Sorted By BAAN Number Description CAPACITOR CERAMIC SMT 0402 X7R 16V 100NF ±15% Process Code: CMP BAAN Description Line 1: CAPACITOR 16V 100NF ±15% Product Type: XE0 BAAN Description Line 2: CERAMIC SMT 0402 X7R Item Group CAP Part Number C0402X7R160-104E Reference Designators: 97872 13 C105, C1118, C1119, C1120, C1121, C1124, C1125, C1127, C1128, C1129, C127, C128, C138, C139, C142, C143, C145, C147, C162, C163, C164, C165, C166, C167, C168, C16
PAGE 45
BOM 1008015-002 Rev A5 Device 98152 Qty Sorted By BAAN Number Description IC POWER SWITCH 1.5A HIGH SIDE 5V SO-8 2 Process Code: CMP BAAN Description Line 1: Product Type: XE0 BAAN Description Line 2: Item Group ICT Reference Designators: 98153 CMP BAAN Description Line 1: IC POWER SWITCH 1.
PAGE 46
C A D B Special Component Detail Related Reference Designator PCB1 BaaN P/N Description 1008021 Qty PCB 8525 KEYBOARD 68 KEY 1 ADH1 94751 GE SILICONE RTV 162 NON CORROSIVE 0.001 LBL1 95565 LABEL 0.25" X 0.25" WHITE 1 LBL2 1008087 LABEL BLANK PCA 0.25"X1.0" WHITE MYLAR 0.
PAGE 47
C A D B 3V3 3V3 PROGRAMMING INTERFACE 0.100" SPACING C8 97871 100N ±15% 16V C7 97871 100N ±15% 16V Layout the same as 7535 keyboard.
PAGE 48
C A D B ~BLUE,~ENTER,~SPACE HOTKEYS ~SPACE ~BLUE ~ENTER 1 2 2 SPACE 2 SPACE SPACE 2 2 SPACE BLUE 2 ENTER 2 ENTER 2 ENTER 1 SW9 1 1 1 1 SW3 SW33 SW70 SW73 ROW[9:0] SW24 1 D 1 SW19 1 SW83 1 D D ROW[9:0] 2 SW1 ESC F2 2 2 2 2 SW72 SW2 SW4 F4 F6 2 SW5 SW6 F8 1 F10 1 1 1 1 1 ROW0 2 2 2 SW12 SW7 2 SW10 TAB 2 2 2 2 SW8 W SW13 R I 1 1 1 1 1 1 2 2 SW61 SW14 SW11 Y 9 7 P 1 1 ROW1 2 2 KEYBOARD MAPPING - 8525 QWERTY 2 SW63
PAGE 49
C A D B 3V3 TP56 TP128 C30 93187 10N 10% 50V 1 2 D 1 C12 C23 97871 1U0 100N 9007495 ±15% 16V 1 2 TP129 D D 3V3_LED TP61 TP126 C13 97871 100N ±15% 16V 1 2 D 1 TP127 C29 93187 10N 10% 50V External Keyboard Components D Not Populated on Internal keyboard TP131 TP85 TP130 3V3 5V0 TP113 5 VCC GND To PIC Controller GND U6 9000515 NC7SZ125P5X 2 32KHZ 32KHz 3 1 2 1 2 2 4 TP87 FH12-24S-0.
PAGE 50
C A D B 1 1 5V_SWITCHED 3 D6 92642 MMBD914 70V_225MA 5V_SWITCHED 1 L1 9002928 DR125-471 470U 1.02A 20% 1 D 1 TP69 D2 9000909 BAS21 2 1 D3 9000909 BAS21 3 PROTECTION FOR NO-LOAD CONDITION 1 D7 9000517 3 1 TP82 1 3 D5 9000909 BAS21 2 1 C1 95621 100N 20% 50V VSS 7 GP5_OSC1_CLKIN GP2_TOCKI 1 5 1 EL_GP2 3 2 1 GP3_~MCLR_VPP MTG TAB MTG TAB 3 TP80 D 6 D4 9000909 BAS21 TP79 1 4 1 D1 9000909 BAS21 3 R25 97320 100K 0.
PAGE 51
A B C D 1 1 8530 - DISPLAY TRANSITION BOARD; SHARP LQ104S1DG21 COLOUR LCD SCHEMATIC INDEX 2 Page 2: Main Logic Board (MLB) Interface LCD Power Control REFERENCE DESIGNATOR BaaN P/N REV PCB1 1008461-200 A PCB DISPLAY TRANSITION BOARD, 8530 LCD 1 DOC1 1008460-200 A DOC PCB ARTWORK 8530 DTB COLOUR DISPLAY TRANSITION BD 0 DOC2 1008463-200 A DOC PCB ASSY DWG 8530 COLOUR DISPLAY TRANSITION BOARD 0 DOC3 1008464-200 A DOC SCHEMATIC 8530 COLOUR DISPLAY TRANSITION BOARD 0 DOC4 1010084
PAGE 52
A B C D I2C_SDA,I2C_SCL TP_DCLK,TP_DIN,TP_DOUT,~TP_CS,~TP_IRQ,TP_BUSY,~TP_INSTALLED,DTB_PU_DRIVE TP_INTERFACE FPDAT_[17:0] 13806_LCD_DATA 1 1 FPFRAME,FPLINE,FPSHIFT,DRDY,VSH_EN,VGH_EN,VGL_EN 13806_LCD_CTRL J1 52760-1209 9002921 1 FPDAT_7 3 5 FPDAT_14 7 FPDAT_16 11 9 13 FPDAT_3 15 17 FPDAT_5 19 21 FPDAT_12 23 25 FPDAT_1 27 29 FPDAT_9 31 33 FPDAT_17 35 2 37 FPFRAME 39 41 FPDAT_6 43 45 DRDY 47 49 I2C_SDA 51 53 I2C_SCL 1 D R5 16K2 9001574 2 55 TP17 57 LCD_TYPE DISP
PAGE 53
A B C D 1 DTB_PU_DRIVE 3V3_STANDBY TP51 R11 10R0 97224 1 TS_P3V3 2 C24 100N 97871 1 2 D DGND C1 10U 9003429 1 2 D C25 10N 97372 1 2 D DGND C26 100N 97871 1 2 D DGND DGND 2 R10 100K 97320 650 UA MAX. 3 UA MAX. IN PWR DN.
PAGE 54
A B C D FPDAT_[17:0] 13806_LCD_DATA FL1 BLM15AG700PN1 9001853 TP59 FPDAT_6 1 FPDAT_7 LCD_3V3 2 FL2 BLM15AG700PN1 9001853 TP60 1 TP121 1 TP102 FL29 BLM21PG221SN1? 96321 TP66 1 FL3 BLM15AG700PN1 9001853 1 6 5 2 3 4 CN6 97622 100P 1 1 2 TP67 C32 100N 97871 1 2 C2 10U 9003429 D DGND 2 D DGND D FPDAT_8 7 1 SHARP_LCD_P3V3 2 2 TP61 8 2 DGND R17 TP105 0R0 97453 1 FL4 BLM15AG700PN1 9001853 FPDAT_14 1 BLUE_4 FL5 BLM15AG700PN1 9001853 1 BLUE_2 C34 2 100P 97371 1 2
PAGE 55
C A D B Special Component Detail 8525/8530 VEHICLE MOUNT COMPUTER Related Reference Designator PCB1 1 MAIN LOGIC BOARD BaaN P/N 1008011 Description Qty PCB 8525 MAIN LOGIC BOARD 1 CON1 9003441 CONNECTOR DOUBLE SLOT CARDBUS EJECTOR REVERSE TYPE 2MM STANDOFF 1 SCR1-SCR4 9002961 SCREW M2 X 20 PAN HEAD 4 SCR5,SCR6 9001802 SCREW M2 X 8 CHEESE PHIL 2 NUT1- NUT6 95257 NUT M2 PCMCIA 6 WRS1-WSR4 9004474 M2 LOCKWASHER.
PAGE 56
C A FL4 98136 BLM21A102S? 200MA TP23 CPU_PLL_VCC C182 97871 100N ±15% 16V D A[25:0] A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20 1 A21 2 A22 2 1 A23 C134 94054 1U0 ±10% 16V 1 A24 2 A25 1 C183 97871 100N ±15% 16V CORE_VDD 1 CORE_VDD 2 1 2 1 1 3V3 2 L6 K10 K8 H10 L9 J7 G9 G7 F11 G1 H2 H1 H6 J6 J5 J3 J1 K1 K2 K5 K6 L1 L3 M1 M3 N3 P1 R1 P2 R3 T4 R5 P5 P4 CLK_PXA_EXTAL K16 K15 F13 G13 BOOT_SEL0 D D
PAGE 57
C D B 3V3 SDRAM_CTL R216 97296 10K0 0.
PAGE 58
C A D B 1 TP135 1 1 D[31:0] U80 PI3B32X384BX 9004514 BD[31:0] 3V3 D0 3 D1 4 D2 7 D3 8 D4 11 A0 1 R631 97296 10K0 0.
PAGE 59
C A D B 3V3_STANDBY 2 R231 97296 10K0 ±1% 0.
PAGE 60
C D CFG_DATA ~S2_OE ~S2_IORD ~S2_IOWR ~S2_WE S2_RDY S2_RST ~S2_CE[2:1] 1 1 CFG_DONE ~S2_WAIT 2 R55 97320 100K 0.
PAGE 61
C A D B 3V3 BYPASS CAPS FOR 5V TOLERANT I/O BANKS 5V C227 97871 100N ±15% 16V 1 2 5V C425 97372 10N ±5% 16V 1 2 C226 97871 100N ±15% 16V 1 2 1 2 C421 97372 10N ±5% 16V D 1 2 TP116 TP119 8 5 D D D D 3 CF_3V3EN 2 CF_5VEN 1 VCC_INT VCC_B0 3V3 3V3 2 1 2 C259 97871 100N ±15% 16V 1 2 C258 97871 100N ±15% 16V 1 2 C257 97372 10N ±5% 16V 2 D C264 97871 100N ±15% 16V 1 2 1 2 C263 97871 100N ±15% 16V 1 2 C262 97871 100N ±15% 16V 1 2 C220 97871 100N ±15% 16V 1 2 1 2 C
PAGE 62
C A D B 3V3_SWITCHED 3V3_SWITCHED C449 97871 100N ±15% 16V TP401 2 TP383 2 TP672 TP826 1 TP829 4 1 TP830 S2_CARD_ERROR 2 1 1 U70 5 NC7S02M5X 9002949 D TP831 D 2 3V3_SWITCHED 3V3_SWITCHED TP804 C447 97871 100N ±15% 16V 1 2 2 1 TP675 2 C405 97871 100N ±15% 16V 1 TP674 2 U68 5 NC7S86M5X 9002948 2 U73 NC7S04M5 97125 D 4 U69 5 NC7S02M5X 9002949 TP811 2 TP812 4 ~S2_CARD_DETECTED 1 TP813 3 3 4 TP814 TP382 2 TP381 TP815 D D 1 TP818 3 TP819 D CF_VCC TP820
PAGE 63
C A D B TP1077 TP773 TP771 E6 1 3V3 2 OSCO ~MQ1188_CS2 K8 ~MOE L9 ~PWE K6 TP772 L8 DQM1 M7 MRDY L7 ~MQ1188_IRQ K9 ~CS OSCR CLK_3M6864 AVDD18 ~BE0 AVDDP1 ~BE1 AVDDP2 RDY AGND18 ~IRL AGNDP1 H3 2 D1 1 182K ±1% 0.
PAGE 64
C A D B 1 1 TP335 1 3V3 1 2 SS_CLK_48MHZ 2 R606 97453 0R0 0.063W ±5% 1 R590 97296 10K0 0.063W ±1% 2 TP3 1 ~SS_CLK_PWR_EN 1 3 TP676 1 2 C450 97871 100N ±15% 16V 1 C356 97372 10N ±5% 16V 2 1 2 C137 97371 100P ±5% 50V 1 2 2 C451 97871 100N ±15% 16V 2 TP404 TP677 X6 ABMC2-10.0000MHZ-18-60-D 9003435 3V3 1 D R607 97453 0R0 0.063W ±5% 1 4 3 1 2 2 R92 97453 0R0 0.063W ±5% 1 R610 97453 0R0 0.063W ±5% 1 5 D 2 1 Q35 9000501 BSS84 1 2 1 C355 9000585 4P7 ±2.
PAGE 65
C A D B BA[25:0] BD[31:0] TP542 TP696 1 TP690 TP689 TP688 TP687 TP692 TP691 TP686 TP685 TP693 TP694 TP684 TP695 TP683 TP552 TP551 TP550 TP549 TP545 TP543 TP860 1 BA22 1 BA21 1 BA20 1 BA19 1 BD30 BD29 BD28 BD27 BD26 1 1 1 1 1 1 TP728 TP727 U13 9002773 S1D13806F00A100 BA[25:0] TP726 BA20 6 BA19 7 BA18 8 BA17 9 BA16 10 BA15 11 BA14 12 BA13 13 BA12 14 BA11 15 TP725 TP724 TP723 BA18 1 BA17 1 BA16 1 BA15 1 BA14 1 BA13 1 BA12 1 BA11 1 BA10 1 BA9 1 BA8 1
PAGE 66
C A D B 5V 3V3 3V3_SWITCHED TP1160 R268 97453 0R0 0.063W ±5% 3V3 1 1 1 2 C334 97871 100N ±15% 16V 1 2 C128 97871 100N ±15% 16V 1 2 C407 97871 100N ±15% 16V 1 2 C1103 97372 10N ±5% 16V 1 2 1 2 C308 9003429 10U +80%/-20% 16V C406 97871 100N ±15% 16V C409 978711 100N ±15% 16V 2 1 2 1 2 C1102 97372 10N ±5% 16V 1 2 1 2 C88 9003429 10U +80%/-20% 16V C1105 97372 10N ±5% 16V 1 2 D C408 97871 100N ±15% 16V 1 2 1 R618 97320 100K 0.
PAGE 67
C A D B CHARGER BUCK BATTERY CHARGER 1 1 INRUSH LIMITER VBAT_MAIN_IN TP201 1 R17 1 2 TRACEWIDTH=150 TRACEWIDTH=150 EXTERNAL_PWR CHRG_PWR_IN 9000552 0R039 ±1% 1W TP253 TP216 TRACEWIDTH=150 1 1 TRACEWIDTH=150 SYS_PWR_IN 5 6 7 8 1 2 3 5 6 7 8 2 1 2 3 3 D1 97707 12V 12V_350MW 1 VREF TP231 D C20 97764 1U0 ±20% 25V 1 D 2 GND D 1 1 R196 97248 100 0.063W ±1% 2 5 1 1 TP225 1 2 1 2 R154 97276 1K50 0.
PAGE 68
C A D B TRACEWIDTH=150 SYS_PWR_IN PEAK RIPPLE = 1.75A 2 C4 9003428 10U ±10% 50V 2 C5 9003428 10U ±10% 50V 2 1 C6 9003428 10U ±10% 50V 2 2 R399 97453 0R0 0.
PAGE 69
C A D B 5V TP155 1 2 1 TP158 U24 MIC5236-5BMM 9002955 SYS_PWR_IN 2 2 R91 97320 100K 0.063W ±1% 2 VIN 1 5V_STANDBY 1 TRACEWIDTH=30 3 VOUT 5V_STANDBY 1 C29 97764 1U0 ±20% 25V 1 D16 94543 MBR0530T 30V_500MA 1 4 5 6 7 8 1 D ENABLE TP159 GND5 GND6 GND7 GND8 C104 94054 1U0 10% 16V 1 1 ~ERR 2 D D 5V STANDBY REG ±1% 0.
PAGE 70
C A D B U53 98153 TPS2022D 1A_5V 5V_SWITCHED 3V3 2 TP385 1 1 1 6 C318 97871 100N ±15% 16V 1 2 C2+ 1 1 C2- V- 12 T2IN COM1_RXD 10 R2OUT 2 7 T2OUT 8 COM1_TX_DATA R2IN 9 COM1_RX_DATA TP419 R120 97320 100K 0.063W ±1% D 2 Q28 97634 FDV303N 25V_350MW 3 R119 97320 100K 0.
PAGE 71
C A R285 97453 0R0 0.063W ±5% 1 TP206 5V_SWITCHED 2 3 FL14 9000989 NEF13PT222Z1E9 2 2 1 1 C333 97871 100N ±15% 16V 2 1 5V_SWITCHED TP460 1 1 TP739 1 ~USB_RESET U44 ISP1122ABD 98171 1 2 2 ~OC1 TP746 2 17 ~OC5_~GOC XTAL1 15 DM1 XTAL2 TP160 DP2 1 24 25 D 1 TP207 DP3 DM4 VREG3_3 DP4 DM5 1 10 DP5 D 18 OPTION_SCL ~PSW2_~GL2 1 2 19 R355 97232 P0RT3_USB_HOST_PLUS 1 2 22R1 ±1% 0.
PAGE 72
C A D B 3V3 C423 97871 100N ±15% 16V TP362 1 TP405 1 1 TP407 1 TP406 1 C463 97372 10N ±5% 16V 1 U57 97857 SP3243EEA 1 C426 97871 100N ±15% 16V D TP376 C422 97871 100N ±15% 16V 1 2 TP365 VDD 28 C1+ 24 C1- TP375 1 2 D 26 TP374 1 1 2 TP364 1 TP373 1 EXT_COM2 C424 97871 100N ±15% 16V 1 1 27 TP377 1 1 TP378 1 3 V- TP366 2 C2- TP371 C142 97871 100N ±15% 16V 1 1 C2+ 1 TP367 V+ TP363 2 2 1 TP379 2 1 1 TP372 1 TP370 1 COM2 TP369 1 1 COM2_TXDATA 9 T1O
PAGE 73
C A D B 9000989 6A NFE31PT222Z1E9 1 IN 2 OUT GND 3 HEATER_POWER FL15 TP128 D 1 DC_PWR_IN DC_POWER_IN 1 1 TRACE WIDTH 150 IN 2 OUT 2 TRACEWIDTH=150 FL3 C9 9003428 10U +80%/-20% 50V GND GND 4 D TP752 2 5 TP480 9000989 6 6A 7 1 TRACEWIDTH=100 SMBUS_CLK 8 IN 9 C153 97371 100P ±5% 50V 1 SMBUS_DATA 10 BAT_NEG 2 43045-1021 9002940 GND 3 1 1 2 3 C36 9003433 2U2 ±10% 50V EXTERNAL_PWR EXT_PWR 5 6 7 8 1 D50 9000559 MMBZ5248BLT1 18V_225MW 1 Q26 9002936 FDS6675 30V_1
PAGE 74
C A D B 5V_STANDBY 5V_STANDBY TP494 C429 97871 100N ±15% 16V 2 IRQ_BUS TP544 94724 DS8921AM 5 D 2 ~KBD_IRQ 6 TP482 7 2 TP483 2 R211 97296 10K0 0.063W ±1% R68 95202 100R 0.063W 1% MTG TAB 26 MTG TAB 25 8 2 4 1 TP541 3 R323 4K70 97288 63MW 1% TP758 VCC 1 GND 1 5 2 R201 97296 10K0 0.
PAGE 75
C D B 3V3 R344 97296 10K0 0.063W ±1% 2 3V3 R343 97296 10K0 0.063W ±1% 2 2 3V3 R342 97296 10K0 0.063W ±1% R629 97296 10K0 0.063W ±1% 1 1 3V3 2 1 R624 97296 10K0 0.063W ±1% 1 1 JTAG_BUS R623 97296 10K0 0.063W ±1% TP564 3V3 1 2 5V 1 1 TP567 3V3 2 A 1 C39 9003429 10U +80%/-20% 16V 2 2 1 1 C38 95621 100N ±20% 50V 1 D 1 ~TRST_CPU J11 9003444 FLE-110-01-G-DV-A R191 TDO_FPGA 5V 2 22R1 ±1% 0.
PAGE 76
C A D B TP142 1 HEATER_POWER 2 C19 9003428 10U ±10% 50V 1 2 C103 95621 100N ±20% 50V 2 1 1 1 R197 97296 10K0 0.063W ±1% 1 D 1 2 3 Q23 97634 FDV303N 25V_350MW 3 TP126 5 6 7 8 TP144 1 4 Q36 9002936 FDS6675 30V_11A TP145 1 1 MLB_HEATER_EN 2 1 MLB_HEATER_POWER 2 D 1 1 R64 97320 100K 0.
PAGE 77
A B C D 1 1 8530 PORT EXTENDER BOARD CONFIGURATION DETAIL BaaN P/N 1008735-100 SCHEMATIC INDEX Page 3: 8525/8530 AUXILLARY AND COM2 PORTS INTERFACE 8525/30 PORT EXTENDER BOARD PCB ASSEMBLY REFERENCE DESIGNATOR BaaN P/N DOC1 1008730-100 DOCUMENT ARTWORK PORT_EXTENDER BOARD 8525/30 0 DOC2 1008733-100 DOC PCB ASSY DWG PORT EXTENDER BOARD 8525/30 0 DOC3 1008734-100 DOC SCHEMATIC PORT_EXTENDER BOARD 8525/30 0 PCB1 1008731-100 PCB PORT_EXTENDER_BOARD 8525/30 1 NUT1 9004440 PEM NUT M
PAGE 78
A B C D 1 1 HI DENSITY DB-26 FOR EXTERNAL KEYBOARD J3 32KHZ_TX_B 1 L9 DLP31SN551SL2? 96331 2 9002944 32KHZ_TXD_B 1 32KHZ_TXD_A 2 KBD_INTB 32KHZ_TX_A TP1 3 KBD_INTA TP2 J5 FH12-24S-0.
PAGE 79
A B C D F7 0R35 93610 L4 BLM21PG221SN1? 96321 TP20 EXT_5V_SW 1 TP46 1 T D DGND BEEPER 2 L30 BLM10A121SPT 96350 1 MIC_GND J4 1 1 EXT_5V_SW 2 EXT_5V_SW 3 MIC_IN 4 SPEAKER+ 1 MIC_GND 2 5 TP24 SPEAKER+ 6 L28 BLM10A121SPT 96350 SPEAKER- SPEAKER- 7 1 GND 8 2 P4_USB_HOST+ 9 TP25 BEEPER_OUT P4_USB_HOST- 10 L27 BLM10A121SPT 96350 FLEX FROM MLB 1 9002934 2 L29 BLM10A121SPT 96350 TP23 TP47 GND 11 1 MEDIAQ_USB_DEV+ 12 2 MEDIAQ_USB_DEV- 13 TP26 GND 14 P3_USB_HO
PAGE 80
L10 L6 R105 L8 L7 L3 R103 L9 U20 FL4 C320 R294 R214 C134 U1 C183 C102 R203 J2 C184 C217 C374 U67 R224 C390 U22 R166 R237 R180 R125 R218 R221 C50 R65 R35 R49 R174 R53 R54 R175 R101 R150 R153 R212 R213 R207 R628 C430 R56 R208 U12 FL9 Q28 Q30 R176 C182 C286 C147 R120 U53 U46 R119 C14 C15 X4 R381 R287 P2 R104 R108 R296 C92 C322 R116 R117 R266 R137 R139 C323 U17 R110 C11 R286 U32 R168 L5 R586 C10 D39 D38 C23 Q60 R97 U54 L25 U18 R4
PAGE 81
R474 R371 R386 R401 R469 R454 R449 R439 R444 R471 R461 R431 R429 R459 R339 R406 R256 R255 R427 R268 C410 FL13 C1097 Q82 R389 R402 C296 C459 R460 Q79 R472 R407 R418 R354 R434 R324 R428 R329 C294 R432 R161 R458 R253 R372 R448 R468 R331 C104 R259 C73 R257 R550 R258 R86 C305 R18 C60 D20 R336 R326 R40 R592 R452 R37 R159 R284 R160 U16 C141 R437 Q39 D36 C70 C47 C95 C133 C33 C94 C48 D31 R399 C32 C157 C61 R147 C31 R591 R457 D16 C68 D29 C49
PAGE 82
TP432 TP438 TP412 TP398 TP345 TP350 TP76 TP394 TP509 TP343 TP348 TP386 TP344 TP423 TP416 TP417 TP396 TP88 TP393 TP400 TP513 TP151 TP384 TP411 TP410 TP41 TP424 TP422 TP39 TP419 TP308 TP420 TP38 TP421 TP26 TP773 TP860 TP338 TP35 TP807 TP18 TP93 TP22 TP40 TP11 TP714 TP808 TP683 TP716 TP809 TP810 TP710 TP817 TP403 TP715 TP79 TP332 TP85 TP55 TP91 TP34 TP828 TP331 TP12 TP856 TP78 TP728 TP551 TP727 TP104 TP868 TP862 TP688 TP64 TP684 TP193 TP793 TP147 T
PAGE 83
TP430 TP1161 TP127 TP752 TP749 TP774 TP779 TP167 05-Oct-2005 TP751 TP1160 TP778 TP780 TP750 TP1159 TP775 TP1150 TP445 TP256 TP1154 TP777 TP481 TP447 TP254 TP155 TP289 TP288 TP287 TP290 TP227 TP781 TP159 TP296 TP286 TP282 TP280 TP281 TP269 TP158 TP439 TP145 TP292 TP157 TP277 TP324 TP81 TP759 TP664 TP273 TP272 TP663 TP322 TP279 TP536 TP629 TP327 TP214 TP216 TP501 TP541 TP500 TP482 TP310 TP253 TP219 TP539 TP540 TP130 TP627 TP239 TP246 TP495 TP538 TP633
PAGE 84
8 7 6 5 24.576 Mhz Xtal DAC MIC PRE-AMP AUDIO CODEC AC'97 WM9708 ADC BEEPER VOLUME 1 NAND FLASH CONTROL BUS TO NAND FLASH COM2 PWR EN COM2 EN TO COM 2 TRANSCEIVERS MMC Multi Media Card (20Mbps) PC/CF CARD ERROR PCMCIA INTERFACE Memory INTERFACE RTC Ricoh RV5C386A CF CARD DETECT 32D, 26A OE C LOGI C CARD DETECT PC CARD SLOT 0 (3/5V) PC CARD DETECT GPIO IRQ_KBD FROM PCON 32 KHz XTAL TB2 Timer/PW measure 16-bit TA1 Timer/PWM 16-bit Undecoded External Scanner I/F 3.
PAGE 85
8 7 6 5 H 3 2 1 H 10Mhz XTAL FROM PXA-255 G 4 FROM PXA-255 LCD CONTROLLER S1D13806 MEMORY CONTROL LCD_CS ADDRESS BUS [A18:1] SS_PWRDN SS_CLK_PWRDN PROGRAMMABLE SPREAD SPECTRUM MULTIPLIER CPU Interface 48 MHZ FROM PXA255 FROM PXA255 FROM PXA255 LCD Display 8525 8.8" (Colour TFT) 640H x 240W 3.
PAGE 86
LQ104S1DG21 TFT-LCD Module (Model Number: LQ104S1DG21) Specifications Spec No.
PAGE 87
PREPARED BY : DATE SPEC No. LD-14304 FILE No. APPROVED BY : DATE ISSUE : Apr.10.2002 AVC LIQUID CRYSTAL DISPLAY GROUP SHARP CORPORATION PAGE : 15 pages APPLICABLE GROUP AVC LIQUID CRYSTAL DISPLAY SPECIFICATION GROUP DEVICE SPECIFICATION FOR TFT-LCD Module MODEL No. LQ104S1DG21 □ CUSTOMER'S APPROVAL DATE PRESENTED BY BY M.
PAGE 88
LD-14304-1 1. Application This specifications applies to color TFT-LCD module, LQ104S1DG21. These specifications sheets are the proprietary product of SHARP CORPORATION(”SHARP) and include materials protected under copyright of SHARP. Do not reproduce or cause any third party to reproduce them in any form or by any means, electronic or mechanical, for any purpose, in whole or in part, without the express written permission of SHARP .
PAGE 89
LD-14304-2 3. Mechanical Specifications Parameter Specifications Unit Diagonal cm Display size 26 (10.4") Active area 211.2(H)×158.4(V) mm Pixel format 800(H)×600(V) pixel (1 pixel＝R＋G＋B dots) Pixel pitch 0.264(H)×0.264(V) Pixel configuration R,G,B vertical stripe Display mode Normally white Unit outline dimensions *1 246.5(W)×179.4(H)×15.5max(D) (excluding backlight cables) Outline dimensions is shown in Fig.
PAGE 90
LD-14304-3 Pin No.
PAGE 91
LD-14304-4 【Note3】R/L=High､U/D=Low R/L=Low､U/D=Low Please do not use this terminal by “open”. 【Note4】R/L=High､U/D=High R/L=Low､U/D=High Please do not use this terminal by “open”. 4-2. Backlight driving Connector name :CN2、CN3 Used connector : BHR-03VS-1(JST) Corresponding connector :SM02(8.0)B-BHS(JST) Pin no. Symbol 1 ＶHIGH 2 NC 3 ＶLOW Function Power supply for lamp Cable color (High voltage side) Pink This is electrically opened. Power supply for lamp (Low voltage side) White 5.
PAGE 92
LD-14304-5 6. Electrical Characteristics 6-1.TFT-LCDpaneldriving Ta＝25℃ Parameter Supply voltage Power Supply Current dissipation Symbol Vcc Permissive input ripple voltage Input voltage (Low) Input voltage (High) Input current (low) Input current (High) Min. Typ. Max. +3.0 +3.3 +5.0 +5.5 Unit V Remark 【Note1】 Icc － 310 450 ｍＡ Vcc=3.3V【Note2】 Icc VRF VIL VIH －－－ 330 －－－ 470 ｍＡ Vcc=5.0V【Note2】 100 0.9 － mVp-p ＶＶ－ 1.0 μＡ VI=0V 【Note4】 Vcc=5.0V 【Note3】 IOL1 2.
PAGE 93
LD-14304-6 6-2. Backlight driving The backlight system is an edge-lighting type with twin CCFT (Cold Cathode Fluorescent Tube). The characteristics of single lamp are shown in the following table. Parameter Lamp current Lamp power consumption Lamp frequency Kick-off voltage Symbol IL PL FL Vs Lamp life time LL LL Min. 3.5 － 40 －－－ 50000 30000 Typ. 6.0 2.8 60 －－－－－ Max. 7.
PAGE 94
LD-14304-7 7. Timing Characteristics of input signals Timing diagrams of input signal are shown in Fig.2. 7-1. Timing characteristics Parameter Clock Data Horizontal Symbol Min. Typ. Max. Unit Remark Frequency 1/Tc － 40.0 42.0 MHz － High time Tch 6 －－ ns － Low time Tcl 6 －－ ns － Duty ratio Th/T 40 50 60 % － Setup time Tds 3 －－ ns － Hold time Tdh 5 －－ ns － Cycle TH 20.8 26.4 － μs － 832 1056 － clock － sync.
PAGE 95
TH H I V (Hsync) L I V L I V L I V Horizontal Sync.signal THp THc *Only when enable terminal is fixed “LOW” T H I V Tc Tch Tcl Th V 7 . 1 C2* C88* Tds Tdh Number of clock Data signal (R0～R5,G0～G5, B0～B5) Horizontal invalid data period V 7 . 1 C1* L I V L I V L I V L I V L I V Clock signal (CK) D1 D2 Number of H-data line D3 THe D799 D800 Horizontal invalid data period THd H I V Data Enable signal (ENAB) L I V Tes Tep TV H I V TVp L I V L I V Vertical Sync.
PAGE 96
LD14304-9 8.
PAGE 97
LD14304-10 9. Optical Characteristics Parameter Ta=25℃, Vcc=+3.3V or +5V Symbol Condition Min Typ Max Unit Remark CR≧10 60 70 － Deg. 【Note1,4】 Viewing Horizontal θ21,θ22 Angle Vertical θ11 35 40 － Deg. θ12 55 70 － Deg. θ=0° 150 －－－ Best Viewing － 300 －－－ 20 －ｍｓｍｓ Range Contrast ratio CR 【Note2,4】 Angle Response Rise τr Time Decay τd － 40 －ｘ－ 0.313 －ｙ－ 0.329 －ＹＬ 280 350 － cd/m2 －－ 1.45 －【Note5】－ 35 － Deg.
PAGE 98
LD14304-11 【Note1】Definitions of viewing angle range: 【Note2】Definition of contrast ratio: The contrast ratio is defined as the following. Luminance (brightness) with all pixels white Contrast Ratio (CR) ＝ Luminance (brightness) with all pixels black 【Note3】Definition of response time: The response time is defined as the following figure and shall be measured by switching the input signal for "black" and "white" . 【Note4】This shall be measured at center of the screen.
PAGE 99
LD14304-12 10. Display Quantity The display quality of the color TFT-LCD module shall be in compliance with the Incoming Inspection Standard. 11．Handling Precautions a) Be sure to turn off the power supply when inserting or disconnecting the cable. b) Be sure to design the cabinet so that the module can be installed without any extra stress such as warp or twist. c) Since the front polarizer is easily damaged, pay attention not to scratch it. d) Wipe off water drop immediately.
PAGE 100
LD14304-13 13．Reliability test items No. Test item Conditions 1 High temperature Ta= 50℃ ; 95%RH 240h & high humidity storage test (No condensation) 2 High temperature storage test Ta= 70℃ 3 Low temperature storage test Ta= -35℃ 4 High temperature Ta= 40℃ ; 95%RH 240h & high humidity operation test (No condensation) 5 High temperature operation test Ta= 65℃ 240h 6 Low temperature operation test Ta= -10℃ 240h 7 Vibration test Frequency: 10～57Hz/Vibration width (one side):0.
PAGE 101
05-Oct-2005
PAGE 102
05-Oct-2005
PAGE 103
SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE. Suggested applications (if any) are for standard use; See Important Restrictions for limitations on special applications. See Limited Warranty for SHARP’s product warranty. The Limited Warranty is in lieu, and exclusive of, all other warranties, express or implied. ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE WARRANTIES OF MERCHANTABILITY, FITNESS FOR USE AND FITNESS FOR A PARTICULAR PURPOSE, ARE SPECIFICALLY EXCLUDED.
PAGE 104
Appendix 2 Test Report Serial Number RFI/EMCE1/RP47590JD01A 05-Oct-2005
PAGE 105
TEST REPORT FROM RFI GLOBAL SERVICES LTD Test of: Psion Teklogix. 8530 Venicle Mount Computer. To: 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Test Report Serial No: RFI/EMCE1/RP47590JD01A VCA Job No.: EAF067676 This Test Report Is Issued Under The Authority Of Andrew Brown, Operations Manager Tested By: Steven White Checked By: Claire Ashman.
PAGE 106
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 2 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions This page has been left intentionally blank.
PAGE 107
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 3 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Table of Contents 1. Client Information .............................................................................................................4 2. Equipment Under Test (EUT) ...........................................................................................5 3.
PAGE 108
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 4 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 1. Client Information 1.1. Applicant Company Name: Psion Teklogix Address: 2100 Meadowvale Blvd. Mississauga, ON, L5N 7J9, Canada Contact Name: George Tao Telephone No: 905-812-6200 ext. 3705 E-mail: George.tao@psionteklogix,com 1.2.
PAGE 109
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 5 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 2. Equipment Under Test (EUT) The following information (with the exception of the date of receipt) has been supplied by the client: 2.1.
PAGE 110
RFI GLOBAL SERVICES LTD Test of: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 6 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions To: 2.5. Additional Information Related To Testing Type of ESA: Vehicle Mount Computer Weight: 9.
PAGE 111
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 7 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 2.7.
PAGE 112
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 8 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 3. Test Specification, Methods & Procedures 3.1.
PAGE 113
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 9 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 4. Deviations from the Test Specification None.
PAGE 114
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 10 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 5. Operation of the EUT During Testing 5.1. Operating Conditions The EUT was tested in a normal laboratory environment. During testing, the EUT was powered using a +13.5V and 27V ±10% DC supply with a ripple voltage of less than 1.5%. 5.2.
PAGE 115
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 11 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 6. Summary of Test Results Test Name Section Port Type Compliancy Status Radiated Narrowband Emissions Annex VIII Enclosure Complied Radiated Broadband Emissions Annex VII Enclosure Complied 6.1.
PAGE 116
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 12 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 7. Measurements, Examinations and Derived Results 7.1. General Comments This section contains test results only. Details of the test methods and procedures can be found in section 8 of this report. Measurement uncertainties are evaluated in accordance with current best practice.
PAGE 117
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 13 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 7.2. Test Results 7.2.1. Radiated Narrowband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 12V 7.2.1.1. Plots of the initial scans can be found in appendix 4. 7.2.1.2.
PAGE 118
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 14 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Radiated Narrowband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 12V (Continued) Frequency (MHz) Line Peak Level (dBµV) Limit (dBµV) Margin (dB) Note(s) Result 527.163 Vert. 38.00 55.00 17.00 - Complied 527.163 Horiz. 33.
PAGE 119
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 15 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 7.2.2. Radiated Broadband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 12V 7.2.2.1. Plots of the initial scans can be found in appendix 4. 7.2.2.2.
PAGE 120
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 16 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Radiated Broadband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz) 12V (Complied) Frequency (MHz) Line Quasi Peak Level (dBµV) Limit (dBµV) Margin (dB) Note(s) Result 527.163 Vert. 35.60 65.00 29.40 - Complied 527.163 Horiz. 30.
PAGE 121
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 17 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 7.2.3. Radiated Narrowband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 24V 7.2.3.1. Plots of the initial scans can be found in appendix 4. 7.2.3.2.
PAGE 122
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 18 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Radiated Narrowband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 24V (Continued) Frequency (MHz) Line Peak Level (dBµV) Limit (dBµV) Margin (dB) Note(s) Result 900.000 Vert. 32.20 55.00 22.80 - Complied 900.000 Horiz. 32.
PAGE 123
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 19 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 7.2.4. Radiated Broadband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 24V 7.2.4.1. Plots of the initial scans can be found in appendix 4. 7.2.4.2.
PAGE 124
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 20 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Radiated Broadband Emissions - Electric Field Strength Measurements (Frequency Range: 30 to 1000 MHz): 24V (Continued) Frequency (MHz) Line Quasi Peak Level (dBµV) Limit (dBµV) Margin (dB) Note(s) Result 900.000 Vert. 31.20 65.00 33.80 - Complied 900.000 Horiz.
PAGE 125
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 21 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 8. Measurement Uncertainty No measurement or test can ever be perfect and the imperfections give rise to error of measurement in the results.
PAGE 126
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 22 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 9. Measurement Methods 9.1. Radiated Narrow Band Emissions: Annex VIII. These measurements were performed in accordance with the standard, against appropriate limits for narrow band emissions using an average detector.
PAGE 127
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 23 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions 9.2. Radiated Broad Band Emissions: Annex VII. These measurements were performed in accordance with the standard, against appropriate limits for a quasi peak detector. All measurements were performed with an antenna height of 1.15 m and a measurement distance of 1.
PAGE 128
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 24 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Appendix 1. Test Equipment Used RFI No. Instrument Manufacturer Type No. Serial No.
PAGE 129
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 25 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Appendix 2.
PAGE 130
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 26 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions DRG\47590JD01\001 1.0m high table with earthed metallic top with 50mm spacer if necessary DC Supply LISNs/ Support EUT 100mm 200mm Harness or 1.5m cabling 1.
PAGE 131
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 27 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions DRG\47590JD01\002 Configuration of EUT and Local Support Equipment Teklogix Inc.
PAGE 132
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 28 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Appendix 3.
PAGE 133
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 29 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer.
PAGE 134
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 30 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer.
PAGE 135
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 31 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer. 95/54/EC: 1995 ESA Approval Annex VII and Annex VIII, Emissions Appendix 4.
PAGE 136
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 32 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer.
PAGE 137
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 33 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer.
PAGE 138
RFI GLOBAL SERVICES LTD Test of: To: TEST REPORT S.No. RFI/EMCE1/RP47590JD01A Page 34 of 34 Issue Date: 04 October 2005 Psion Teklogix. 8530 Venicle Mount Computer.