Owner`s manual

9100 Rear Unload - 12 -
TRANSPORTING
WARNING: (TRACTOR POWERED)
INSTALL A SMV EMBLEM ON REAR OF FORAGE
BOX FOR TRANSPORTING ON ROADWAYS.
KEEP THIS EMBLEM CLEAN AND BRIGHT.
FAILURE TO HEED MAY RESULT IN SERIOUS
PERSONAL INJURY OR DEATH.
Be sure and observe that the rear discharge door is
latched closed before traveling on roadways.
If you will travel on public roads you must know all
rules governing such operation. This will include
lighting and brake requirements in addition to traffic
rules. You may also be required to install a safety
chain device on the trailer.
TRACTOR TOWING SIZE REQUIREMENTS
Use the following chart for calculating the minimum
tractor weight.
MATERIAL ESTIMATED WEIGHT PER CUBIC
FOOT
SOURCE: ASAE
NOTE: HEAPED LOADS HAVE SIGNIFICANTLY
HIGHER CAPACITIES.
WARNING: MAKE CERTAIN EVERYONE IS
CLEAR OF EQUIPMENT BEFORE APPLYING
POWER. FAILURE TO HEED MAY RESULT IN
SERIOUS PERSONAL INJURY OR DEATH.
WARNING: (TRACTOR POWERED) DO
NOT TOW
AT SPEEDS IN EXCESS OF 20 MPH.
FAILURE TO HEED MAY RESULT IN SERIOUS
PERSONAL INJURY OR DEATH.
WARNING: YOU MUST OBSERVE ALL
APPLICABLE TRAFFIC LAWS WHEN
TRANSPORTING ON PUBLIC ROADWAYS.
CHECK LOCAL LAWS FOR ALL HIGHWAY
LIGHTING AND MARKING REQUIREMENTS.
FAILURE TO HEED MAY RESULT IN SERIOUS
PERSONAL INJURY OR DEATH.
Operating speed is dictated by the terrain over which
you are traveling. Always use caution. Avoid traveling
on slopes or hills that are unsafe.
CAUTION: FOR TRACTOR TOWED USE
FLASHING WARNING LIGHTS WHEN
TRANSPORTING ON ALL PUBLIC ROADWAYS,
EXCEPT WHEN PROHIBITED BY LAW. CHECK
FOR TRAFFIC CONSTANTLY. BE SURE YOU CAN
SEE THAT NO ONE IS ATTEMPTING TO PASS
YOU AND THAT ALL TRAFFIC IS SUFFICIENTLY
CLEAR FROM YOU BEFORE MAKING ANY
TURNS.
9100 TRAILER REAR BUMPER
(Serial #0991201 & later)
For highway transport of 9100 trailers it is necessary
to adjust the rear bumper to the most rearward
position to comply with the REAR IMPACT
PROTECTION (FMCSR 393.86). For unloading into
baggers the rear bumper is designed to be slid
forward and not interfere with the unloading operation.
(See decal 46-9100-3, on page 10).
MODEL
FORAGE BOX EMPTY
WEIGHT + LOAD = GW
MINIMUM
TRACTOR
WEIGHT UP
TO 20 MPH
9122 6,300 + =
2/3 of box gross
weight
9124 6,600 + =
2/3 of box gross
weight
MATERIAL LBS / CU. FT.
SOYBEANS 47 LBS.
COTTON SEED DRY 20 LBS.
CORN (SHELLED)
45 LBS.
CORN SILAGE 30 LBS.
HAYLAGE 20 LBS.
SAWDUST 17 LBS.