Instruction Manual

8
10- Troubleshooting Tips
A- Engine will not start:
I- Fuel tank may be empty or petcock may be in closed position.
II- Weak or no-spark condition may be caused by a discharged battery, damaged ignition module, or damaged coil. Verify the condition
of components.
III- Spark plug gap may be too wide.
B- Engine will not run at steady speed or rpm:
I- There may be a restriction in fuel supply system (gas tank vent plugged, needle and seat not working properly, etc.)
II- Faulty ignition system. Check for fouled plugs, defective coil, defective electronic module, or improper ignition timing.
GENERAL INFORMATION NOTE: When the motorcycle is not running, the petcock should always be turned o to prevent possible fuel leakage past the
needle and seat.
CONCLUSION
Complete remainder of installation according to the applicable service manuals. Refer to the S&S® 49-State EPA Certied Engine Owner’s Manual for
important information on breaking in the engine.
V124E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 1058 lb (480 kg)
Exhaust Backpressure
Maximum 9.5" H20
Minimum 4.7" H20
V111E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 1058 lb (480 kg)
Exhaust Backpressure
Maximum 9.5" H20
Minimum 4.7" H20
V107E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 8.0" H20
Minimum 2.7" H20
V96E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V89E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V80E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V117E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 1058 lb (480 kg)
Exhaust Backpressure
Maximum 9.5" H20
Minimum 4.7" H20
V113E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 8.0" H20
Minimum 2.7" H20
V100E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 8.0" H20
Minimum 2.7" H20
V93E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V88E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
V79E Specications
Maximum N/V Ratio 43.3
Maximum Vehicle Weight 992 lb (450 kg)
Exhaust Backpressure
Maximum 5.0" H20
Minimum 0.6" H20
ENGINE SPECIFICATIONS