Datasheet

Rest the
back assembly on
2Vz"-wide
spaoers, and
clamp it in
place.
Using
the
shank
holes in
the rear uprights as
guides,
drill
pilot
holes,
and drive
in the
screws.
A
panels
Vc'
10Vz'
1W' 0P
B rear updghts {+"
2{c"
35' 0
C
front
updghts {c"
2{t" 249[' 0
D
upper
rails
{c' 3{+'
10V2' O
E lower rails
{q"
4{+' 10V2'
0
F- brackets
|su 2Y2' 41/t' 0
G'arms
V+'
41/+' 15r/z'
0
H
shelf skiils
lq' 31/2' 42Y2' 0
I seat skirts lt'
21/2" 421/2"
0
J* seat and shelf
Vq"
16Y4' 4t|" E0
K
back
rails {r' 2Y2' 42Yz' O
L
slats ls'
1r7ro'
9%'
O
M'fillers
Ya' Vao 3' 0
18
-Parts
initially cut oversize.
See
the
instructions.
Materials Key:
OP<ak
plywood,
O+ak,
EO-edge-
joined
oak.
Supplies:
#8x11+'flathead wood screws
(41,
#8x1lz"
flathead wood
screws
(6),
#8x2'flathead wood screws
(24),
spray adhesive.
Blades and bits:
Stack
dado set; 7a'
plug
cutter;
t/n'
straight,
t/e'
and
t/+"
round-over router bits.
Brrying Guide
Veneer. Flat-cut red
oak
veneer,2x8'
paper-backed
no.
H4028,
$19.95,
or
2x8'peel-and-stick no. H4029,
$39.95.
Also
available
in 4x8'sheets
and
19 different
species. Call Grizly
Industrial at
800/523-4777,
or
go
to
www.grizzly.com. Look for iron-on
veneer
at
your
local
home center or
woodworking
specialty store.
*Plane
or
resaw
to
the thickness listed in the Materials
List.
uprights, and fasten it in
place,
as shown
in Photo G. The back assembly's rails are
setV2" back from the angled edge of the
rear uprights
(B),
where
shown on
Drawing 1.
lf
Retrieve the
previously
made
plugs,
I
and
glue
them into ttre remaining
counterbores.
Sand
the
plugs
flush.
On to the
firrislr
I
Ctrect< all surfaces of the bench and
!
resand
areas that need it. Ease any
sharp
edges with a sanding block and
220-git sandpaper.
qrfi
you
wish, apply a stain. We used
frZAR
Salem Maple, following the
directions
on the can.I.etthe stain dry for
24
hours. Apply
a clear finish. We
brushed on two coats of
satin
poly-
urethane, sanding benveen coats with
z2}-gttsandpaper. i
Written
by
Jan Svec
with
Chuck
Hedlund
Project
design: Kevin Boyle
I llustrations: Roxanne LeMoine;
Loma Johnson
Photographs:
Marty Baldrvin
crrlting
diagrann
:-..---.@
:::-::::-.._.-.
G)
/cx5U2
x
96" Oak
{qx9Ya
x 96"
Oak
(2
w w
fH) fD\
-\_:/
{rx7l+ x 96"
Oak
/cx24x24'Oak
plywood
47