Operating instructions

ManualsBrandsRV Products ManualsAir Conditioner8000 Series

NRVP

RV Products

A Division

AIRXCEL, Inc.

OPERATION AND MAINTENANCE INSTRUCTIONS

FOR 7000 & 8000 SERIES

ROOF TOP AIR CONDITIONERS

AND

7300 SERIES CEILING PLENUMS

MODE D'EMPLOI ET UTILISATION

DES CLIMATISEURS DE TOIT DES

SERIES 7000 ET 8000 ET

PLENUM DE PLAFOND DE LA SERIE 7300

BETRIEBS- UND WARTUNGSANLEITUNG

FUR DACHSEITIGE KLIMAANLAGEN

DER SERIEN 7000 & 8000

UND INTEGRIERTE VERTEILERSCHACHTE DER SERIE 7300

INSTRUCCIONES PARA LA OPERACION Y EL

MANTENIMIENTO DE LOS DISPOSITIVOS DE AIRE

ACONDICIONADO PARA MONTAJE ENCIMA DEL

TECHO DE LAS SERIES 7000 Y 8000 Y DE LOS

VENTILADORES IMPELENTES PARA

TECHO DE LA SERIE 7300

Summary of content (12 pages)

PAGE 1
NRVP RV Products A Division of AIRXCEL, Inc.
PAGE 2
TABLE OF CONTENTS I. II. III. IV. V. VI. VII.
PAGE 3
B. The Thermostat (temperature control) - In the cooling mode, the thermostat regulates the "ON" and "OFF" temperature setting at which the compressor will operate. C. Louvers - The louvers are located at both ends of the ceiling assembly shroud and are used in directing the discharge air from the unit. For "Heat/Cool" models, the thermostat also controls the "ON" and "OFF" temperature settings of the heater assembly. See Figures 1 and 2.
PAGE 4
II. Do not expect the heating coil on your heater to glow. Because the fan draws in cold air and forces it over the coil, the coil will not turn red. A hint of red may occur where the moving air does not directly touch the coil. Operation During Cooler Nights (Cooling Operation). It is important, when the outdoor temperature drops in the evening or during the night to below 75°F, that the thermostat (temperature control) be set at a midpoint between "Warmer" and "Cooler".
PAGE 5
SECTION IV - MAINTENANCE 1. 6. Owner One of the biggest advantages to your new RV Products air conditioner is that the maintenance needed to keep the unit in good care is minimal. In fact about the only thing you, the owner, must take care of is the cleaning and replacement of the filters. Remove filter from grill and either clean or exchange with new filters. NOTE If replacement filters are necessary, the filters can be purchased from most RV Products Authorized Service Centers.
PAGE 6
shape. Also, an examination of the plastic shroud covering the air conditioner on the top of the roof should be made periodically. Be sure the four mounting screws and washers are snug and holding the shroud to the air conditioner. Also examine the shroud to be sure it is not developing cracks or has suffered damage from impact. If the air conditioner continues to trip off the circuit breakers, have an electrician check the starting amperage and running amperage on the unit.
PAGE 7
OPERATION The chart below shows the system functions with the "Heat/Cool" thermostat. After the entire air conditioning system (and furnace system) is installed, check each position function. Disregard references to heat functions when using the "Cool Only" thermostat. ■ SHOWS POSITION OF SWITCH SYSTEM HEAT COOL OFF FAN ■ ■ 0 0 ■ ■ ■ ■ ■ ■ FAN ON AUTO HI LO LO HI OPERATION No functions occur. Air conditioner fan runs at high speed continuously regardless of fan switch setting or setpoint.
PAGE 8
SECTION VI - OPTIONAL SOLAR BATTERY CHARGERS FOR RV PRODUCTS AIR CONDITIONERS OPERATING INSTRUCTIONS RV Products supplies custom engineered photovoltaic systems using the highest quality components available. To enjoy the maximum benefit from your solar maintenance system, please take a few moments to read the important information in this section. This maintenance kit provides a single 5 watt solar panel mounted on top of the RV Products air conditioner shroud, located on the roof.
PAGE 9
CUT APPLICATION FOR OPTIONAL FOUR (4) YEAR COMPRESSOR PARTS CONTRACT (DOES NOT INCLUDE LABOR) APPLICATION MUST BE MADE WITHIN 90 DAYS OF PURCHASE DATE OF THE AIR CONDITIONER OR THE RECREATIONAL VEHICLE IF THE AIR CONDITIONER IS ORIGINAL EQUIPMENT. Date of Purchase (Air Conditioner) Air Conditioner Model Number Air Conditioner Serial Number Name of Purchaser Address City State Zip BE SURE TO ENCLOSE A CHECK OR MONEY ORDER FOR $39.
PAGE 10
SECTION VII - WARRANTY SERVICE The optional four year parts contract begins upon the expiration of the initial warranty. Before applying, carefully read the parts contract reproduced on the back page of this manual. Let's face it. Sometimes even the best products may need service. If that's true of your RV Products air conditioner, you can get service on your unit at most of the firms listed in the Authorized Service Center List included with your product.
PAGE 11
r4nva OPTIONAL FOUR YEAR COMPRESSOR REPLACEMENT CONTRACT RV Products 0 4 AIHXCEL, NOT RENEWABLE A/C MODEL NUMBER CONTRACT # RECREATIONAL VEHICLE AIR CONDITIONING COMPRESSORS (OPTIONAL at ADDITIONAL COST) A/C SERIAL NUMBER EFFECTIVE COMPRESSOR CONTRACT DATE NOT REFUNDABLE SAMPLE See Cut Out Application in This Publication 1.
PAGE 12
NRVP RV Products A Division of AIRXCEL, Inc. RV Products A Division of Airxcel, Inc. P.O.