Unit installation

2
TABLE OF CONTENTS
1. Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
2. Component Match-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
3. Unit Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
4. Unit Depiction Figures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
5. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
6. Unit Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
7. Duct Mounting and Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
8. Duct and Register Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
9. 115 VAC Electrical Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
10. Thermostat and 12 VDC Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
11. Checkout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
1. WARNINGS
IMPORTANT NOTICE
These instructions are for the use of qualified individuals
specially trained and experienced in installation of this type
equipment and related system components.
Installation and service personnel are required by some states
to be licensed. PERSONS NOT QUALIFIED SHALL NOT
INSTALL NOR SERVICE THIS EQUIPMENT.
NOTE
The words “Shall” or “Must” indicate a requirement which is
essential to satisfactory and safe product performance.
The words “Should” or “May” indicate a recommendation or
advice which is not essential and not required but which may
be useful or helpful.
WARNING
DO NOT PERFORM A DIELECTRIC
STRENGTH TEST (HYPOT) ON 6535
SERIES HEAT PUMPS. DAMAGE TO
PRINTED CIRCUIT BOARD MAY
RESULT.
WARNING - SHOCK HAZARD
To prevent the possibility of severe personal injury or
equipment damage due to electrical shock, always be sure
the electrical power source to the appliance is
disconnected.
CAREFULLY FOLLOW ALL INSTRUCTIONS AND
WARNINGS IN THIS BOOKLET TO AVOID DAMAGE
TO THE EQUIPMENT, PERSONAL INJURY OR FIRE.
WARNING
Improper installation may damage equipment, can create a
hazard and will void the warranty.
The use of components not tested in combination with
these units will void the warranty, may make the
equipment in violation of state codes, may create a hazard
and may ruin the equipment.