MSDS

Date Printed: 5/1/2015
HANDLIN G: Wash thoroughly after handling. Wash hands before eating. Remove contaminated clothing and launder before
reuse. Use only with adequate ventilation. Follow all MSDS/label precautions even after container is emptied because it may retain
product residues. Avoid breathing fumes, vapors, or mist. Avoid contact with eyes, skin and clothing.
STORAGE: Product should be stored in tightly sealed containers and protected from heat, moisture, and foreign materials. Store
in a dry, well ventilated place. Keep container tightly closed when not in use. Keep containers tightly closed. Isolate from heat,
electrical equipment, sparks and open flame. Keep away from heat, sparks, flame and sources of ignition. Avoid excess heat. Do
not store above 120 ° F. Store large quantities in buildings designed and protected for storage of NFPA Class II combustible liquids.
8. Exposure Controls/Personal Protection
Chem ica l N a m e CAS-No.
W eight %
Less Than
ACGIH T LV-
TW A
ACGIH T LV-
STEL
OSHA PEL-
TW A
OSHA PEL-
CEILING
1-Methoxy-2-propyl acetate 108-65-6 40.0
50 ppm (AIHA
WEEL)
N.E. N.E. N.E.
Toluene 108-88-3 30.0 20 ppm N.E. 200 ppm 300 ppm
Stoddard Solvent 8052-41-3 5.0 100 ppm N.E. 500 ppm N.E.
Xylene (mixed isomers) 1330-20-7 5.0 100 ppm 150 ppm 100 ppm N.E.
Aluminum Flake 7429-90-5 5.0 1 mg/ m3 N.E.
15 mg/ m3 [Total
Dust]
N.E.
Carbon Black 1333-86-4 1.0
3 mg/ m3
(Inhalable Dust)
N.E. 3.5 mg/ m3 N.E.
Ethylbenzene 100-41-4 1.0 20 ppm 125 ppm 100 ppm N.E.
PERSONAL PR OTECTION
EN GINEERIN G CON TROLS: Use process enclosures, local exhaust ventilation, or other engineering controls to control airborne
levels below recommended exposure limits. Prevent build-up of vapors by opening all doors and windows to achieve cross-
ventilation.
RESPIRATOR Y PROTECTION: A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 requirements must
be followed whenever workplace conditions warrant a respirator's use. A NIOSH/MSHA approved air purifying respirator with an
organic vapor cartridge or canister may be permissible under certain circumstances where airborne concentrations are expected to
exceed exposure limits.
Protection provided by air purifying respirators is limited. Use a positive pressure air supplied respirator if there is any potential for
an uncontrolled release, exposure levels are not known, or in any other circumstances where air purifying respirators may not
provide adequate protection.
SKIN PROTECTION: Use gloves to prevent prolonged skin contact. Nitrile or Neoprene gloves may afford adequate skin
protection.
EYE PR OTECTION: Use safety eyewear designed to protect against splash of liquids.
OTH ER PR OTECTIVE EQUIPM EN T: Refer to safety supervisor or industrial hygienist for further guidance regarding types of
personal protective equipment and their applications.
HYGIENIC PRACTICES: Wash thoroughly with soap and water before eating, drinking or smoking. Remove contaminated
clothing immediately and launder before reuse.
9. Physical and Chemical Properties
Appeara n ce : Liquid Ph ysical State: Liquid
Odor: Solvent Like Odor Thre shold : N.E.
Relative D ensi ty: 0.982 pH: N.A.
Fre e ze Point, °C: N.D. Viscosity: No Information
So l u bility in Wate r: Slight Partiti o n Co e ffi cien t, n -
octa nol/w a te r:
No Information
Deco m p o sti o n Tem p ., °C: No Information
Bo i ling Range, °C: 223 - 410 Explosive L i m i ts, vo l%: 0.9 - 9.5
Flam m ability: Does not Support Combustion Flash Po i n t, °C: 13
Eva p o ration Rate : Slower than Ether Auto -igniti on Tem p ., °C: No Information
Vapor D e n sity: Heavier than Air Vapor Pre ssure : No Information
(See "Other information" Section for abbreviation legend)
Page 4 / 8