SDS

ManualsBrandsRust-Oleum Automotive ManualsPaint1-qt. Gray Auto Body Low VOC Primer (2-Pack)

SAFETY DATA SHEET

1. Identification

Product identifier LOW VOC GRAY PRIMER

Other means of identification

Product Code

ROB-262275

Recommended use

Automotive Refinish Laquer Primer

Manufacturer/Importer/Supplier/Distributor information

Manufacturer

Rust-Oleum Corporation

Address

11 Hawthorn Parkway

Company name

Contact person

Website

Telephone

Information 866-585-8430

Emergency phone number

24 Hour Assistance 847-367-7700

Meghan Gaughen

E-mail

United States

www.rustoleum.com

MGaughan@rustoleum.com

Vernon Hills, Illinois 60061

2. Hazard(s) identification

Category 2Flammable liquids

Physical hazards

Category 2ASerious eye damage/eye irritation

Health hazards

Category 1Sensitization, skin

Category 2Germ cell mutagenicity

Category 2Carcinogenicity

Category 1Reproductive toxicity

Category 3 narcotic effectsSpecific target organ toxicity, single exposure

Category 2Hazardous to the aquatic environment, acute

hazard

Environmental hazards

Category 3Hazardous to the aquatic environment,

long-term hazard

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Highly flammable liquid and vapor. May cause an allergic skin reaction. Causes serious eye

irritation. May cause drowsiness or dizziness. Suspected of causing genetic defects. Suspected of

causing cancer. May damage fertility or the unborn child. Toxic to aquatic life. Harmful to aquatic

life with long lasting effects.

Precautionary statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Keep

container tightly closed. Ground/bond container and receiving equipment. Use only non-sparking

tools. Take precautionary measures against static discharge. Avoid breathing mist or vapor. Use

only outdoors or in a well-ventilated area. Contaminated work clothing must not be allowed out of

the workplace. Avoid release to the environment. Wear protective gloves/protective clothing/eye

protection/face protection.

1 / 13

Material name: LOW VOC GRAY PRIMER

ROB-262275 Version #: 01 Issue date: 05-08-2015

SDS US

Summary of content (13 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier LOW VOC GRAY PRIMER Other means of identification Product Code ROB-262275 Recommended use Automotive Refinish Laquer Primer Manufacturer/Importer/Supplier/Distributor information Manufacturer Company name Address Telephone Website E-mail Contact person Emergency phone number Rust-Oleum Corporation 11 Hawthorn Parkway Vernon Hills, Illinois 60061 United States Information www.rustoleum.com MGaughan@rustoleum.
PAGE 2
Response If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. If inhaled: Remove person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If exposed or concerned: Get medical advice/attention. If skin irritation or rash occurs: Get medical advice/attention. If eye irritation persists: Get medical advice/attention.
PAGE 3
Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Vapors may form explosive mixtures with air. Vapors may travel considerable distance to a source of ignition and flash back. This product is a poor conductor of electricity and can become electrostatically charged. If sufficient charge is accumulated, ignition of flammable mixtures can occur. To reduce potential for static discharge, use proper bonding and grounding procedures.
PAGE 4
Conditions for safe storage, including any incompatibilities Store locked up. Keep away from heat, sparks and open flame. Prevent electrostatic charge build-up by using common bonding and grounding techniques. Eliminate sources of ignition. Avoid spark promoters. Ground/bond container and equipment. These alone may be insufficient to remove static electricity. Store in a cool, dry place out of direct sunlight. Store in original tightly closed container. Store in a well-ventilated place.
PAGE 5
US. NIOSH: Pocket Guide to Chemical Hazards Components Type isopropanol (CAS 67-63-0) STEL TWA Magnesium carbonate (CAS 546-93-0) TWA Talc (CAS 14807-96-6) Toluene (CAS 108-88-3) TWA STEL acetone (CAS 67-64-1) Ethyl benzene (CAS 100-41-4) 50 mg/l 0.15 g/g isopropanol (CAS 67-63-0) 40 mg/l Toluene (CAS 108-88-3) 0.3 mg/g 0.03 mg/l 0.02 mg/l Form 1225 mg/m3 500 ppm 980 mg/m3 400 ppm 5 mg/m3 Respirable.
PAGE 6
Form Liquid. Color Grey Opaque. Odor Solvent. Odor threshold Not available. pH Not available. Melting point/freezing point -138.46 °F (-94.7 °C) estimated Initial boiling point and boiling range 132.89 °F (56.05 °C) estimated Flash point -4.0 °F (-20.0 °C) estimated Evaporation rate Not available. Flammability (solid, gas) Not applicable. Upper/lower flammability or explosive limits 2.6 % estimated Flammability limit - lower (%) Flammability limit - upper (%) 12.
PAGE 7
Eye contact Causes serious eye irritation. Ingestion Expected to be a low ingestion hazard. Symptoms related to the physical, chemical and toxicological characteristics Headache. May cause drowsiness and dizziness. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. May cause an allergic skin reaction. Dermatitis. Rash. Information on toxicological effects Acute toxicity Components Narcotic effects.
PAGE 8
Components Species Test Results 14.1 ml/kg Inhalation LC50 Mouse 5320 ppm, 8 Hours 400 ppm, 24 Hours Rat 26700 ppm, 1 Hours 12200 ppm, 2 Hours 8000 ppm, 4 Hours Oral LD50 Rat 2.6 g/kg * Estimates for product may be based on additional component data not shown. Prolonged skin contact may cause temporary irritation. Skin corrosion/irritation Causes serious eye irritation. Serious eye damage/eye irritation Respiratory or skin sensitization Not a respiratory sensitizer.
PAGE 9
Components Species Test Results Bluegill (Lepomis macrochirus) > 1400 mg/l, 96 hours isopropanol (CAS 67-63-0) Aquatic Fish LC50 Titanium dioxide (CAS 13463-67-7) Aquatic Crustacea EC50 Water flea (Daphnia magna) > 1000 mg/l, 48 hours Fish LC50 Mummichog (Fundulus heteroclitus) > 1000 mg/l, 96 hours Aquatic Crustacea EC50 Water flea (Daphnia magna) 5.46 - 9.83 mg/l, 48 hours Fish LC50 Coho salmon,silver salmon (Oncorhynchus kisutch) 8.
PAGE 10
UN proper shipping name Transport hazard class(es) Class Subsidiary risk Packing group Environmental hazards ERG Code Special precautions for user Other information Passenger and cargo aircraft Cargo aircraft only IMDG UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Packing group Environmental hazards Marine pollutant EmS Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Paint, Paint Related Material 3 II No.
PAGE 11
Ethyl benzene (CAS 100-41-4) Listed. isopropanol (CAS 67-63-0) Listed. Nitrocellulose (CAS 9004-70-0) Listed. Toluene (CAS 108-88-3) Listed. SARA 304 Emergency release notification Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. Superfund Amendments and Reauthorization Act of 1986 (SARA) Immediate Hazard - Yes Hazard categories Delayed Hazard - Yes Fire Hazard - Yes Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance Not listed.
PAGE 12
isopropanol (CAS 67-63-0) Magnesium carbonate (CAS 546-93-0) Nitrocellulose (CAS 9004-70-0) Talc (CAS 14807-96-6) Titanium dioxide (CAS 13463-67-7) Toluene (CAS 108-88-3) US. New Jersey Worker and Community Right-to-Know Act acetone (CAS 67-64-1) Dibutyl Phthalate (CAS 84-74-2) Ethyl benzene (CAS 100-41-4) isopropanol (CAS 67-63-0) Magnesium carbonate (CAS 546-93-0) Nitrocellulose (CAS 9004-70-0) Talc (CAS 14807-96-6) Titanium dioxide (CAS 13463-67-7) Toluene (CAS 108-88-3) US.
PAGE 13
Country(s) or region Philippines Inventory name Philippine Inventory of Chemicals and Chemical Substances (PICCS) United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory On inventory (yes/no)* No No *A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s)